Albino A. Dias

Modification of wheat straw lignin by solid state fermentation with white-rot fungi

The potential of crude enzyme extracts, obtained from solid state cultivation of four white-rot fungi (Trametes versicolor, Bjerkandera adusta, Ganoderma applanatum and Phlebia rufa), was exploited to modify wheat straw cell wall. At different fermentation times, manganese-dependent peroxidase (MnP), lignin peroxidase (LiP), laccase, carboxymethylcellulase (CMCase), avicelase, xylanase and feruloyl esterase activities were screened and the content of lignin as well as hydroxycinnamic acids in fermented straw were determined. All fungi secreted feruloyl esterase while LiP was only detected in crude extracts from B. adusta. Since no significant differences (P>0.05) were observed in remaining lignin content of fermented straw, LiP activity was not a limiting factor of enzymatic lignin removal process. The levels of esterified hydroxycinnamic acids degradation were considerably higher than previous reports with lignocellulosic biomass. The data show that P. rufa, may be considered for more specific studies as higher ferulic and p-coumaric acids degradation was observed for earlier incubation times.

Enzymatic saccharification of biologically pre-treated wheat straw with white-rot fungi

Wheat straw was submitted to a pre-treatment by the basidiomycetous fungi Euc-1 and Irpex lacteus, aiming to improve the accessibility of cellulose towards enzymatic hydrolysis via previous selective bio-delignification. This allowed the increase of substrate saccharification nearly four and three times while applying the basidiomycetes Euc-1 and I. lacteus, respectively. The cellulose/lignin ratio increased from 2.7 in the untreated wheat straw to 5.9 and 4.6 after the bio-treatment by the basidiomycetes Euc-1 and I. lacteus, respectively, thus evidencing the highly selective lignin biodegradation. The enzymatic profile of both fungi upon bio-treatment of wheat straw have been assessed including laccase, manganese-dependent peroxidase, lignin peroxidase, carboxymethylcellulase, xylanase, avicelase and feruloyl esterase activities. The difference in efficiency and selectivity of delignification within the two fungi treatments was interpreted in terms of specific lignolytic enzyme profiles and moderate xylanase and cellulolytic activities.

Discrimination among eight modified michaelis-menten kinetics models of cellulose hydrolysis with a large range of substrate/enzyme ratios: inhibition by cellobiose.

The kinetics of exoglucanase (Cel7A) from Trichoderma reesei was investigated in the presence of cellobiose and 24 different enzyme/Avicel ratios for 47 h, in order to establish which of the eight available kinetic models best explained the factors involved. The heterogeneous catalysis was studied and the kinetic parameters were estimated employing integrated forms of Michaelis-Menten equations through the use of nonlinear least squares. It was found that cellulose hydrolysis follows a model that takes into account competitive inhibition by cellobiose (final product) with the following parameters: Km=3.8 mM, Kic=0.041 mM, kcat=2 h−1 (5.6×10−4 s−1). Other models, such as mixed type inhibition and those incorporating improvements concerning inhibition by substrate and parabolic inhibition, increased the modulation performance very slightly. The results support the hypothesis that nonproductive enzyme substrate complexes, parabolic inhibition, and enzyme inactivation (Selwyn test) are not the principal constraints in enzymatic cellulose hydrolysis. Under our conditions, the increment in hydrolysis was not significant for substrate/enzyme ratios <6.5.

Influence of ligninolytic enzymes on straw saccharification during fungal pretreatment.

Solid state and submerged fermentations in the presence of white-rot basidiomycetes (Bjerkandera adusta, Fomes fomentarius, Ganoderma resinaceum, Irpex lacteus, Phanerochaete chrysosporium, Trametes versicolor and basidiomycete Euc-1) and the litter-decomposing basidiomycete Lepista nuda were evaluated as a pretreatment to increase enzymatic saccharification of wheat straw. Enzymatic hydrolysis of holocellulose after solid state pretreatment showed a significant (P<0.05) increase of saccharification process for T. versicolor, Euc-1, G. resinaceum and I. lacteus, being T. versicolor (strain Tv2) the best one with a sugar yield increase of 91% compared with untreated straw. In submerged medium the pretreatment with I. lacteus, Euc-1 and P. chrysosporium enhanced saccharification but at a lesser extent. Covariance analysis was used to evaluate the relationships between ligninolytic enzymes (lignin peroxidase, manganese-dependent peroxidase and laccase) and saccharification increase. Results showed that only the presence of lignin peroxidase during pretreatment can lead to a significant (P<0.05) increase in the saccharification yield.

Screening of fungal isolates and properties of ganoderma applanatum intended for olive mill wastewater decolourization and dephenolization

Aims:  To investigate different autochthonous isolates of wood‐rotting fungi for the removal of both colour and phenolic compounds from olive mill wastewaters (OMW).

