Guodong Qi

Solvent-Free Synthesis of Silicoaluminophosphate Zeolites†

Solvent-Free Synthesis of Silicoaluminophosphate Zeolites Solvents, who needs them? Silicoaluminophosphate zeolites with various frameworks have been successfully synthesized by a solvent-free route. Catalytic tests for the conversion of methanol into olefins show that thus obtained SAPO-34 (see picture) exhibited catalytic performance comparable to that of zeolites made by the conventional hydrothermal route. Angewandte Chemie

Sustainable Synthesis of Zeolites without Addition of Both Organotemplates and Solvents

The development of sustainable and environmentally friendly techniques for synthesizing zeolites has attracted much attention, as the use of organic templates and solvents in the hydrothermal synthesis of zeolites is a major obstacle for realizing green and sustainable synthesis ways. Recently, the introduction of the organotemplate-free synthesis method allowed avoiding the use of organic templates, but water as solvent was still required; solvent-free routes on the other hand beared the potential to significantly reduce the amount of polluted wastewater, but organic templates were still present. In this work, we have demonstrated a combined strategy of both organotemplate- and solvent-free conditions to synthesize aluminosilicate zeolites Beta and ZSM-5 (S-Beta and S-ZSM-5), two of the most important zeolites relevant for industry. The samples are thoroughly characterized by XRD patterns, SEM images, N2 sorption isotherms, UV-Raman spectra, and (29)Si and (27)Al MAS NMR spectra. The results demonstrate that S-Beta and S-ZSM-5 zeolites exhibit almost the same textural parameters (e.g., BET surface area and pore volume) and catalytic performance in cumene cracking and m-xylene isomerization as those of conventional Beta and ZSM-5 zeolites synthesized under hydrothermal conditions (C-Beta and C-ZSM-5). The organotemplate- and solvent-free syntheses of S-Beta and S-ZSM-5 take place at a low-pressure regime and are free of harmful gases as well as give high product yields together with highly efficient consumption of the starting raw materials. These advantages plus the very simple procedures opened the pathway to a highly sustainable zeolite synthesis protocol compared to conventional methods currently employed for C-Beta and C-ZSM-5. Very interestingly, this simple synthesis is a good model for understanding zeolite crystallization. The detail characterizations indicate that the S-Beta crystals are formed from the assembly of zeolite building units, mainly 4MRs, while the 5MRs in the framework are just formed in the crystallization of S-ZSM-5, rather than existence in the starting solid mixture. During the crystallization processes, small traces of water play an important role for the hydrolysis and condensation of silica and/or aluminosilicate species.

New Insight into the Hydrocarbon‐Pool Chemistry of the Methanol‐to‐Olefins Conversion over Zeolite H‐ZSM‐5 from GC‐MS, Solid‐State NMR Spectroscopy, and DFT Calculations

Over zeolite H-ZSM-5, the aromatics-based hydrocarbon-pool mechanism of methanol-to-olefins (MTO) reaction was studied by GC-MS, solid-state NMR spectroscopy, and theoretical calculations. Isotopic-labeling experimental results demonstrated that polymethylbenzenes (MBs) are intimately correlated with the formation of olefin products in the initial stage. More importantly, three types of cyclopentenyl cations (1,3-dimethylcyclopentenyl, 1,2,3-trimethylcyclopentenyl, and 1,3,4-trimethylcyclopentenyl cations) and a pentamethylbenzenium ion were for the first time identified by solid-state NMR spectroscopy and DFT calculations under both co-feeding ([(13) C6 ]benzene and methanol) conditions and typical MTO working (feeding [(13) C]methanol alone) conditions. The comparable reactivity of the MBs (from xylene to tetramethylbenzene) and the carbocations (trimethylcyclopentenyl and pentamethylbenzium ions) in the MTO reaction was revealed by (13) C-labeling experiments, evidencing that they work together through a paring mechanism to produce propene. The paring route in a full aromatics-based catalytic cycle was also supported by theoretical DFT calculations.

NMR-Spectroscopic Evidence of Intermediate-Dependent Pathways for Acetic Acid Formation from Methane and Carbon Monoxide over a ZnZSM-5 Zeolite Catalyst

Two ways: a Zn-modified ZSM-5 zeolite catalyst was developed for the reaction of methane with carbon monoxide to directly produce acetic acid under mild conditions (573-623 K), and two different intermediate-dependent reaction pathways were unambiguously identified for acetic acid formation by in situ solid-state NMR spectroscopy.

Low-Temperature Reactivity of Zn+ Ions Confined in ZSM-5 Zeolite toward Carbon Monoxide Oxidation: Insight from in Situ DRIFT and ESR Spectroscopy

We report the low-temperature catalytic reactivity of Zn(+) ions confined in ZSM-5 zeolite toward CO oxidation. In situ DRIFT and ESR spectroscopy demonstrated that molecular O2 is readily activated by Zn(+) ion to produce O2(-) species at room temperature (298 K) via facile electron transfer between Zn(+) ion and O2 and that the formation of the active O2(-) species is responsible for the high activity of the ZnZSM-5 catalyst toward CO oxidation.

