Jette Thykaer

Comparative genomics of citric-acid-producing Aspergillus niger ATCC 1015 versus enzyme-producing CBS 513.88

The filamentous fungus Aspergillus niger exhibits great diversity in its phenotype. It is found globally, both as marine and terrestrial strains, produces both organic acids and hydrolytic enzymes in high amounts, and some isolates exhibit pathogenicity. Although the genome of an industrial enzyme-producing A. niger strain (CBS 513.88) has already been sequenced, the versatility and diversity of this species compel additional exploration. We therefore undertook whole-genome sequencing of the acidogenic A. niger wild-type strain (ATCC 1015) and produced a genome sequence of very high quality. Only 15 gaps are present in the sequence, and half the telomeric regions have been elucidated. Moreover, sequence information from ATCC 1015 was used to improve the genome sequence of CBS 513.88. Chromosome-level comparisons uncovered several genome rearrangements, deletions, a clear case of strain-specific horizontal gene transfer, and identification of 0.8 Mb of novel sequence. Single nucleotide polymorphisms per kilobase (SNPs/kb) between the two strains were found to be exceptionally high (average: 7.8, maximum: 160 SNPs/kb). High variation within the species was confirmed with exo-metabolite profiling and phylogenetics. Detailed lists of alleles were generated, and genotypic differences were observed to accumulate in metabolic pathways essential to acid production and protein synthesis. A transcriptome analysis supported up-regulation of genes associated with biosynthesis of amino acids that are abundant in glucoamylase A, tRNA-synthases, and protein transporters in the protein producing CBS 513.88 strain. Our results and data sets from this integrative systems biology analysis resulted in a snapshot of fungal evolution and will support further optimization of cell factories based on filamentous fungi.

Metabolic engineering of β-lactam production

Abstract Metabolic engineering has become a rational alternative to classical strain improvement in optimisation of β -lactam production. In metabolic engineering directed genetic modification are introduced to improve the cellular properties of the production strains. This has resulted in substantial increases in the existing β -lactam production processes. Furthermore, pathway extension, by heterologous expression of novel genes in well-characterised strains, has led to introduction of new fermentation processes that replace environmentally damaging chemical methods. This minireview discusses the recent developments in metabolic engineering and the applications of this approach for improving β -lactam production.

Metabolic characterization of high- and low-yielding strains of Penicillium chrysogenum

Abstract A recently developed method for analyzing metabolic networks using 13C-labels was employed for investigating the metabolism of a high- and a low-yielding strain of Penicillium chrysogenum. Under penicillin-producing conditions, the flux through the pentose phosphate (PP) pathway in the high- and the low-yielding strains was estimated to 70 and 66, respectively. When the high-yielding strain was cultivated in a medium without the penicillin side chain precursor, phenoxyacetic acid, the PP pathway flux was estimated as 71. Thus, in all three experiments, the flux through the PP pathway was almost constant with an average value of 69 ± 3, and the method therefore allows for a very reproducible estimation of the PP pathway flux. Phenoxyacetic acid was found to be a source of cytosolic acetyl-CoA and thereby a source of precursors for the biosynthesis of 2-aminoadipic acid, which is a central amino acid in penicillin biosynthesis. However, the labeling patterns also indicated the presence of an unrecognized pathway to cytosolic acetyl-CoA.

Increased glycopeptide production after overexpression of shikimate pathway genes being part of the balhimycin biosynthetic gene cluster

Amycolatopsis balhimycina produces the vancomycin-analogue balhimycin. The strain therefore serves as a model strain for glycopeptide antibiotic production. Previous characterisation of the balhimycin biosynthetic cluster had shown that the border sequences contained both, a putative 3-deoxy-d-arabino-heptulosonate 7-phosphate synthase (dahp), and a prephenate dehydrogenase (pdh) gene. In a metabolic engineering approach for increasing the precursor supply for balhimycin production, the dahp and pdh genes from the biosynthetic cluster were overexpressed both individually and together and the resulting strains were subjected to quantitative physiological characterisation. The constructed strains expressing an additional copy of the dahp gene and the strain carrying an extra copy of both dahp and pdh showed improved specific glycopeptide productivities by approximately a factor three, whereas the pdh overexpression strain showed a production profile similar to the wild type strain. In addition to the overexpression strains, corresponding deletion mutants, Deltadahp and Deltapdh, were constructed and characterised. Deletion of dahp resulted in significant reduction in balhimycin production whereas the Deltapdh strain had production levels similar to the parent strain. Based on these results the relation between primary and secondary metabolism with regards to Dahp and Pdh is discussed.

