Chaisri Suksaroj

Alternative technologies for the reduction of greenhouse gas emissions from palm oil mills in Thailand.

Alternative methodologies for the reduction of greenhouse gas (GHG) emissions from crude palm oil (CPO) production by a wet extraction mill in Thailand were developed. The production of 1 t of CPO from mills with biogas capture (four mills) and without biogas capture (two mills) in 2010 produced GHG emissions of 935 kg carbon dioxide equivalent (CO2eq), on average. Wastewater treatment plants with and without biogas capture produced GHG emissions of 64 and 47% of total GHG emission, respectively. The rest of the emissions mostly originated from the acquisition of fresh fruit bunches. The establishment of a biogas recovery system must be the first step in the reduction of GHG emissions. It could reduce GHG emissions by 373 kgCO2eq/t of CPO. The main source of GHG emission of 163 kgCO2eq/t of CPO from the mills with biogas capture was the open pond used for cooling of wastewater before it enters the biogas recovery system. The reduction of GHG emissions could be accomplished by (i) using a wastewater-dispersed unit for cooling, (ii) using a covered pond, (iii) enhancing the performance of the biogas recovery system, and (iv) changing the stabilization pond to an aerated lagoon. By using options i-iv, reductions of GHG emissions of 216, 208, 92.2, and 87.6 kgCO2eq/t of CPO, respectively, can be achieved.

Water footprints of products of oil palm plantations and palm oil mills in Thailand.

The water footprint (WF) of fresh fruit bunches (FFBs) from oil palm plantations and crude palm oil (CPO) from palm oil mills in southern and eastern Thailand were determined over 25 years. Climatic conditions, soil characteristics, and the characteristics of oil palm growth were considered. The WF of FFBs was 1063 m(3)/ton (t) on average. Green, blue, and grey waters comprised of 68, 18, and 14% of total WF, respectively. The oil palm plantations in Thailand required smaller amounts of indirect blue water. The average WF for producing a ton of CPO of seven mills was 5083 m(3). Most of the waters used in the mills originated from indirect green, blue and grey waters from the plantations. The direct blue water used in the mills had less impact on the total WF, lower than 1% of the total WF. Average percentages of green, blue, and grey waters of 69, 16, and 15% of total WF were determined for the mills, respectively. The water deprivation of the FFBs and CPO ranged from 0.73-12.9 and 3.44-58.3 m(3)H2Oeq/t, respectively. In 2013, the CPO production in Thailand including green, blue, and grey waters from plantation and blue water from mills required 11,343 million m(3) water. If the oil palm variety Suratthani 7 is used in the plantation, it would increase the yield from 15.2 to 22.8 t FFBs/ha-year and decrease the WF to 888 m(3)/t FFBs. The average value of the oil extraction rate (OER) of mills was 18.1%. With an increase in the OER of 1%, a reduction of the WF of 250 m(3)/t CPO or 5.1% of total WF could be obtained.

Removal of organic impurities in waste glycerol from biodiesel production process through the acidification and coagulation processes.

Treatment of waste glycerol, a by-product of the biodiesel production process, can reduce water pollution and bring significant economic benefits for biodiesel facilities. In the present study, hydrochloric acid (HCl) was used as acidification to convert soaps into salts and free fatty acids which were recovered after treatment. The pH value, dosages of polyaluminum chloride (PACl) and dosage of polyacrylamide (PAM) were considered to be the factors that can influence coagulation efficiency. The pH value of waste glycerol was adjusted to a pH range of 3-9. The PACl and PAM added were in the range of 1-6 g/L and 0.005-0.07 g/L. The results showed best coagulation efficiency occurs at pH 4 when dosage of PACl and PAM were 2 and 0.01 g/L. The removal of chemical oxygen demand (COD), biochemical oxygen demand (BOD(5)), total suspended solids (TSS) and soaps were 80, 68, 97 and 100%, respectively. The compositions of organic matters in the treated waste glycerol were glycerol (288 g/L), methanol (3.8 g/L), and other impurities (0.3 g/L).

Formation of trihalomethanes of dissolved organic matter fractions in reservoir and canal waters

ABSTRACT The formation of trihalomethanes (THMs) of hydrophobic organic fraction (HPO), transphilic organic fraction (TPI), and hydrophilic organic fraction (HPI) of reservoir and canal waters from the U-Tapao River Basin, Songkhla, Thailand was investigated. Water samples were collected three times from two reservoirs, upstream, midstream, and downstream of the U-Tapao canal. The HPO was the major dissolved organic matter (DOM) fraction in reservoir and canal waters. On average, the HPO accounted for 53 and 45% of the DOM in reservoir and canal waters, respectively. The TPI of 19 and 23% in reservoir and canal waters were determined, respectively. The HPI of 29% of the reservoir water and HPI of 32% of the canal water were detected. For the reservoir water, the highest trihalomethane formation potential (THMFP)/dissolved organic carbon (DOC) was determined for the HPI, followed by the TPI and HPO, respectively. The average values of the THMFP/DOC of the HPI, TPI, and HPO of the reservoir water were 78, 52, and 49 µg THMs/mg C, respectively. The highest THMFP/DOC of the canal water was detected for the HPI, followed by HPO and TPI, respectively. Average values of the THMFP/DOC of HPI of water at upstream and midstream locations of 58 µg THMs/mg C and downstream location of 113 µg THMs/mg C were determined. Average values of THMFP/DOC of HPO of water at upstream and midstream and downstream locations were 48 and 93 µg THMs/mg C, respectively. For the lowest THMFP/DOC fraction, the average values of THMFP/DOC of TPI of water at upstream and midstream and downstream locations were 35 and 73 µg THMs/mg C, respectively.

