Gaihe Yang

Optimizing feeding composition and carbon–nitrogen ratios for improved methane yield during anaerobic co-digestion of dairy, chicken manure and wheat straw

This study investigated the possibilities of improving methane yield from anaerobic digestion of multi-component substrates, using a mixture of dairy manure (DM), chicken manure (CM) and wheat straw (WS), based on optimized feeding composition and the C/N ratio. Co-digestion of DM, CM and WS performed better in methane potential than individual digestion. A larger synergetic effect in co-digestion of DM, CM and WS was found than in mixtures of single manures with WS. As the C/N ratio increased, methane potential initially increased and then declined. C/N ratios of 25:1 and 30:1 had better digestion performance with stable pH and low concentrations of total ammonium nitrogen and free NH(3). Maximum methane potential was achieved with DM/CM of 40.3:59.7 and a C/N ratio of 27.2:1 after optimization using response surface methodology. The results suggested that better performance of anaerobic co-digestion can be fulfilled by optimizing feeding composition and the C/N ratio.

Biogas Production by Co-Digestion of Goat Manure with Three Crop Residues

Goat manure (GM) is an excellent raw material for anaerobic digestion because of its high total nitrogen content and fermentation stability. Several comparative assays were conducted on the anaerobic co-digestion of GM with three crop residues (CRs), namely, wheat straw (WS), corn stalks (CS) and rice straw (RS), under different mixing ratios. All digesters were implemented simultaneously under mesophilic temperature at 35±1 °C with a total solid concentration of 8%. Result showed that the combination of GM with CS or RS significantly improved biogas production at all carbon-to-nitrogen (C/N) ratios. GM/CS (30:70), GM/CS (70:30), GM/RS (30:70) and GM/RS (50:50) produced the highest biogas yields from different co-substrates (14840, 16023, 15608 and 15698 mL, respectively) after 55 d of fermentation. Biogas yields of GM/WS 30:70 (C/N 35.61), GM/CS 70:30 (C/N 21.19) and GM/RS 50:50 (C/N 26.23) were 1.62, 2.11 and 1.83 times higher than that of CRs, respectively. These values were determined to be the optimal C/N ratios for co-digestion. However, compared with treatments of GM/CS and GM/RS treatments, biogas generated from GM/WS was only slightly higher than the single digestion of GM or WS. This result was caused by the high total carbon content (35.83%) and lignin content (24.34%) in WS, which inhibited biodegradation.

Effect of initial pH on anaerobic co-digestion of kitchen waste and cow manure

This study investigated the effects of different initial pH (6.0, 6.5, 7.0, 7.5 and 8.0) and uncontrolled initial pH (CK) on the lab-scale anaerobic co-digestion of kitchen waste (KW) with cow manure (CM). The variations of pH, alkalinity, volatile fatty acids (VFAs) and total ammonia nitrogen (NH4(+)-N) were analyzed. The modified Gompertz equation was used for selecting the optimal initial pH through comprehensive evaluation of methane production potential, degradation of volatile solids (VS), and lag-phase time. The results showed that CK and the fermentation with initial pH of 6.0 failed. The pH values of the rest treatments reached 7.7-7.9 with significantly increased methane production. The predicted lag-phase times of treatments with initial pH of 6.5 and 7.5 were 21 and 22 days, which were 10 days shorter than the treatments with initial pH of 7.0 and 8.0, respectively. The maximum methane production potential (8579 mL) and VS degradation rate (179.8 mL/g VS) were obtained when the initial pH was 7.5, which is recommended for co-digestion of KW and CM.

Evaluation of two statistical methods for optimizing the feeding composition in anaerobic co-digestion: mixture design and central composite design.

