Hongxue An

An efficient process for wastewater treatment to mitigate free nitrous acid generation and its inhibition on biological phosphorus removal

Free nitrous acid (FNA), which is the protonated form of nitrite and inevitably produced during biological nitrogen removal, has been demonstrated to strongly inhibit the activity of polyphosphate accumulating organisms (PAOs). Herein we reported an efficient process for wastewater treatment, i.e., the oxic/anoxic/oxic/extended-idle process to mitigate the generation of FNA and its inhibition on PAOs. The results showed that this new process enriched more PAOs which thereby achieved higher phosphorus removal efficiency than the conventional four-step (i.e., anaerobic/oxic/anoxic/oxic) biological nutrient removal process (41 ± 7% versus 30 ± 5% in abundance of PAOs and 97 ± 0.73% versus 82 ± 1.2% in efficiency of phosphorus removal). It was found that this new process increased pH value but decreased nitrite accumulation, resulting in the decreased FNA generation. Further experiments showed that the new process could alleviate the inhibition of FNA on the metabolisms of PAOs even under the same FNA concentration.

Effect of ciprofloxacin on biological nitrogen and phosphorus removal from wastewater

In this work, both short-term and long-term experiments were therefore conducted to assess the effects of ciprofloxacin (0.2 and 2mg·L-1) on wastewater nutrient removal. The results showed that both levels of ciprofloxacin had no acute and chronic adverse effects on the surface integrity and viability of activated sludge. Short-term exposure to all the ciprofloxacin levels induced negligible influences on wastewater nutrient removal. However, the prolonged exposure to ciprofloxacin decreased total phosphorus and nitrogen removal efficiencies from 96.8, 95.8% (control) to 91.7, 84.9% (0.2mg·L-1) and 90.5%, 80.2% (2mg·L-1), respectively. The mechanism study showed that ciprofloxacin exposure suppressed denitrification and phosphorus uptake processes. It was also found that ciprofloxacin affected the transformations of intracellular polyhydroxyalkanoates and glycogen in the oxic and anoxic stages. Moreover the activities of nitrite reductase and polyphosphate kinase were inhibited by the presence of ciprofloxacin. Further analysis with high-throughput sequencing revealed that compared with the control, the abundances of polyphosphate accumulating organisms, glycogen accumulating organisms and denitrifying bacteria in ciprofloxacin exposure reactors reduced, which were consistent with the decreased nutrient removal performance measured in these reactors.

Effective adsorption/electrocatalytic degradation of perchlorate using Pd/Pt supported on N-doped activated carbon fiber cathode

In this work, Pd/Pt supported on N-doped activated carbon fiber (Pd/Pt-NACF) was employed as the electrode for electrocatalytic degradation of perchlorate through adsorption/electroreduction process. Perchlorate in solution was firstly adsorbed on Pd/Pt-NACF and then reduced to non-toxic chloride by the catalytic function of Pd/Pt at a constant current (20mA). Compared with Pd/Pt-ACF, the adsorption capacity and electrocatalytic degradation efficiency of Pd/Pt-NACF for perchlorate increased 161% and 28%, respectively. Obviously, positively charged N-functional groups on NACF surface enhanced the adsorption capacity of Pd/Pt-NACF, and the dissociation of hydrogen to atomic H* by the Pd/Pt nanostructures on the cathode might drastically promote the electrocatalytic reduction of perchlorate. The role of atomic H* in the electroreduction process was identified by tertiary butanol inhibition test. Meanwhile, the perchlorate degradation performance was not substantially lower after three successive adsorption/electrocatalytic degradation experiments, demonstrating the electrochemical reusability and stability of the as-prepared electrode. These results showed that Pd/Pt-NACF was effective for electrocatalytic degradation of perchlorate and had great potential in perchlorate removal from water.

The behavior of melamine in biological wastewater treatment system

Melamine (MA) is a significant raw material for industry and home furnishing, and an intermediate for pharmacy. However it is also a hazardous material when being added to food as a protein substitute due to the high nitrogen content. In this study, the behavior of MA in activated sludge was investigated. Experiments showed that MA was removed during biological wastewater treatment process, and the removal was mainly achieved by activated sludge adsorption instead of biodegradation. Low levels of MA (0.001-0.10mg/L) in wastewater had negligible influence on the performance of activated sludge, but high levels of MA deteriorated biological nitrogen and phosphorus removal. The presence of MA (1.00 and 5.00mg/L) decreased total nitrogen removal efficiency from 94.15% to 79.47% and 68.04%, respectively. The corresponding concentration of effluent phosphorus increased from 0.11 to 1.45 and 2.06mg/L, respectively. It was also observed that MA inhibited the enzyme activities of nitrite oxidoreductase, nitrate reductase, nitrite reductase and exopolyphosphatase, which were closely relevant to nitrogen and phosphorus removal. Further investigation showed that the presence of high MA concentrations promoted the consumption and synthesis of glycogen, thereby providing the advantage for the growth of glycogen accumulating organisms.

