G. C. Mead

Effect of changes in processing to improve hygiene control on contamination of poultry carcasses with campylobacter.

Examination of neck skin and caecal samples taken at a commercial processing plant from 15 randomly chosen poultry flocks showed that all flocks were contaminated initially with thermophilic Campylobacter spp., even in the apparent absence of caecal carriage. During processing, numbers of campylobacter on skin samples were reduced by between 10 and 1000-fold. To improve hygiene control generally, chlorinated-water sprays were used to limit microbial contamination on equipment and working surfaces. In addition, chlorine concentrations in process water were increased and any unnecessary carcass contact surfaces in the processing plant were removed. When comparing flocks before and after the changes, it was found that numbers of campylobacter on packaged carcasses were significantly lower after the changes had been made (P 0.001). In practice, however, the reduction would be likely to have little impact on consumer exposure to campylobacter infection.

Use of a marker organism in poultry processing to identify sites of cross‐contamination and evaluate possible control measures

1. Nine different sites at a poultry processing plant were selected in the course of a hazard analysis to investigate the degree of microbial cross-contamination that could occur during processing and the effectiveness of possible control measures. 2. At each site, carcases, equipment or working surfaces were inoculated with a non-pathogenic strain of nalidixic acid-resistant Escherichia coli K12; transmission of the organism among carcases being processed was followed qualitatively and, where appropriate, quantitatively. 3. The degree of cross-contamination and the extent to which it could be controlled by the proposed measures varied from one site to another.

Recommended Assay for Treatment of Chicks to Prevent Salmonella Colonization by ‘Competitive Exclusion’

An assay is described for evaluating live-culture treatment material that may be given orally to chicks to prevent intestinal colonization by non-host-specific salmonellae. Both pre-treated and control chicks are challenged with ca 104 salmonellae/chick, using a strain bearing an antibiotic resistance marker. Chicks are examined 5 d after challenge to determine both the proportion of positive birds in treated and control groups and the levels of Salmonella in the caeca of infected individuals. The efficacy of the treatment is determined by calculation of values for Infection Factor and Protection Factor.

Microbiological survey of five poultry processing plants in the UK

1. Neck skin samples were taken from chickens and turkeys at all the main stages of processing to monitor changes in total viable count (TVC) and counts of coliforms and pseudomonads. 2. Processing reduced TVC by up to 100-fold. Geometric mean counts after packaging were log10 4.4 to 5.3 CFU/g whilst corresponding counts of coliforms were 2.7 to 3.8 CFU/g. 3. Increases in mean TVC or coliforms as a result of either defeathering or evisceration did not exceed 0.6 log. 4. Pseudomonads represented only a minor fraction of the initial microflora of the bird and were often reduced by scalding to a figure which could not be detected by direct plating of samples; however, subsequent contamination resulted in means between log10 2.9 and 4.0 CFU/g for packaged carcases. 5. Although Staphylococcus aureus was readily isolated from defeathering equipment, mean counts from defeathered carcases were always below log10 3.0 CFU/g.

Phage typing of Salmonella enteritidis from different sources in Brazil.

The occurrence of Salmonella Enteritidis (SE) phage types (PTs) in samples collected from healthy and diseased chickens, in outbreaks of human gastroenteritis related to the consumption of egg products, in samples of poultry meat, in pipped embryos of broiler chickens, in meat meal, in poultry-rearing environments, and in many foods (cheese, mayonnaise, cake, and bacon) is described for strains isolated from 1995 to 1997 in Brazil. SE strains were isolated, and the most common PT was found to be PT 4, followed by PTs 7, 21, 35, 6, 4a, 8, 30, 6a, 5a, 1, and 1b. Fourteen strains were classified as react-but-do-not-conform strains, and one strain was not typeable. The results of this study demonstrate that PT 4 has a wider distribution among the sources studied than do any other SE phage types and is the most important phage type in human salmonellosis.

Relevance of abattoir hygiene assessment to microbial contamination of British beef carcases

Eleven beef abattoirs were visited, each on five separate occasions. On each occasion, an audit was carried out according to the official Hygiene Assessment System (HAS) and 10 carcases were sampled at four different sites to assess total viable counts and counts of presumptive coliform bacteria. The HAS scores ranged from 11 to 84 (maximum 100), and the logarithmic mean total viable counts for all sampling sites on each batch of carcases varied between 1.98 and 4.14 colony forming units/cm2. The mean prevalence of coliform contamination ranged from 0 to 85 per cent. There was a significant negative correlation (P<0.001) between the mean HAS scores and the mean total viable count for each abattoir, but not between the HAS scores and the numbers of coliforms. Within the HAS, the mean scores for all five categories, before weighting, showed a significant correlation with the mean total viable count (P<0.001); however, the categories concerned with slaughter and dressing, and personnel and practices were of most value in determining trends in carcase contamination. A new advisory classification is proposed for levels of microbial contamination on beef carcases.

