Eva Tornberg

Effects of heat on meat proteins – Implications on structure and quality of meat products

Globular and fibrous proteins are compared with regard to structural behaviour on heating, where the former expands and the latter contracts. The meat protein composition and structure is briefly described. The behaviour of the different meat proteins on heating is discussed. Most of the sarcoplasmic proteins aggregate between 40 and 60 °C, but for some of them the coagulation can extend up to 90°C. For myofibrillar proteins in solution unfolding starts at 30-32°C, followed by protein-protein association at 36-40°C and subsequent gelation at 45-50°C (conc.>0.5% by weight). At temperatures between 53 and 63°C the collagen denaturation occurs, followed by collagen fibre shrinkage. If the collagen fibres are not stabilised by heat-resistant intermolecular bonds, it dissolves and forms gelatine on further heating. The structural changes on cooking in whole meat and comminuted meat products, and the alterations in water-holding and texture of the meat product that it leads to, are then discussed.

Biophysical aspects of meat tenderness

Biophysical aspects of meat tenderness is reviewed, where the meat structural origin of variation in meat tenderness is tried to be elucidated. Processes, such as rigor development and ageing, known to influence the properties of the structural components, is covered, and variables that influence those processes, such as chilling, electrical stimulation and stress ante-mortem, are discussed. Meat tenderness can be evaluated both by sensory and instrumental methods. The relationships between mechanical and sensory assessments tend to be non-linear, which can be due to non-linearity in the sensory evaluation and that muscle fibre orientation is easier to control in instrumental than in sensory evaluation. Structural changes of the meat occuring during rigor development are both longitudinal and lateral contraction of the myofibrillar mass. Other structural events, based on the proteolytic action, are the loosing up of the myofibrils held together laterally, weakening of the myofibrillar length and myofibril fragmentation. Using instrumental recordings of meat toughness (Warner-Bratzler (W-B) peak force), it decreases significantly with degree of contraction, when raw, but the reverse is found, when meat is cooked above 60 °C. A structural explanation to this behaviour is suggested to be the following. When meat is raw the lateral contraction of the meat fiber increases with shorter sarcomeres, giving rise to a larger viscous component and hence a lower W-B peak force. On heating, however, with a larger extracellular space, when shortened, there is more room for the connective tissue to contract without being restricted by the myofibrillar mass. This in turn gives a higher number of fibers per unit cross-sectional area, hence a larger elastic modulus and a higher W-B peak force, when cooked. When chilling of muscle during rigor both warm- and cold-shortening occur. Minimal shortening region is for beef M. longissimus dorsi (LD) 10-15 °C and for M. semimembranosus (SM) 7-13 °C. For the SM muscle there is a high correlation between percentage shortening and ultimate tenderness both in the warm- and cold-shortening region. But for the LD muscle this is only the case in the cold-shortening region. This observation suggests that the LD muscle is a more enzymatically active muscle than SM. The influence of low-voltage electrical stimulation (ES) was followed in the cold-shortening region for muscles LD and SM. A significant effect on tenderness 15 days post-mortem was only observed for LD at 1 °C and 4 °C, but not for SM. It was suggested that enhanced proteolysis could be the reason for the improved tenderness on ES of LD, as colds-hortening was not prevented by ES. Long-term and short-term stress ante-mortem can give rise to DFD (dark, firm and dry)-and PSE (pale, soft and exudative)-meat, respectively. DFD-meat (pH(u) > 6.0 in LD) has relatively short sarcomere lengths, but still it is swollen laterally and has consequently a small extracellular space. Therefore DFD-meat usually is tender. PSE-meat has a large variation in sarcomere length. The long sarcomeres of PSE-meat is suggested to be caused by reduced shortening, due to the denaturation of the sarcoplasmic proteins during rigor. The short sarcomeres can be caused by a higher percentage of rigor development in the warm-shortening region and that the denaturation of the myosin heads cause both longitudinal and lateral contraction of the myofibrillar mass. There is also a large variation in tenderness of PSE-meat, but it has been found that this variation is positively correlated to the sarcomere length (r = 0.52**), as has been shown for the other variables that governs the rigor process.

Contribution of pigment content, myoglobin forms and internal reflectance to the colour of pork loin and ham from pure breed pigs

The colour of loin, M. longissimus dorsi (LD), and ham, M. biceps femoris (BF), from pure breed Hampshire, Swedish Landrace and Swedish Yorkshire pigs was studied. The contribution of the pigment content, the myoglobin forms deoxymyoglobin (Mb), oxymyoglobin (MbO) and metmyoglobin (MetMb) and the internal reflectance to the colour of pork of normal meat quality was evaluated using partial least squares regression (PLS). The colour of LD and BF from the Hampshire breed was more red and yellow and more saturated than the colour of the same muscles from the Swedish Landrace and the Swedish Yorkshire breeds. Furthermore, BF from Hampshire was darker than BF from the other two breeds. These differences in colour were related to the lower pH in Hampshire, resulting in more blooming and in higher internal reflectance, and to the higher pigment content. The colour of BF was darker and more red than the colour of LD within each breed. No colour difference was found between gilts and castrates within each breed. Most of the variation (86-90%) in lightness (L* value), redness (a* value) and yellowness (b* value), chroma (saturation) and hue angle of pork of normal meat quality was explained by the pigment content, myoglobin forms and internal reflectance. The L* value, a* value, chroma and hue angle were influenced by both the pigment content and by the myoglobin forms to almost the same extent, while the internal reflectance was of no significance to these colour parameters. The b* value was influenced most by the myoglobin forms, less by the internal reflectance and almost not at all by the pigment content.

