Gurbuz Gunes

Inactivation of Escherichia coli (ATCC 4157) in Diluted Apple Cider by Dense-Phase Carbon Dioxide

Dense-phase carbon dioxide (CO2) treatments in a continuous flow through system were applied to apple cider to inactivate Escherichia coli (ATCC 4157). A response surface design with factors of the CO2/product ratio (0, 70, and 140 g/kg), temperature (25, 35, and 45 degrees C), and pressure (6.9, 27.6, and 48.3 MPa) were used. E. coli was very sensitive to dense CO2 treatment, with a more than 6-log reduction in treatments containing 70 and 140 g/kg CO2, irrespective of temperature and pressure. The CO2/product ratio was the most important factor affecting inactivation rate of E. coli. No effect of temperature and pressure was detected because of high sensitivity of the cells to dense CO2. Dense CO2 could be an alternative pasteurization treatment for apple cider. Further studies dealing with the organoleptic quality of the product are needed.

Growth and survival of Escherichia coli O157:H7 on fresh-cut apples in modified atmospheres at abusive temperatures.

The effects of reduced-O2 and elevated-CO2 modified atmospheres (MAs) and abusive temperatures on the growth and survival of E. coli O157:H7, yeast, and molds and on changes in the visual quality of fresh-cut apples were evaluated. High-CO1 and low-O2 (> or = 15% and < 1%, respectively) atmospheres inhibited the growth of the pathogen on apple slices at 15 and 20 degrees C. However, the population of the pathogen increased by 1 log cycle after 2 weeks of storage in air. The high-CO2 MA resulted in the inhibition of yeast and mold growth, less browning, and better visual quality than did air and ambient-CO2 atmospheres. The results of this study confirm that E. coli O157:H7 can grow on apple slices in air. These results also show that these organisms survive but are inhibited in MAs with high CO2 levels at abusive temperatures. An MA can increase the shelf life of fresh-cut apples by improving retention of visual quality and inhibiting yeast and molds. Thus, contamination of minimally processed apples with E. coli O157:H7 can be a safety issue for both air- and MA-packaged cut apples.

Effects of irradiation on respiration and ethylene production of apple slices

Respiration and ethylene production rates of irradiated apple slices from four apple cultivars were measured for 72 h. Doses less than 1.2 kGy had no effect on rates of CO2 production and O2 consumption, and irradiation at doses between 1.2 and 2.4 kGy had minimal effect for all cultivars. Respiratory response of ‘Idared’, ‘Law Rome’ and ‘Empire’ slices to irradiation was curvilinear, with maximum respiration occurring in the 3–6 kGy dose range. Response of ‘Delicious’ slices was linear over the irradiation dose range (0–11 kGy) studied. Respiratory quotient increased with irradiation dose. The degree of maturity of the slices affected respiratory responses. Irradiation reduced ethylene production of all slices. These results suggest that irradiation doses of up to 2.4 kGy can be used with minimum effect on the respiratory physiology of tissues. © 2000 Society of Chemical Industry

Physiological responses of fresh-cut apple slices under high CO2 and low O2 partial pressures

Abstract The physiological responses of ‘Delicious’ apple slices to 0–30 kPa CO 2 at 0–10 kPa O 2 partial pressures at 5°C have been studied. Increasing CO 2 partial pressures from 0 to 30 kPa at 0.5, 1 and 10 kPa O 2 reduced respiration rates and ethylene production of the slices. The inhibitory effect of CO 2 on respiration rate of slices was best explained by an enzyme kinetics model that combined competitive and uncompetitive types of inhibition. Browning increased during storage and was reduced by CO 2 to only a limited extent. CO 2 levels of 15–30 kPa resulted in about a 50% reduction in acetaldehyde, ethanol and ethyl acetate concentrations in tissues under both anaerobic and low-O 2 atmospheres compared with slices kept in CO 2 -free atmospheres. Elevated CO 2 might provide a mechanism to reduce accumulation of fermentation products but sensory quality of slices needs be studied before recommending its use.