To investigate the feasibility of statistical methods in optimizing the feeding composition in anaerobic co-digestion, a simplex-centroid mixture design (SCMD) and central composite design (CCD) were evaluated with methane potential as the response variable. Dairy manure, chicken manure, swine manure and rice straw (RS) were selected as raw materials and two kinds of manures and RS were mixed in each blend. Each component served as an independent variable in the SCMD and CCD and involved two factors, the manure and C/N ratios. Co-digestion of three-component substrates resulted in higher methane potentials than single and two-component substrates. In response surface plots, SCMD showed the interactions among each component in the co-substrates and CCD presented the interaction between the ratio of manures and the C/N ratio. SCMD and CCD are both suitable methods for optimizing the feeding composition during anaerobic co-digestion.

Influence of initial pH on thermophilic anaerobic co-digestion of swine manure and maize stalk.

The contradictions between the increasing energy demand and decreasing fossil fuels are making the use of renewable energy the key to the sustainable development of energy in the future. Biogas, a renewable clean energy, can be obtained by the anaerobic fermentation of manure waste and agricultural straw. This study examined the initial pH value had obvious effect on methane production and the process in the thermophilic anaerobic co-digestion. Five different initial pH levels with three different manure ratios were tested. All digesters in different initial pH showed a diverse methane production after 35 days. The VFA/alkalinity ratio of the optimum reaction condition for methanogens activity was in the range of 0.1-0.3 and the optimal condition that at the 70% dung ratio and initial pH 6.81, was expected to achieve maximum total biogas production (146.32 mL/g VS).

Effects of temperature and carbon-nitrogen (C/N) ratio on the performance of anaerobic co-digestion of dairy manure, chicken manure and rice straw: focusing on ammonia inhibition.

Anaerobic digestion is a promising alternative to disposal organic waste and co-digestion of mixed organic wastes has recently attracted more interest. This study investigated the effects of temperature and carbon-nitrogen (C/N) ratio on the performance of anaerobic co-digestion of dairy manure (DM), chicken manure (CM) and rice straw (RS). We found that increased temperature improved the methane potential, but the rate was reduced from mesophilic (30∼40°C) to thermophilic conditions (50∼60°C), due to the accumulation of ammonium nitrogen and free ammonia and the occurrence of ammonia inhibition. Significant ammonia inhibition was observed with a C/N ratio of 15 at 35°C and at a C/N ratio of 20 at 55°C. The increase of C/N ratios reduced the negative effects of ammonia and maximum methane potentials were achieved with C/N ratios of 25 and 30 at 35°C and 55°C, respectively. When temperature increased, an increase was required in the feed C/N ratio, in order to reduce the risk of ammonia inhibition. Our results revealed an interactive effect between temperature and C/N on digestion performance.

Anaerobic digestion of pig and dairy manure under photo-dark fermentation condition

Anaerobic digestion (AD) with livestock manure is a promising way for biogas production. This work presents the influence of photo-dark fermentation on biogas production of pig manure (PM) and dairy manure (DM). All sets were conducted with temperature 35 ± 2 °C and total solid concentrations 8%: PM₁ and DM₁ in transparent reactor under sunlight for photo-dark fermentation, and PM₂ and DM₂ in non-transparent reactor for dark fermentation. DM₂ had the best cumulative biogas production (CBP) of 15,447.5 mL, followed by PM₁ (15,020 mL) with stable pH and low total ammonium nitrogen (TAN) concentration (1384.99 mg/L), and DM₁ and PM₂. The CBP of DM₂ was 5.77 times as much as PM₂. The relationship between CBP and four factors including volatile fatty acid (VFA), TAN, total alkalinity and pH was analyzed. pH gained the maximum determination coefficient with the CBP among all sets and total alkalinity showed negative correlation with CBP of PM₁ and DM₁.

Stratification of carbon fractions and carbon management index in deep soil affected by the Grain-to-Green Program in China.