Prediction of water-holding capacity and composition of porcine meat by comparative spectroscopy

Four spectroscopic instruments, a fibre optical probe (FOP), a visual (VIS) and near infrared (NIR) reflectance spectrophotometer, a reflectance spectrofluorometer and a low-field (1)H nuclear magnetic resonance (LF-NMR) instrument were used to perform measurements on two muscles (longissimus dorsi and semitendinosous) from 39 pigs, 18 of which were carriers of the Halothane gene. Water-holding capacity (drip loss and filter paper wetness) and chemical composition (intramuscular fat and water) of the muscle samples were determined for spectroscopic calibration. Prediction models were established by partial least squares regression to evaluate the potential of using the spectroscopic techniques in an on-line slaughterhouse system. VIS data gave good prediction models, indicating that current industrial colour systems can be advanced into more specific meat evaluation systems by including the entire visible spectral range. The FOP and fluorescence measurements were less successful, and suffered from sampling problems since they measure only a small area. The best regression models were obtained from LF-NMR data for all reference quality measures and yielded a correlation coefficient of 0.75 with drip loss. LF-NMR proved able to distinguish between the two muscles and the results for their longitudinal relaxation times, T(21), were proportional to their average myofibrillar cross-sectional areas reported in the literature.

The application of the drop volume technique to measurements of the adsorption of proteins at interfaces

A new procedure for the application of the drop volume technique to measurements of the rate of adsorption of proteins at interfaces has been developed. The mode of adsorption of the proteins lysozyme, β-lactoglobulin and bovine serum albumin (BSA) at the air-water interface has been measured with the drop volume method and has been compared to measurements with the Wilhelmy plate technique. Due to surface enlargement of the drop throughout the process of the surface tension decay, slower kinetics of the adsorption process is obtained by the drop volume method compared to the Wilhelmy plate technique, and the proteins investigated were differently sensitive to this surface expansion. The adsorption process of the proteins has been evaluated in terms of different rate-determining processes. Different intermediate states between the native and the denatured forms have been observed.

Effect of rigor temperature on muscle shortening and tenderisation of restrained and unrestrained beef m. longissimus thoracicus et lumborum

Pairs of muscularis longissimus thoracicus et lumborum (LTL) from young bulls were removed within 1h of slaughter. Small portions of the muscles were placed in a rigormeter to continously follow the isometric tension and isotonic shortening developed, at constant temperatures of 15, 20, 25, 30 and 35°C, as the muscle went into rigor. The bulk LTL was placed in water baths at the same temperature. One of the bulk pairs was tightly restrained by wrapping, to reduce muscle shortening, the other was unrestrained free to shorten. For the bulk samples, shear values were measured using a Warner-Bratzler instrument (1, 7 and 14 days post mortem), and sensory attributes were measured using a sensory panel (7 and 14 days post mortem). Minimum tension and shortening occurred at 15°C. The activation energy for the muscle shortening process was larger than for the isometric tension process. This indicates that the isometric tension data, collected during rigor, does not solely reflect muscle shortening. Thus, a counteracting process that decreases the tension response, most likely ageing is simultaneously detected. Meat that went into rigor at 15°C had least shortening and was always more tender than meat going into rigor at higher temperatures. For meat entering rigor at temperatures higher than 15°C, restraining of the muscle by wrapping, significantly (p<0.05) decreased the amount of muscle shortening and resulted in an improved meat tenderness (p<0.001). It was also observed that at rigor temperatures higher than 15°C the meat tenderness is affected negatively by a reduced ageing capacity. It therefore appears that muscle shortening and enzyme activity both affect tenderness and that both are highly affected by rigor temperature and have the greatest beneficial effect at a rigor temperature of 15°C.

A surface tension apparatus according to the drop volume principle

A new construction of a drop volume apparatus has proved to be successful in determining the interfacial tension for a variety of pure liquids as well as for solutions having surface tensions, which come to equilibrium quickly. Temperature dependence of the surface tension can easily be recorded even at elevated temperatures, which has been shown for water.

An international study on the importance of androstenone and skatole for boar taint: IV. Simulation studies on consumer dissatisfaction with entire male pork and the effect of sorting carcasses on the slaughter line, main conclusions and recommendations.

