Björn Vinnerås

Inactivation of bacteria and viruses in human urine depending on temperature and dilution rate.

Source separation and reuse of human urine can decrease the environmental pollution of recipient waters and reduce the need for artificial mineral fertilisers. However, the reuse of urine introduces another pathogen transmission route that needs to be managed. The inactivation of enteric pathogens and model organisms (Salmonella enterica subspecies 1 serovar Typhimurium (S. typhimurium), Enterococcus faecalis, bacteriophages S. typhimurium 28B, MS2 and Phi x 174) by urine storage was studied at dilutions (urine:water) 1:0, 1:1 and 1:3 at temperatures 4, 14, 24 and 34 degrees C. A threshold concentration of ammonia was found at approximately 40 mM NH(3) (e.g. 2.1 g NH(3)-NL(-1) and pH 8.9 at 24 degrees C), below which all studied organisms, except Salmonella, persisted considerably longer irrespective of treatment temperature, showing that urine dilution rate is of great importance for pathogen inactivation. For Salmonella spp. no threshold level was found in these studies (15 mM NH(3) lowest concentration studied). At temperatures below 20 degrees C, bacteriophage reduction was very slow. Therefore, urine stored at temperatures below 20 degrees C carries a high risk of containing viable viruses. The study indicated that the current recommended storage time for urine of 6 months at 20 degrees C or higher is safe for unrestricted use and could probably be shortened, especially for undiluted urine.

Thermal composting of faecal matter as treatment and possible disinfection method--laboratory-scale and pilot-scale studies.

When using toilets where the urine and faeces are collected separately for reuse as nutrients in agriculture, the collected matter should be disinfected. One way to do this is by thermal composting. Composting of different material mixes was investigated in a laboratory-scale experiment. This showed that the best mixture for dry thermal composting was a mix of faeces, food waste and amendment. The urine was collected separately by use of urine-diverting toilets. A new method was developed to mathematically evaluate and estimate the safety margins of pathogen inactivation during thermal composting. The method is based upon a mathematical calculation of the number of times total inactivation (at least 12log(10) reduction) of the organisms is achieved. In a pilot-scale experiment, the disinfection of a faeces/food waste mix was performed with a calculated safety margin of more than 37 times the total die-off of Enteroviruses and some 550 times that of Ascaris. Thus, well functioning composting seems to be effective for disinfection of faecal matter. To get a high temperature in all of the material, the reactor has to have sufficient insulation. A major disadvantage is the initial need for handling the raw un-disinfected material. The degradation of the organic matter in the compost was almost 75%, resulting in a small final volume that could safely be recycled.

Fertiliser products from new sanitation systems: their potential values and risks.

The plant nutrients consumed in human society today are lost through the established wastewater treatment systems in industrialised countries as well as via insufficient or non-existent handling of sewage in the developing world. New sanitation systems have been designated to overcome this failure. The source separated wastewater streams collected within these systems contain a high nutrient content, and can be used as fertiliser as well as soil conditioner after appropriate storage and/or treatment. Application in agriculture with existing techniques is feasible. However, pathogens and pharmaceuticals contained in these fertiliser types are a potential hazard. Nevertheless, storage and appropriate treatment can minimise the risks. The products deriving from these systems have a high potential to preserve available plant nutrient resources and deficiencies in agriculture as well as being able to substitute synthetic plant nutrients and at the same time prevent unwanted environmental nutrient over-enrichment.

Inactivation of Ascaris Eggs in Source-Separated Urine and Feces by Ammonia at Ambient Temperatures

