Caroline Vanderghem

Influence of steam explosion on physicochemical properties and hydrolysis rate of pure cellulose fibers

The aim of this study is to compare the effect of different steam explosion treatments on the physicochemical properties and the hydrolysis rate of a pure bleached cellulose. The results showed that moderate steam explosion treatments (severity factor below 5.2) did not appear to improve the enzymatic hydrolysis rate of the cellulose fibers. However, characterization of the samples showed a modification of the physicochemical properties of the cellulose, resulting in an increase of the water retention values (WRV) coupled to an increase of the overall crystallinity. For higher treatment intensities, an important thermal degradation of the cellulose was highlighted. This thermal degradation caused an important modification of the cellulose composition which leads to a decrease of the hydrolysis rate.

Comparative biochemical analysis during the anaerobic digestion of lignocellulosic biomass from six morphological parts of Williams Cavendish banana (Triploid Musa AAA group) plants

We studied banana lignocellulosic biomass (BALICEBIOM) that is abandoned after fruit harvesting, and assessed its biochemical methane potential, because of its potential as an energy source. We monitored biogas production from six morphological parts (MPs) of the “Williams Cavendish” banana cultivar using a modified operating procedure (KOP) using KOH. Volatile fatty acid (VFA) production was measured using high performance liquid chromatography. The bulbs, leaf sheaths, petioles–midribs, leaf blades, rachis stems, and floral stalks gave total biogas production of 256, 205, 198, 126, 253, and 221xa0mlxa0g−1 dry matter, respectively, and total biomethane production of 150, 141, 127, 98, 162, and 144xa0mlxa0g−1, respectively. The biogas production rates and yields depended on the biochemical composition of the BALICEBIOM and the ability of anaerobic microbes to access fermentable substrates. There were no significant differences between the biogas analysis results produced using KOP and gas chromatography. Acetate was the major VFA in all the MP sample culture media. The bioconversion yields for each MP were below 50xa0%, showing that these substrates were not fully biodegraded after 188xa0days. The estimated electricity that could be produced from biogas combustion after fermenting all of the BALICEBIOM produced annually by the Cameroon Development Corporation–Del Monte plantations for 188xa0days is approximately 10.5xa0×xa0106 kWxa0h (which would be worth 0.80–1.58 million euros in the current market). This bioenergy could serve the requirements of about 42,000 people in the region, although CH4 productivity could be improved.

Effect of Physicochemical Characteristics of Cellulosic Substrates on Enzymatic Hydrolysis by Means of a Multi-Stage Process for Cellobiose Production

The effect of two types of cellulose, microcrystalline cellulose and paper pulp, on enzymatic hydrolysis for cellobiose production was investigated. The particle size, the relative crystallinity index and the water retention value were determined for both celluloses. A previously studied multistage hydrolysis process that proved to enhance the cellobiose production was studied with both types of celluloses. The cellobiose yield exhibited a significant improvement (120% for the microcrystalline cellulose and 75% for the paper pulp) with the multistage hydrolysis process compared to continuous hydrolysis. The conversion of cellulose to cellobiose was greater for the microcrystalline cellulose than for the paper pulp. Even with high crystallinity, microcrystalline cellulose achieved the highest cellobiose yield probably due to its highest specific surface area accessible to enzymes and quantity of adsorbed protein.

Comparative biochemical analysis after steam pretreatment of lignocellulosic agricultural waste biomass from Williams Cavendish banana plant (Triploid Musa AAA group).

The accessibility of fermentable substrates to enzymes is a limiting factor for the efficient bioconversion of agricultural wastes in the context of sustainable development. This paper presents the results of a biochemical analysis performed on six combined morphological parts of Williams Cavendish Lignocellulosic Biomass (WCLB) after steam cracking (SC) and steam explosion (SE) pretreatments. Solid (S) and liquid (L) fractions (Fs) obtained from SC pretreatment performed at 180°C (SLFSC180) and 210°C (SLFSC210) generated, after diluted acid hydrolysis, the highest proportions of neutral sugar (NS) contents, specifically 52.82 ± 3.51 and 49.78 ± 1.39 %w/w WCLB dry matter (DM), respectively. The highest proportions of glucose were found in SFSC210 (53.56 ± 1.33 %w/w DM) and SFSC180 (44.47 ± 0.00 %w/w DM), while the lowest was found in unpretreated WCLB (22.70 ± 0.71 %w/w DM). Total NS content assessed in each LF immediately after SC and SE pretreatments was less than 2 %w/w of the LF DM, thus revealing minor acid autohydrolysis consequently leading to minor NS production during the steam pretreatment. WCLB subjected to SC at 210°C (SC210) generated up to 2.7-fold bioaccessible glucan and xylan. SC and SE pretreatments showed potential for the deconstruction of WCLB (delignification, depolymerization, decrystallization and deacetylation), enhancing its enzymatic hydrolysis. The concentrations of enzymatic inhibitors, such as 2-furfuraldehyde and 5-(hydroxymethyl)furfural from LFSC210, were the highest (41 and 21 µg ml−1, respectively). This study shows that steam pretreatments in general and SC210 in particular are required for efficient bioconversion of WCLB. Yet, biotransformation through biochemical processes (e.g., anaerobic digestion) must be performed to assess the efficiency of these pretreatments.

Influence of Homogenization Treatment on Physicochemical Properties and Enzymatic Hydrolysis Rate of Pure Cellulose Fibers

The aim of this study is to compare the effect of different homogenization treatments on the physicochemical properties and the hydrolysis rate of a pure bleached cellulose. Results obtained show that homogenization treatments improve the enzymatic hydrolysis rate of the cellulose fibers by 25 to 100xa0%, depending of the homogenization treatment applied. Characterization of the samples showed also that homogenization had an impact on some physicochemical properties of the cellulose. For moderate treatment intensities (pressure below 500xa0b and degree of homogenization below 25), an increase of water retention values (WRV) that correlated to the increase of the hydrolysis rate was highlighted. Result also showed that the overall crystallinity of the cellulose properties appeared not to be impacted by the homogenization treatment. For higher treatment intensities, homogenized cellulose samples developed a stable tridimentional network that contributes to decrease cellulase mobility and slowdown the hydrolysis process.

Can Lignin Wastes Originating From Cellulosic Ethanol Biorefineries Act as Radical Scavenging Agents

Lignin is a co-product from the biorefinery and paper industries. Its non-energetic valorisation remains a field of extensive research and development. In this perspective, this study was undertaken to evaluate the radical scavenging ability of selected herbaceous lignins. These lignins, extracted from either Miscanthus (Miscanthusu2009×u2009giganteus) or switchgrass (Panicum virgatum L.), were selected as benchmarks for this study based on their chemical structure and average molecular weight. These technical lignins, which are side-products in the bioethanol production process, displayed a moderate antioxidant activity as evaluated by the 1,1-diphenyl-2-picrylhydrazil free radical scavenging test system. A correlation between the radical scavenging properties and the molecular features is proposed and discussed. Infrared spectroscopy was employed as a straightforward qualitative prediction tool for assessing the radical scavenging capacity.