Effect of nickel on the flocculability, settleability, and dewaterability of activated sludge

Short-term and long-term effects of nickel (Ni) (0.1-10mg/L) on the physicochemical properties of activated sludge, including the flocculability, settleability, and dewaterability, were investigated. It was found that these properties were unaffected after short-term exposure (1day) to Ni(II) even at the level of 10mg/L. After long-term exposure (60days) to 1 and 10mg/L of Ni(II), however, the sludge flocculability has seriously deteriorated, while the settleability, and dewaterability became gradually better than the control. The mechanism studies revealed that long-term exposure to Ni(II) resulted in the decrease of protein content in extracellular polymeric substances (EPS) and the damage to EPS structures. Although Ni(II) did not bring any adverse effect on the cell membrane, the relative hydrophobicity of activated sludge was significantly decreased. The negative effects on the flocculability and phosphorus removal performance of activated sludge could be completely eliminated by adding the chelator such as EDTA and citrate.

Feasibility of enhancing short-chain fatty acids production from waste activated sludge after free ammonia pretreatment: Role and significance of rhamnolipid

This study reported a new, renewable and high-efficient strategy for anaerobic fermentation, i.e., using free ammonia (FA) to pretreat waste activated sludge (WAS) for 1 d and then combining with rhamnolipid (RL), by which the short-chain fatty acids (SCFA) production was remarkably improved. Experimental results showed the maximal SCFA production of 324.7 ± 13.9 mg COD/g VSS was achieved at 62.6 mg FA/L pretreatment combined with 0.04 g RL/g TSS, which was respectively 5.95-fold, 1.63-fold and 1.41-fold of that from control, FA pretreatment and RL pretreatment. Mechanism investigations revealed that FA + RL enhanced sludge solubilization and hydrolysis, providing more organics for subsequent SCFA production. It was also found that the combined method inhibited acidogenesis and methanogenesis, but the inhibition to methanogenesis was much severer than that to acidogenesis. Finally, the feasibility of NH4+-N and PO3-4-P, released in fermentation liquor, being recovered as magnesium ammonium phosphate (MAP) was confirmed.

Perchlorate bioreduction linked to methane oxidation in a membrane biofilm reactor: Performance and microbial community structure

Perchlorate bioreduction coupled to methane oxidation was successfully achieved without the addition of nitrate or nitrite in a membrane biofilm reactor (MBfR) inoculated with a mixture of freshwater sediments and anaerobic digester sludge as well as return activated sludge. The reactor was operated at different methane pressures (60, 40 and 20 Kpa) and influent perchlorate concentrations (1, 5 and 10 mg/L) to evaluate the biochemical process of perchlorate bioreduction coupled to methane oxidation. Perchlorate was completely reduced with a higher removal flux of 92.75 mg/m2·d using methane as the sole carbon source and electron donor, other than hydrogen or other limiting organics. Quantitative real-time PCR showed that bacteria prevailed over archaea and the abundances of mcrA, pMMO, pcrA, and nirS genes were correlated with the influent perchlorate flux. High-throughput sequencing of 16S rRNA genes demonstrated that the functional community consisted of methanotrophs, methylotrophs, perchlorate-reducing bacteria, as well as various denitrifiers.

Free ammonia-based pretreatment enhances phosphorus release and recovery from waste activated sludge

The recovery of phosphorus from waste activated sludge (WAS) was usually at low levels due to low phosphorus release. This study presents a novel, cost-effective and eco-friendly pretreatment method, e.g., using free ammonia (FA) to pretreat WAS, to enhance the phosphorus release from WAS. Experimental results showed that the phosphorus release from WAS was significantly increased after FA pretreatment at up to 189.4 mg NH3-N L-1 for 24 h, under which the released PO43--P (i.e. 101.6 ± 6.7 mg L-1) was higher than that pH 9 (i.e. 62.6 ± 4.54 mg L-1) and control (without pH and FA pretreatment) (i.e. 15.1 ± 1.86 mg L-1). More analysis revealed that the FA induced improvement in phosphorus release could be attributed to the disintegration of extracellular polymeric substances (EPS) and cell envelope of sludge cells. Moreover, the released phosphorus recovered as magnesium ammonium phosphate (MAP) was confirmed. The findings reported may guide engineers to develop an economic and practical strategy to enhance resources and energy recovery from WAS.