Andrew R. Barber

Facile Pretreatment of Bacillus circulans β-Galactosidase Increases the Yield of Galactosyl Oligosaccharides in Milk and Lactose Reaction Systems

The commercially available preparation of beta-galactosidase from Bacillus circulans , known as Biolacta FN5, has been extensively used in the production of prebiotic galactooligosaccharides (GOS). This study focuses on characterizing the production of GOS in two reaction systems: 10% lactose (w/v) in buffer and skim milk. Analysis of the temperature dependence of the GOS yield along with the relative rates of GOS synthesis and degradation leads to the finding that GOS degradation activity was selectively decreased in Biolacta FN5 above 40 degrees C. Facile heat treatment of Biolacta FN5 solution prior to use allowed for GOS yields to be significantly increased in both reaction systems.

Effect of the Substrate Concentration and Water Activity on the Yield and Rate of the Transfer Reaction of β-Galactosidase from Bacillus circulans

Prebiotic galactosyl oligosaccharides (GOS) are produced from lactose by the enzyme β-galactosidase. It is widely reported that the highest GOS levels are achieved when the initial lactose concentration is as high as possible; however, little evidence has been presented to explain this phenomenon. Using a system composed of the commercial β-galactosidase derived from Bacillus circulans known as Biolacta FN5, lactose and sucrose, the relative contribution of water activity, and substrate availability were assessed. Oligosaccharide levels did not appear to be affected by changes in water activity between 1.0 and 0.77 at a constant lactose concentration. The maximum oligosaccharide concentration increased at higher initial concentrations of lactose and sucrose, while initial reaction rates for transfer increased but remained constant for hydrolysis. This suggests that the high oligosaccharide levels achieved at the raised initial saccharide concentration are due to increases in reactions that form oligosaccharides rather than decreases in concurrent reactions, which degrade oligosaccharides. There were different effects from changing the initial concentration of lactose compared to sucrose, suggesting that the ability of lactose to act as a donor saccharide may be more important for increasing maximum oligosaccharide concentrations than the combined ability of both saccharides to act as galactosyl acceptors.

Significant Enrichment of Polyunsaturated Fatty Acids (PUFAs) in the Lipids Extracted by Supercritical CO2 from the Livers of Australian Rock Lobsters (Jasus edwardsii).

Australian rock lobster (Jasus edwardsii) liver contains approximately 24.3% (w/w) lipids, which can contain a high amount of polyunsaturated fatty acids (PUFAs). However, this material has been found to be contaminated with arsenic (240 mg/kg) and cadmium (8 mg/kg). The high level of contaminants in the raw material and the large amount of PUFAs in the lipids prove a significant challenge in the extraction of high-quality lipids from this byproduct by conventional methods. Supercritical carbon dioxide (SC-CO2) extraction is a highly promising technology for lipid extraction with advantages including low contamination and low oxidation. The technique was optimized to achieve nearly 94% extraction of lipids relative to conventional Soxhlet extraction in Australian rock lobster liver at conditions of 35 MPa and 50 °C for 4 h. The extracted lipids are significantly enriched in PUFAs at 31.3% of total lipids, 4 times higher than those in the lipids recovered by Soxhlet extraction (7.8%). Specifically, the concentrations of docosahexaenoic acid (DHA) and eicosapentaenoic acid (EPA) in SC-CO2 extraction are 7 times higher than those obtained by Soxhlet extraction. Moreover, very small amounts of toxic heavy metals such as lead (Pb), arsenic (As), mercury (Hg), and cadmium (Cd) were detected in the SC-CO2-extracted lipids, 0.5-27 times lower than those in the Soxhlet-extracted lipids, which are 40-200 times lower than the regulatory limit maximum values. The low levels of contaminants and the high proportion of PUFAs (dominated by DHA and EPA) found in the SC-CO2-extracted lipids from Australian rock lobster liver suggest that the material could potentially be used as a valuable source of essential fatty acids for human consumption.