Microbial quality of fresh potatoes : Effect of minimal processing

Fresh-cut potatoes were treated with an antibrowning solution (l-cysteine-citric acid mixture) and chlorine solutions, and then packaged under a modified atmosphere. The effect of these treatments on the microbiology of the potatoes was evaluated. Dipping the potato strips in sodium hypochlorite solutions (100 and 300 ppm) resulted in higher microbial populations during the storage period, while potatoes treated with the antibrowning solution combined with modified-atmosphere packaging showed only a slight increase. Modified-atmosphere packaging had no significant-effect on the microbial population compared to nonpackaged samples. The predominant organisms were Pseudomonas fluorescens , along with other Pseudomonas species, and Vibrio fluvialis .

Combined effects of gamma-irradiation and modified atmosphere packaging on quality of some spices

Thyme (Thymus vidgaris L.), rosemary (Rosmarinus officinalis L.), black pepper (Piper nigrum L.) and cumin (Cuminum cyminum L.) in ground form were packaged in either air or 100% N2 and γ-irradiated at 3 different irradiation levels (7kGy, 12kGy, 17kGy). Total viable bacterial count, yeast and mould count, colour, essential oil yield and essential oil composition were determined. Microbial load was not detectable after 12kGy irradiation of all samples. Irradiation resulted in significant changes in colour values of rosemary and black pepper. The discolouration of the irradiated black pepper was lower in modified atmosphere packaging (MAP) compared to air packaging. Essential oil yield of irradiated black pepper and cumin was lower in air packaging compared to MAP. Gamma-irradiation generally decreased monoterpenes and increased oxygenated compounds, but the effect was lower in MAP. Overall, spices should be irradiated under an O2-free atmosphere to minimise quality deterioration.

Impact of shortwave ultraviolet (UV-C) radiation on the antioxidant activity of thyme (Thymus vulgaris L.).

Thyme is a good source of antioxidant compounds but it can be contaminated by microorganisms. An experimental fluid bed ultraviolet (UV) reactor was designed for microbial decontamination of thyme samples and the effect of shortwave ultraviolet light (UV-C) radiation on antioxidant properties of thyme was studied. Samples were exposed to UV-C radiation for 16 or 64 min. UV-C treatment led to 1.04 and 1.38 log CFU/g reduction of total aerobic mesophilic bacteria (TAMB) counts. Hunter a(∗) value was the most sensitive colour parameter during UV-C treatment. 2,2-Diphenyl-1-picrylhydrazyl (DPPH) scavenging activity of extracts was not significantly affected by UV-C. Addition of thyme extracts at 0.15 and 0.3 μmol GAE/ml emulsion delayed the formation of lipid hydroperoxides and headspace hexanal in the 5.0%(wt) corn oil-in-water emulsion from 4 to 9 and 14 days, respectively. No significant changes in oxidation rates were observed between UV-C treated and untreated samples at same concentrations.

Maintenance of Safety and Quality of Refrigerated Ready-to-Cook Seasoned Ground Beef Product (Meatball) by Combining Gamma Irradiation with Modified Atmosphere Packaging