Treatment of oily wastewater from waste glycerol by acidification and the coalescer process

AbstractIn this study, treatment of grease and oil (G&O) and other impurities in waste glycerol from biodiesel production was performed by a two-step process, by acidification and the coaleser process. 1 M hydrochloric acid (HCl) was used to acidify waste glycerol to destabilize the emulsion and remove the suspended solids (SS), soap and methyl ester. For acidification, a pH of 6 was selected, before testing with coalescer. The study was investigated with a wide range of factors and parameters including two media materials (polypropylene (PP) and polyethyleneterephthalate (PET)), two configure shapes (granular and fiber), pH (3–6), bed height (50–150 mm), and flow rate (5–18 dm3/h). The results of the study in the same experiment conditions showed, PP media material gave better results than PET media materials where the fiber sharp material performed better than the granular sharp material. G&O concentration of treated waste glycerol reduced to 0.081 g/L under operating conditions with 120 mm bed height, ...

Reduction by enhanced coagulation of dissolved organic nitrogen as a precursor of N-nitrosodimethylamine

ABSTRACT Raw water from the Banglen (BL) water treatment plant (WTP) and Bangkhen (BK) WTP in central Thailand and Hatyai (HY) WTP in southern Thailand was investigated for dissolved organic nitrogen (DON) reduction. The DON(mg N/L) and the dissolved organic carbon (DOC)/DON ratio were 0.34 and 21, 0.24 and 18, and 1.12 and 3 for the raw waters from BL, BK, and HY WTPs, respectively. Polyaluminum chloride (PACl) dosages of 150, 80, and 40 mg/L at pH 7 were the optimal coagulation conditions for the raw waters from BL, BK, and HY WTPs, respectively, and could reduce DON by 50%, 42%, and 42%, respectively. PACl and powder activated carbon (PAC, both in mg/L) at 150 and 20, 80 and 20, and 40 and 60 could reduce DON in the raw waters from BL, BK, and HY WTPs by 71%, 67%, and 29%, respectively. DOC/DON values of water treated with PACl were similar to those of raw water. DOC/DON values of water treated with PACl and PAC were lower than those of raw water. N-nitrosodimethylamine (NDMA) formation potentials of raw water, water treated with PACl, or both PACl and PAC, and organic fractions of BL, BK, and HY WTPs were below the detection limits of 542 and 237 ng/L, respectively. Reductions in fluorescence intensities of tryptophan-like substances at peaks 240/350 and 280/350 (nmEx/nmEm) were moderately (correlation coefficient, R = 0.85 and 0.86) and fairly (R = 0.59, 0.67, and 0.75) correlated with DON reduction.

Economic Benefit of Management Options for a Suburban Forest (Kho Hong Hill) in South Thailand

Kho Hong Hill (KHH) is located close to Hat Yai City in Songkhla Province, South Thailand. Almost half of its forested area has been deforested as a consequence of population increase, urbanization and the ongoing conversion of forest areas into rubber plantations. This study assesses the net economic benefits of three forest resource management strategies based on information derived from interviews and discussions with relevant KHH stakeholders. The three strategies are represented as three scenarios: Scenario I is the base case or the business-as-usual (BAU) scenario; Scenario II involves the establishment of protected areas to preserve the remaining forest areas in KHH; and Scenario III assumes the implementation of forest restoration and rehabilitation initiatives designed to increase the forest areas on KHH. Six ecosystem services are selected as the environmental variables for the study: (a) the provision of timber, (b) carbon dioxide sequestration, (c) oxygen generation, (d) water supply, (e) flood control and (f) biodiversity. Market valuation is used to estimate the values of provision of timber, CO2 sequestration, O2 generation, water supply and flood control, while the value transfer approach is used to value of the service derived from KHH biodiversity. The results show that under Scenario I, the annual benefits from the ecosystem services from KHH would become negative after 15 years, whereas positive net present values would be yielded under Scenarios II and III. The study recommends that rubber farmers should be encouraged to convert their rubber plantations back to forest areas. Introducing a payment for ecosystem services (PES), mechanism is also recommended to induce rubber farmers to reforest. Further studies would be needed, however, to establish an effective PES system.