The potential of white‐rot fungi to degrade phorbol esters of Jatropha curcas L. seed cake

The potential of solid‐state cultivation, with three white‐rot fungi (Bjerkandera adusta, Ganoderma resinaceum and Phlebia rufa), to decrease phorbol esters concentration of Jatropha curcas L. was evaluated in this study. Incubation was conducted in 250 mL Erlenmeyer flasks without agitation at 28°C for 30 days. Phorbol esters were analyzed by reverse‐phase HPLC after an extraction procedure using dichloromethane. All fungi studied were able to decrease the concentration of phorbol esters, mainly B. adusta and P. rufa which significantly reduced (p<0.05) phorbol esters contents to non‐toxic levels. These results suggest that white‐rot fungi could be potentially used as a possible approach for the biological treatment of the oilseed cake.

Influence of culture medium growth variables on Ganoderma lucidum exopolysaccharides structural features

In this work the effect of carbon and nitrogen levels and initial pH of the wheat extract culture medium of submerged culture of Ganoderma lucidum on the amount, purity and structural features of exopolysaccharides (EPS) were studied. A low peptone level (1.65 g L(-1)) favored mycelium biomass, EPS purity, but a higher supply of peptone (4.80 g L(-1)) is needed for maximum EPS production. The carbohydrate composition of the EPS and structural features also changed significantly according to the different growing conditions, being observed significant differences in the (1 → 3)/(1 → 4)-Glcp ratio and also on the branching degree of EPS. As the biological activities of EPS are highly dependent on the polysaccharide structural features, this variability can have implications on the EPS biological activities, but can also be used advantageously to produce tailor made polysaccharides with specific applications.

Winery wastewater treatment by combination of Cryptococcus laurentii and Fenton's reagent.

Winery wastewaters (WW) have high levels of organic matter, resulting in high COD and BOD and suspended solids. This paper studies the combination of biological and chemical processes in WW treatment. Among 10 yeast isolates, Filobasidium sp. (AGG 577) and Cryptococcus laurentii (AGG 726) were selected due to their superior performance in COD removal. During WW degradation, COD and total polyphenols (TPP) content removal of 89-90% for Filobasidium sp. and 90-93% for C. laurentii were obtained. However, despite similar degradation efficiency for both yeasts, COD kinetics and pH evolution during treatment reveals that C. laurentii presents a faster response than Filobasidium sp. The toxicity (inhibition of Vibrio fischeri luminescence) of C. laurentii treated WW decreases to an inhibition value below 2.5%. However, treated WW exceeds the legal limits, making necessary an additional treatment. In this case, the selection of Fentons reagent as a chemical final polish step process is a good compromise between efficiency and lower practical complexity. The best results for both COD and TPP removal were obtained with H2O2 initial concentration of 39.2mM and a H2O2:Fe(2+) molar ratio of 15:1. The combined C. laurentii - Fentons reagent treatment of WW achieved a total reduction of 98% and 96%, for COD and TPP, respectively.

Gallic acid photochemical oxidation as a model compound of winery wastewaters

Winery wastewaters (WW) are characterized by their high organic load and by the presence of non-biodegradable compounds such as phenolic compounds. This study was undertaken to evaluate the capacity of different Advanced Oxidation Processes (AOP) combined with several radiation sources to degrade the phenolic compound Gallic Acid (GA). A toxicological assessment was also carried out to evaluate the subproducts harmful effect generated during the most efficient AOP in the GA photoxidation. Through the course of the study it was verified that the UV radiation lamp TNN 15/32 showed the capacity to degrade 34.7% of GA, the UV radiation lamp TQ 150 achieved a value of 20.2% and the solar radiation presented only a value of 2.3% in 60 minutes. The combination of different advanced oxidation processes (Fentons reagent, ferrioxalate and heterogeneous photocatalysis) were evaluated with the previously studied sources of radiation. From the experiments conducted it was possible to suggest that the AOP in combination with Fe2 + + H2O2 + UV TNN 15/32 (photo-Fenton process) was the most efficient process thereby achieving the GA degradation value of 95.6% in 7.5 minutes and resulting in a total elimination of toxicity.

Utilization of integrated Michaelis-Menten equations for enzyme inhibition diagnosis and determination of kinetic constants using Solver supplement of Microsoft Office Excel

Enzyme kinetic parameters are usually determined from initial rates nevertheless, laboratory instruments only measure substrate or product concentration versus reaction time (progress curves). To overcome this problem we present a methodology which uses integrated models based on Michaelis-Menten equation. The most severe practical limitation of progress curve analysis occurs when the enzyme shows a loss of activity under the chosen assay conditions. To avoid this problem it is possible to work with the same experimental points utilized for initial rates determination. This methodology is illustrated by the use of integrated kinetic equations with the well-known reaction catalyzed by alkaline phosphatase enzyme. In this work nonlinear regression was performed with the Solver supplement (Microsoft Office Excel). It is easy to work with and track graphically the convergence of SSE (sum of square errors). The diagnosis of enzyme inhibition was performed according to Akaike information criterion.