Direct Detection of Supramolecular Reaction Centers in the Methanolto- Olefins Conversion over Zeolite H-ZSM-5 by C-13-Al-27 Solid-State NMR Spectroscopy

Hydrocarbon-pool chemistry is important in methanol to olefins (MTO) conversion on acidic zeolite catalysts. The hydrocarbon-pool (HP) species, such as methylbenzenes and cyclic carbocations, confined in zeolite channels during the reaction are essential in determining the reaction pathway. Herein, we experimentally demonstrate the formation of supramolecular reaction centers composed of organic hydrocarbon species and the inorganic zeolite framework in H-ZSM-5 zeolite by advanced (13)C-(27)Al double-resonance solid-state NMR spectroscopy. Methylbenzenes and cyclic carbocations located near Brønsted acid/base sites form the supramolecular reaction centers in the zeolite channel. The internuclear spatial interaction/proximity between the (13)C nuclei (associated with HP species) and the (27) Al nuclei (associated with Brønsted acid/base sites) determines the reactivity of the HP species. The closer the HP species are to the zeolite framework Al, the higher their reactivity in the MTO reaction.

Experimental Evidence on the Formation of Ethene through Carbocations in Methanol Conversion over H-ZSM-5 Zeolite

The methanol to olefins conversion over zeolite catalysts is a commercialized process to produce light olefins like ethene and propene but its mechanism is not well understood. We herein investigated the formation of ethene in the methanol to olefins reaction over the H-ZSM-5 zeolite. Three types of ethylcyclopentenyl carbocations, that is, the 1-methyl-3-ethylcyclopentenyl, the 1,4-dimethyl-3-ethylcyclopentenyl, and the 1,5-dimethyl-3-ethylcyclopentenyl cation were unambiguously identified under working conditions by both solid-state and liquid-state NMR spectroscopy as well as GC-MS analysis. These carbocations were found to be well correlated to ethene and lower methylbenzenes (xylene and trimethylbenzene). An aromatics-based paring route provides rationale for the transformation of lower methylbenzenes to ethene through ethylcyclopentenyl cations as the key hydrocarbon-pool intermediates.

Transfer Channel of Photoinduced Holes on a TiO2 Surface As Revealed by Solid-State Nuclear Magnetic Resonance and Electron Spin Resonance Spectroscopy

The detailed structure-activity relationship of surface hydroxyl groups (Ti-OH) and adsorbed water (H2O) on the TiO2 surface should be the key to clarifying the photogenerated hole (h+) transfer mechanism for photocatalytic water splitting, which however is still not well understood. Herein, one- and two-dimensional 1H solid-state NMR techniques were employed to identify surface hydroxyl groups and adsorbed water molecules as well as their spatial proximity/interaction in TiO2 photocatalysts. It was found that although the two different types of Ti-OH (bridging hydroxyl (OHB) and terminal hydroxyl (OHT) groups were present on the TiO2 surface, only the former is in close spatial proximity to adsorbed H2O, forming hydrated OHB. In situ 1H and 13C NMR studies of the photocatalytic reaction on TiO2 with different Ti-OH groups and different H2O loadings illustrated that the enhanced activity was closely correlated to the amount of hydrated OHB groups. To gain insight into the role of hydrated OHB groups in the h+ transfer process, in situ ESR experiments were performed on TiO2 with variable H2O loading, which revealed that the hydrated OHB groups offer a channel for the transfer of photogenerated holes in the photocatalytic reaction, and the adsorbed H2O could have a synergistic effect with the neighboring OHB group to facilitate the formation and evolution of active paramagnetic intermediates. On the basis of experimental observations, the detailed photocatalytic mechanism of water splitting on the surface of TiO2 was proposed.

Synergic Effect of Active Sites in Zinc‐Modified ZSM‐5 Zeolites as Revealed by High‐Field Solid‐State NMR Spectroscopy

Understanding the nature of active sites in metal-supported catalysts is of great importance towards establishing their structure-property relationships. The outstanding catalytic performance of metal-supported catalysts is frequently ascribed to the synergic effect of different active sites, which is however not well spectroscopically characterized. Herein, we report the direct detection of surface Zn species and 1 H-67 Zn internuclear interaction between Zn2+ ions and Brønsted acid sites on Zn-modified ZSM-5 zeolites by high-field solid-state NMR spectroscopy. The observed promotion of C-H bond activation of methane is rationalized by the enhanced Brønsted acidity generated by synergic effects arising from the spatial proximity/interaction between Zn2+ ions and Brønsted acidic protons. The concentration of synergic active sites is determined by 1 H-67 Zn double-resonance solid-state NMR spectroscopy.

Unstable-Fe-site-induced formation of mesopores in microporous zeolite Y without using organic templates

A novel organic template-free strategy for generating mesoporosity in Y zeolites is reported. It is revealed that Fe(3+) functioned as unstable sites in the Fe-NaY zeolite, which promotes deferrization-dealumination, leading to enhanced formation of intra-crystalline mesopores as well as desirable interconnectivity. The mesopore-enriched zeolite exhibits a remarkable ability in conversion of the bulky substrate.