An international study has been conducted in order to determine the respective contributions of androstenone and skatole to boar taint and their possible variations according to production systems and consumer populations. The presentation of the study and the main results concerning skatole and androstenone levels and data from sensory evaluation or consumer surveys are reported in companion papers. The present paper summarises the main conclusions of the study and gives tentative recommendations. A simulation study was conducted, based on the skatole and androstenone levels currently observed in European populations of entire male pigs and on the results of the consumer surveys. The first part of the simulation study demonstrated that, overall, 6.5% (odour) and 3.0% (flavour) more consumers were dissatisfied with entire male than with gilt pork. The differences were, however, very variable according to countries. Consumer dissatisfaction for the odour of entire male pork was mostly associated with high skatole levels, while androstenone had little influence on it. On the other hand, androstenone and skatole had similar contributions to the level of dissatisfaction for flavour. From the present study it is not possible to determine clear cut-off levels for androstenone/skatole. The regression equations presented in [Matthews, K. R., Homer, D. B., Punter, P., Béague, M. P., Gispert, M., Siret, F., Leask, H., Fonti i Furnols, M., & Bonneau, M. (2000). An international study on the importance of androstenone, skatole for boar taint: III. Consumer survey in seven European countries. Meat Science, 54, 271-283] provide a basis for decision making. However, due to methodological limitations, the results may underestimate consumer reaction to entire male pork. The second part of the simulation study demonstrated that sorting carcasses on the basis of androstenone/skatole would reduce, but not eliminate, differences in consumer dissatisfaction between entire male and gilt pork. For odour, taking androstenone into account did not improve the efficiency obtained from sorting using skatole only. For flavour, sorting using both compounds was more efficient than sorting using skatole only. Sorting out 15% of the entire males, on the basis of skatole only, would result in a difference in the proportion of dissatisfied consumers of 4.2% (odour) or 2.0% (flavour) between entire male and gilt pork. The results of the last part of the simulation study demonstrated that decreasing skatole in entire male pig populations, to levels as low as 0.10 ppm, would still result in a difference in the proportion of dissatisfied consumers of 3.2% (odour) or 1.6% (flavour). To reduce this difference further, the levels of both compounds would have to be reduced still further. The lowest difference that can be achieved is 2.3% (odour) or 0.4% (flavour). The conclusions of the present study may differ according to whether immediate commercial applications or long-term goals are considered. On the basis of the skatole and androstenone levels currently observed in entire male pig populations, sorting out procedures based on skatole is the easiest way to rapidly achieve a significant decrease in consumer dissatisfaction with entire male pork. In most countries, however, this will not be sufficient to obtain the same level of acceptability as with gilts. In the long term, a sharp reduction in both skatole and androstenone would have to be achieved in entire male pig populations to obtain low differences in acceptability between entire male and gilt pork.

Sensory and technological meat quality in carriers and non-carriers of the RN(-) allele in Hampshire crosses and in purebred Yorkshire pigs.

The effect of the dominant RN(-) allele on technological and sensory meat quality of loin and ham from pigs, crossbred from Landrace × Yorkshire sows and one Hampshire sire heterozygous for the RN(-) allele was studied. The non-carriers of the RN(-) allele and the purebred Yorkshire pigs were similar regarding most of the technological traits. In comparison with the RN(-) carriers, they had higher values for pH(u), Napole yield, dry matter and protein content, but lower values for drip loss, filter paper wetness, cooking loss, internal reflectance, residual glycogen and glycolytic potential. The three groups did not differ concerning lactate content, intramuscular fat or ash content. Shear-force values did not differ between the two RN genotypes, but both genotypes had lower shear-force values than the purebred Yorkshire pigs. Non-carriers had higher processing yield for cured cooked ham than RN(-) carriers. The RN(-) allele had little effect on the sensory attributes, as assessed by a trained panel using a descriptive test, but there was a tendency to lower chewing time for meat from the crossbreds compared to the purebred Swedish Yorkshire. RN(-) carriers produced more acidic fresh loin than non-carriers and purebred Yorkshire pigs, and juicier cured cooked ham than non-carriers.

The effect of high post-mortem temperature on the development of pale, soft and exudative pork: Interaction with ultimate pH

The effects of post-mortem temperature and ultimate pH (pH(u), 24 h post mortem) on the development of the pale, soft and exudative (PSE) characteristics in pig longissimus dorsi muscle were studied. Ten out of the 13 pigs used received pre-slaughter injections of adrenaline in order to deplete muscle glycogen stores. The two muscles from each pig were held at 12 or 35°C during rigor mortis development. Results from covariance analysis, using pH(u) as covariate, showed that a high temperature (35°C) resulted in a dramatic increase in internal light scattering (FOP) 24 h post mortem and a significant decrease in water- and salt-soluble proteins. Cooking loss, sarcomere length and drip loss did not vary significantly with rigor temperature. Interaction between temperature and pH(u) was estimated by assessing the relationship between pH(u) and the difference between the two rigor temperatures for selected traits. The best predictive model was a segmented quadratic model with a plateau which gave significant results for FOP, drip loss, water- and salt-soluble proteins. The effect of temperature decreased curvilinearly when pH increased until a constant value above which no noticeable difference was recorded (drip loss, water- and salt-soluble proteins) or a constant difference was reached (FOP). The pH values corresponding to the convergence points differed from one trait to another. They ranged from 5·72 to 6·22. These results illustrate the importance of muscle glycogen content at slaughter and subsequent pH(u) with regard to the development of temperature-induced PSE meat.