Conversion of slope cropland to perennial vegetation has a significant impact on soil organic carbon (SOC) stock in A horizon. However, the impact on SOC and its fraction stratification is still poorly understood in deep soil in Loess Hilly Region (LHR) of China. Samples were collected from three typical conversion lands, Robinia psendoacacia (RP), Caragana Korshinskii Kom (CK), and abandoned land (AB), which have been converted from slope croplands (SC) for 30 years in LHR. Contents of SOC, total nitrogen (TN), particulate organic carbon (POC), and labile organic carbon (LOC), and their stratification ratios (SR) and carbon management indexes (CMI) were determined on soil profiles from 0 to 200 cm. Results showed that the SOC, TN, POC and LOC stocks of RP were significantly higher than that of SC in soil layers of 0–10, 10–40, 40–100 and 100–200 cm (P<0.05). Soil layer of 100–200 cm accounted for 27.38–36.62%, 25.10–32.91%, 21.59–31.69% and 21.08–26.83% to SOC, TN, POC and LOC stocks in lands of RP, CK and AB. SR values were >2.0 in most cases of RP, CK and AB. Moreover, CMI values of RP, CK, and AB increased by 11.61–61.53% in soil layer of 100–200 cm compared with SC. Significant positive correlations between SOC stocks and CMI or SR values of both surface soil and deep soil layers indicated that they were suitable indicators for soil quality and carbon changes evaluation. The Grain-to-Green Program (GTGP) had strong influence on improving quantity and activity of SOC pool through all soil layers of converted lands, and deep soil organic carbon should be considered in C cycle induced by GTGP. It was concluded that converting slope croplands to RP forestlands was the most efficient way for sequestering C in LHR soils.

Responsiveness of soil nitrogen fractions and bacterial communities to afforestation in the Loess Hilly Region (LHR) of China.

In the present paper, we investigated the effects of afforestation on nitrogen fractions and microbial communities. A total of 24 soil samples were collected from farmland (FL) and three afforested lands, namely Robinia pseudoacacia L (RP), Caragana korshinskii Kom (CK), and abandoned land (AL), which have been arable for the past 40 years. Quantitative PCR and Illumina sequencing of 16S rRNA genes were used to analyze soil bacterial abundance, diversity, and composition. Additionally, soil nitrogen (N) stocks and fractions were estimated. The results showed that soil N stock, N fractions, and bacterial abundance and diversity increased following afforestation. Proteobacteria, Acidobacteria, and Actinobacteria were the dominant phyla of soil bacterial compositions. Overall, soil bacterial compositions generally changed from Actinobacteria (Acidobacteria)-dominant to Proteobacteria-dominant following afforestation. Soil N fractions, especially for dissolved organic nitrogen (DON), were significantly correlated with most bacterial groups and bacterial diversity, while potential competitive interactions between Proteobacteria (order Rhizobiales) and Cyanobacteria were suggested. In contrast, nitrate nitrogen (NO3−-N) influenced soil bacterial compositions less than other N fractions. Therefore, the present study demonstrated that bacterial diversity and specific species respond to farmland-to-forest conversion and hence have the potential to affect N dynamic processes in the Loess Plateau.

Response surface optimization of methane potentials in anaerobic co-digestion of multiple substrates: dairy, chicken manure and wheat straw

Dairy manure (DM), chicken manure (CM) and wheat straw were used to investigate the possibility of optimizing the methane (CH4) potentials in anaerobic co-digestion of multiple substrates. Response surface methodology (RSM) was used to evaluate the individual and interactive effects of four variables [carbon/nitrogen (C/N) ratio, the feeding composition (DM/CM), initial substrate loading and inoculum-to-substrate ratio (ISR)] in the digestion process. All four variables had significant effects on CH4 potentials. Interactive effects of C/N and DM/CM ratios, C/N ratio and ISR, initial substrate loading and ISR were significant The optimum conditions were a C/N ratio of 26.31, a DM/CM ratio of 42.96:57.04, an initial loading of 15.90 g volatile solids (VS)/l and an ISR ratio of 2.34, with the maximum CH4 potential being 394 ml/g VS. The RSM model was appropriate for optimizing CH4 production in the process of anaerobic co-digestion of multiple substrates.