Assessing abattoir hygiene with a marker organism

A study was made to evaluate the use of a marker organism for assessing whether hygienic slaughter practices were being followed at red meat abattoirs. The organism, a nonpathogenic strain of Escherichia coli K12 that was resistant to nalidixic acid, was detected and counted on a highly specific isolation medium. With beef carcases, the practice of bagging the excised anus reduced, but did not prevent the spread of the organism from an inoculum applied in the anal region before the hide was removed. The carcases of sheep that were processed at a low-throughput abattoir, were contaminated with the marker after the fleece had been inoculated at a single site. The contamination was significantly reduced (P<0.001) when the operative responsible for flaying had cleaned his hands, arms and apron before and during the handling of each carcase, and used a knife which was freshly pasteurised on several occasions. However, the subsequent washing of carcases had little or no effect on the levels of the marker organism. It was concluded that the marker may be of value in assessing hygiene control, improving present practices, and training abattoir staff.

Investigation of hygiene aspects during air chilling of poultry carcases using a model rig

1. An experimental rig, designed and built to simulate conditions found in commercial poultry chilling systems, was used to investigate the effects of varying air temperature and chilling duration, and the effect of chlorinated water sprays, on the microbial load present on the skin and in the body cavity of freshly eviscerated poultry carcases; deep muscle and skin temperatures were monitored during chilling at three different temperatures. 2. During dry chilling for 2 h, total viable microbe counts (TVC) and counts of coliforms and pseudomonads from the body cavity fell by between half and one log unit; smaller reductions were observed in samples from the breast skin. 3. The situation changed when chlorinated water sprays (50, 100 or 250 ppm available chlorine) were applied for the first hour of chilling; spraying carcases enhanced the reduction in numbers on the skin; the effect was most pronounced with 250 ppm chlorine; conversely, in the body cavity, the general effects of sprays was to increase contamination by up to one log unit. 4. There was no evidence that sprays increased the rate of chilling. 5. When carcases were held overnight in the rig at 11°C after chilling, microbe counts on dry-chilled carcases remained stable, but increased on carcases that had been sprayed with chlorinated water.

Determination of farm-level risk factors for abnormalities observed during post-mortem meat inspection of lambs: a feasibility study

To investigate the feasibility of using information about the health and management of lambs on farms to predict the risk of gross abnormalities at post-mortem meat inspection, 6732 lambs from 30 different farms in Great Britain were followed through to slaughter in 1995/6. The farm-level data were collected during farm visits at the beginning of the study. Routine meat inspection findings for the lambs were obtained from the 10 participating abattoirs. The most common abnormalities found during post-mortem inspection were pneumonia/pleurisy (53% of cohorts), lungworm (40%), abscesses (30%), liver fluke (27%) and nephritis/nephrosis (27%). The farm-level risk factors associated with abnormalities at slaughter varied with the type of lesion. The most significant risk factor was the age of the lambs at slaughter. Lambs slaughtered at an older age were more likely to have an abnormality, especially pneumonia, abscesses and liver fluke. After age, environmental factors appeared to be better predictors of those cohorts that would have lesions at slaughter than health and disease control variables. However, a much larger study would be required to identify a set of farm-level factors that adequately discriminated between lambs with high and low risks of lesion at slaughter. At the end of the study, the farmers were informed of the meat inspection findings for their lambs and a third indicated that they would improve their animal husbandry as a result of the information.

The bacteriological quality of British beef 1: Carcasses sampled prior to chilling

During a survey of 11 beef abattoirs in England 2200 swab samples were taken from carcasses just before chilling. Geometric mean aerobic plate counts at 30°C on each of four carcass sites ranged from log(10) 2·45 to 4·29cfu cm(2) with the brisket and flank samples tending to be more highly contaminated than those from the fore-rib and groin. Presumptive coliforms were isolated from 24% of the samples and the proportion of positive samples among the abattoirs varied between 1·5% and 43%. Analysis of variance confirmed that the bacteriological status of beef carcasses may be influenced by a number of interacting factors, including abattoir, visit, and sampling site. However, the results showed that working methods alone were not critical factors in the production of beef of superior bacteriological quality.