James T. C. Yuan

Increased inactivation of ozone-treated Clostridium perfringens vegetative cells and spores on fabricated beef surfaces using mild heat.

Ozone treatment of beef surfaces enhanced the effectiveness of cooking temperatures ranging from 45 to 75 degrees C against enterotoxin-producing strains of Clostridium perfringens. Vegetative cells on beef surfaces at an initial concentration of 5.59 +/- 0.17 log CFU/g were reduced significantly (P < 0.05) to 4.09 +/- 0.72 log CFU/g and 3.50 +/- 0.90 log CFU/g after combined treatments with aqueous ozone (5 ppm) and subsequent heating at 45 and 55 degrees C, respectively. Spores on the beef surface were likewise significantly reduced from an initial concentration of 2.94 +/- 0.37 log spores per g to 2.07 +/- 0.38 log spores per g and 1.70 +/- 0.37 log spores per g after the combined treatment with aqueous ozone (5 ppm) and subsequent heating at 55 and 75 degrees C, respectively. Fluorescent nucleic acid stains were used with confocal fluorescence microscopy to show that spores remaining attached to the meat were protected from treatment-specific injury. This study provides evidence for the decreased resistance of both vegetative cells and spores of C. perfringens with ozone treatment that is followed by heat treatment at temperatures that would not otherwise be as effective, thus lowering the requirements for cooking beef while maintaining a margin of safety.

Viability of Clostridium perfringens, Escherichia coli, and Listeria monocytogenes surviving mild heat or aqueous ozone treatment on beef followed by heat, alkali, or salt stress.

The threat of pathogen survival following ozone treatment of meat necessitates careful evaluation of the microorganisms surviving under such circumstances. The objective of this study was to determine whether sublethal aqueous ozone treatment (3 ppm of O3 for 5 min) of microorganisms on beef surfaces would result in increased or decreased survival with respect to subsequent heat, alkali, or NaCl stress. A mild heat treatment (55 degrees C for 30 min) was used for comparison. Reductions in three-strain cocktails of Clostridium perfringens, Escherichia coli O157:H7, and Listeria monocytogenes on beef following the heat treatment were 0.14, 0.77, and 1.47 log10 CFU/g, respectively, whereas reductions following ozone treatment were 1.28, 0.85, and 1.09 log10 CFU/g, respectively. C. perfringens cells exhibited elevated heat resistance at 60 degrees C (D60 [time at 60 degrees C required to reduce the viable cell population by 1 log10 units or 90%] = 17.76 min) following heat treatment of beef (55 degrees C for 30 min) but exhibited reduced viability at 60 degrees C following ozone treatment (D60 = 7.64 min) compared with the viability of untreated control cells (D60 = 13.84 min). The D60-values for L. monocytogenes and E. coli O157:H7 following heat and ozone exposures were not significantly different (P > 0.05). C. perfringens cells that survived ozone treatment did not exhibit increased resistance to pH (pH 6 to 12) relative to non-ozone-treated cells when grown at 37 degrees C for 24 h. The heat treatment also resulted in decreased numbers of surviving cells above and below neutral pH values for both E. coli O157:H7 and L. monocytogenes relative to those of non-heat-treated cells grown at 37 degrees C for 24 h. There were significant differences (P < 0.05) in C. perfringens reductions with increasing NaCl concentrations. The effects of NaCl were less apparent for E. coli and L. monocytogenes survivors. It is concluded that pathogens surviving ozone treatment of beef are less likely to endanger food safety than are those surviving sublethal heat treatments.