ABSTRACT Sustainable management of toilet waste must prevent disease transmission but allow reuse of plant nutrients. Inactivation of uterus-derived Ascaris suum eggs was studied in relation to ammonia in source-separated urine without additives and in human feces to which urea had been added, in order to evaluate ammonia-based sanitation for production of safe fertilizers from human excreta. Urine was used concentrated or diluted 1:1 and 1:3 with tap water at 4, 14, 24, and 34°C. Fecal material, with and without ash, was treated with 1% or 2% (wt/wt) urea at 24 and 34°C. At 34°C eggs were inactivated in less than 10 days in urine and in amended feces. At 24°C only feces with 2% (wt/wt) urea or 1% (wt/wt) urea at high pH (10) inactivated all eggs within 1 month, and no inactivation was observed after 75 days in urine diluted 1:3 (18 ± 11 mM NH3). At temperatures of ≥24°C, NH3 proved to be an efficient sanitizing agent in urine and feces at concentrations of ≥60 mM. Treating fecal material at 34°C can give a 6-log10 egg inactivation within 1 month, whereas at 24°C 6 months of treatment is necessary for the same level of egg inactivation. At temperatures of 14°C and below, inactivation rates were low, with viable eggs after 6 months even in concentrated urine.

The potential for disinfection of separated faecal matter by urea and by peracetic acid for hygienic nutrient recycling

No efficient, reliable, and scale independent disinfection methods for toilet waste are available today for safe recycling of plant nutrients. Therefore, two chemical treatment methods, addition of urea or of PAA (a quaternary mixture of 15% peracetic acid, 15% hydrogen peroxide and 30% acetic acid), were evaluated for disinfection of faecal matter.Degradation of the added urea resulted in 30 g of ammonia nitrogen per kilogram of treated matter and a pH increase to approximately 9.3. This produced an efficient disinfection of E. coli, Enterococcus spp., and Salmonella spp. within 3 weeks (>6log(10) reduction) and a reduction of the chemical resistant Salmonella typhimurium 28b phage, corresponding to a decimal reduction within 7.5 days. No viable Ascaris suum eggs were found after 50 days of treatment. No reduction of spore forming Clostridia spp. was observed. Urea treatment proved to be efficient for disinfection of source separated faecal matter in a scale independent method used for safe recycling of nutrients found in the faecal matter.PAA reduced all of the above indicator organisms within 12 h after application. For this faecal material, with a dry matter content of approximately 10%, an addition of 0.5-1% of PAA (active substance, corresponding to 3.3-6.7% of the Proxitane 15 used) was required before no viable organisms were found in the material. However, this was not tested for the A. suum. No viable spore-forming bacteria or phages were detected. A high rate of bacteria regrowth occurred at 0.15% dosage and 5 days of treatment. PAA is an efficient alternative for disinfection of separated faeces if a rapid treatment is needed.

Inactivation of Pathogens in Feces by Desiccation and Urea Treatment for Application in Urine-Diverting Dry Toilets

ABSTRACT Ecological sanitation technologies can be effective in providing health and environmental pollution control if they can efficiently reduce the pathogenicity of microorganisms carried in fecal material to safe levels. This study evaluated the sanitizing effects of different additives for dry treatment of feces from urine-diverting dry toilets, based on inactivation of Enterococcus faecalis, Salmonella enterica serovar Typhimurium, bacteriophages MS2 and ΦX, and Ascaris suum. The additives, ash (A) and oyster shell (O) in different amounts and urea (U) to optimize the process, were compared with no additive, solely urea, and sawdust as controls (C) and were covered ([x%O:A]) or uncovered (x%O:A). The main inactivation factors found were desiccation, ammonia content, and pH. S. Typhimurium and E. faecalis were more affected by the ammonia content. A combination of neutral to high pH and desiccation was most effective for inactivation of MS2, and desiccation was most effective for inactivation of ΦX and A. suum. The inactivation rate was modeled for all combinations studied. The most promising treatments were [150%O:A+U], 150%O:A+U, and 150%O:A. According to the models, these could inactivate, for example, 7 log10 units of all bacteria and bacteriophages within 83, 125, and 183 days, respectively. The inactivation of A. suum was modeled, albeit the measured decay in egg viability was low.

Variation of chemical and microbial parameters in collection and storage tanks for source separated human urine

Abstract To investigate if variations in concentrations occur at different levels within urine tanks and to evaluate possible consequences thereof, urine samples were collected from four collection tanks and one storage tank of different urine separating sewerage systems. Plant nutrients and metals were found to concentrate in the sediment at the bottom of the tanks. Also, densities of indicator bacteria were higher in the bottom layer, probably due to adsorption to sedimented particles. The differences in concentration at different levels became more apparent during storage of the urine mixture. After four months storage concentrations of the investigated indicator bacteria, except clostridia, were below detection limits at all levels. Considering the variability in nutrient concentration, samples from the middle level correspond well to the average composition in the tanks and can be used to calculate urine application rates. When estimating hygienic risks with the reuse of human urine the concentration variability also needs to be considered.