UNLABELLED Meatballs were prepared by mixing ground beef and spices and inoculated with E. coli O157:H7, L. monocytogenes, and S. enteritidis before packaged in modified atmosphere (3% O₂ + 50% CO₂ + 47% N₂) or aerobic conditions. The packaged samples were irradiated at 0.75, 1.5, and 3 kGy doses and stored at 4 °C for 21 d. Survival of the pathogens, total plate count, lipid oxidation, color change, and sensory quality were analyzed during storage. Irradiation at 3 kGy inactivated all the inoculated (approximately 10⁶ CFU/g) S. enteritidis and L. monocytogenes cells in the samples. The inoculated (approximately 10⁶ CFU/g) E. coli O157:H7 cells were totally inactivated by 1.5 kGy irradiation. D¹⁰-values for E. coli O157:H7, S. enteritidis, and L. monocytogenes were 0.24, 0.43, and 0.41 kGy in MAP and 0.22, 0.39, and 0.39 kGy in aerobic packages, respectively. Irradiation at 1.5 and 3 kGy resulted in 0.13 and 0.36 mg MDA/kg increase in 2-thiobarbituric acid-reactive substances (TBARS) reaching 1.02 and 1.49 MDA/kg, respectively, on day 1. Irradiation also caused significant loss of color and sensory quality in aerobic packages. However, MAP effectively inhibited the irradiation-induced quality degradations during 21-d storage. Thus, combining irradiation (3 kGy) and MAP (3% O₂ + 50% CO₂ + 47% N₂) controlled the safety risk due to the potential pathogens and maintained qualities of meatballs during 21-d refrigerated storage. PRACTICAL APPLICATION Combined use of gamma irradiation and modified atmosphere packaging (MAP) can maintain quality and safety of seasoned ground beef (meatball). Seasoned ground beef can be irradiated at 3 kGy and packaged in MAP with 3% O₂ + 50% CO₂ + 47% N₂ gas mixture in a high barrier packaging materials. These treatments can significantly decrease risk due to potential pathogens including E. coli O157:H7, L. monocytogenes, and S. enteritidis in the product. The MAP would reduce the undesirable effects of irradiation on quality, and extend the shelf life of the product for up to 21 d at 3 °C.

Effects of Irradiation Dose and O2 and CO2 Concentrations in Packages on Foodborne Pathogenic Bacteria and Quality of Ready-to-Cook Seasoned Ground Beef Product (Meatball) during Refrigerated Storage

Combined effects of gamma irradiation and concentrations of O2 (0, 5, 21%) and CO2 (0, 50%) on survival of Escherichia coli O157:H7, Salmonella enteritidis, Listeria monocytogenes, lipid oxidation, and color changes in ready-to-cook seasoned ground beef (meatball) during refrigerated storage were investigated. Ground beef seasoned with mixed spices was packaged in varying O2 and CO2 levels and irradiated at 2 and 4 kGy. Irradiation (4 kGy) caused about 6 Log inactivation of the inoculated pathogens. Inactivation of Salmonella was 0.9- and 0.4-Log lower in 0 and 5% O2, respectively, compared to 21% O2. Irradiation at 2 and 4 kGy increased thiobarbituric acid reactive substances in meatballs by 0.12 and 0.28 mg malondialdehyde kg−1, respectively, compared to control. In reduced-O2 packages, radiation-induced oxidation was lower, and the initial color of an irradiated sample was maintained. Packaging with 0% + 50% CO2 or 5% O2 + 50% CO2 maintained the oxidative and the color quality of irradiated meatballs during 14-day refrigerated storage. MAP with 5%O2 + 50% CO2 combined with irradiation up to 4 kGy is suggested for refrigerated meatballs to reduce the foodborne pathogen risk and to maintain the quality.

The impact of the molecular weight of dextran on formation of whey protein isolate (WPI)–dextran conjugates in fibers produced by needleless electrospinning after annealing

The conjugation reaction of electrospun fibers of a mixture of whey protein isolate (WPI) and dextran using different molecular weights (40, 70, and 100 kDa) and mixing ratios was studied. This study includes the electrospinnability of a mixture of WPI and dextran, and the conjugation reaction between them via the initial stage of the Maillard reaction. The WPI-dextran fibers were characterized using optical and transmission electron microscopy. The covalent attachment of dextran to WPI was confirmed using sodium-dodecyl-sulfate-polyacrylamide gel-electrophoresis with protein and glycoprotein staining. Both 70 and 100 kDa of dextran and WPI at mixing ratios of 2 : 1 and 3 : 1 in phosphate buffer (30 mM, pH 6.5) were electrospun using needleless electrospinning. The solution concentration of the mixture was 50 wt% (33.3/37.5 wt% for dextran/16.5/12.5 wt% for WPI). The optimal conjugation conditions chosen from the experiments were a mixture of dextran (70 kDa)-WPI at 3 : 1 (75% relative humidity, 60 °C, 48 h).