Faecal sludge management with the larvae of the black soldier fly (Hermetia illucens) — From a hygiene aspect

Inadequate and lacking sanitation and wastewater treatment systems can lead to the spreading of diarrhoeal diseases. One contributing factor in the lack of such treatment systems is the lack of economic incentives for stakeholders throughout the service chain. However, the organic fraction of the waste is high in valuable plant nutrients and could be reused in agriculture and as animal feed. For example, grown larvae of the black soldier fly, Hermetia illucens L. (Diptera: Stratiomyidae), make an excellent protein source in animal feed, while the feeding activity of the larvae substantially reduces the dry mass of the treated material. This study examined the effect of black soldier fly larvae on the concentration of pathogenic microorganisms in human faeces and found a 6 log10 reduction in Salmonella spp. in human faeces in eight days, compared with a <2 log10 reduction in the control. No increased reduction was observed for Enterococcus spp., bacteriophage ΦX174 or Ascaris suum ova.

Ammonia Disinfection of Hatchery Waste for Elimination of Single-Stranded RNA Viruses

ABSTRACT Hatchery waste, an animal by-product of the poultry industry, needs sanitation treatment before further use as fertilizer or as a substrate in biogas or composting plants, owing to the potential presence of opportunistic pathogens, including zoonotic viruses. Effective sanitation is also important in viral epizootic outbreaks and as a routine, ensuring high hygiene standards on farms. This study examined the use of ammonia at different concentrations and temperatures to disinfect hatchery waste. Inactivation kinetics of high-pathogenic avian influenza virus H7N1 and low-pathogenic avian influenza virus H5N3, as representatives of notifiable avian viral diseases, were determined in spiked hatchery waste. Bovine parainfluenza virus type 3, feline coronavirus, and feline calicivirus were used as models for other important avian pathogens, such as Newcastle disease virus, infectious bronchitis virus, and avian hepatitis E virus. Bacteriophage MS2 was also monitored as a stable indicator. Coronavirus was the most sensitive virus, with decimal reduction (D) values of 1.2 and 0.63 h after addition of 0.5% (wt/wt) ammonia at 14 and 25°C, respectively. Under similar conditions, high-pathogenic avian influenza H7N1 was the most resistant, with D values of 3.0 and 1.4 h. MS2 was more resistant than the viruses to all treatments and proved to be a suitable indicator of viral inactivation. The results indicate that ammonia treatment of hatchery waste is efficient in inactivating enveloped and naked single-stranded RNA viruses. Based on the D values and confidence intervals obtained, guidelines for treatment were proposed, and one was successfully validated at full scale at a hatchery, with MS2 added to hatchery waste.

Vermicomposting as manure management strategy for urban small-holder animal farms - Kampala case study

Inadequate organic waste management can contribute to the spread of diseases and have negative impacts on the environment. Vermicomposting organic waste could have dual beneficial effects by generating an economically viable animal feed protein in the form of worm biomass, while alleviating the negative effects of poor organic waste management. In this study, a low-maintenance vermicomposting system was evaluated as manure and food waste management system for small-holder farmers. A vermicomposting system using the earthworm species Eudrilus eugeniae and treating cow manure and food waste was set up in Kampala, Uganda, and monitored for 172days. The material degradation and protein production rates were evaluated after 63days and at the end of the experiment. The material reduction was 45.9% and the waste-to-biomass conversion rate was 3.5% in the vermicomposting process on a total solids basis. A possible increase in the conversion rate could be achieved by increasing the frequency of worm harvesting. Vermicomposting was found to be a viable manure management method in small-scale urban animal agriculture; the return of investment was calculated to be 280% for treating the manure of a 450kg cow. The vermicompost was not sanitised, although hygiene quality could be improved by introducing a post-stabilisation step in which no fresh material is added. The value of the animal feed protein generated in the process can act as an incentive to improve current manure management strategies.