Differential proteomic analysis reveals novel links between primary metabolism and antibiotic production in Amycolatopsis balhimycina

A differential proteomic analysis, based on 2‐DE and MS procedures, was performed on Amycolatopsis balhimycina DSM5908, the actinomycete producing the vancomycin‐like antibiotic balhimycin. A comparison of proteomic profiles before and during balhimycin production characterized differentially and constitutively expressed protein isoforms, which were associated with 203 ORFs in the A. balhimycina genome. These data, providing insights on the major metabolic pathways/molecular processes operating in this organism, were used to compile 2‐DE reference maps covering 3–10, 4–7 and 4.5–5.5 pH gradients available over the World Wide Web as interactive web pages (http://www.unipa.it/ampuglia/Abal‐proteome‐maps). Functional clustering analysis revealed that differentially expressed proteins belong to functional groups involved in central carbon metabolism, amino acid metabolism and protein biosynthesis, energetic and redox balance, sugar/amino sugar metabolism, balhimycin biosynthesis and transcriptional regulation or with hypothetical and/or unknown function. Interestingly, proteins involved in the biosynthesis of balhimycin precursors, such as amino acids, amino sugars and central carbon metabolism intermediates, were upregulated during antibiotic production. qRT‐PCR analysis revealed that 8 out of 14 upregulated genes showed a positive correlation between changes at translational and transcriptional expression level. Furthermore, proteomic analysis of two nonproducing mutants, restricted to a sub‐set of differentially expressed proteins, showed that most proteins required for the biosynthesis of balhimycin precursors are downregulated in both mutants. These findings suggest that primary metabolic pathways support anabolic routes leading to balhimycin biosynthesis and the differentially expressed genes are interesting targets for the construction of high‐yielding producer strains by rational genetic engineering.

Dispersive solid phase extraction combined with ion-pair ultra high-performance liquid chromatography tandem mass spectrometry for quantification of nucleotides in Lactococcus lactis

Analysis of intracellular metabolites in bacteria is of utmost importance for systems biology and at the same time analytically challenging due to the large difference in concentrations, multiple negative charges, and high polarity of these compounds. To challenge this, a method based on dispersive solid phase extraction with charcoal and subsequent analysis with ion-pair liquid chromatography coupled with electrospray ionization tandem mass spectrometry was established for quantification of intracellular pools of the 28 most important nucleotides. The method can handle extracts where cells leak during the quenching. Using a Phenyl-Hexyl column and tributylamine as volatile ion-pair reagent, sufficient retention and separation was achieved for mono-, di-, and triphosphorylated nucleotides. Stable isotope labeled nucleotides were used as internal standards for some analytes. The method was validated by determination of the recovery, matrix effects, accuracy, linearity, and limit of detection based on spiking of medium blank as well as standard addition to quenched Lactococcus lactis samples. For standard addition experiments, the isotope-labeled standards needed to be added in similar or higher concentrations as the analytes. L. lactis samples had an energy charge of 0.97 ± 0.001 which was consistent with literature, whereas some differences were observed compared with legacy data based on ³³P labeling.

Identification of a transcription factor controlling pH-dependent organic acid response in Aspergillus niger.

Acid formation in Aspergillus niger is known to be subjected to tight regulation, and the acid production profiles are fine-tuned to respond to the ambient pH. Based on transcriptome data, putative trans-acting pH responding transcription factors were listed and through knock out studies, mutants exhibiting an oxalate overproducing phenotype were identified. The yield of oxalate was increased up to 158% compared to the wild type and the corresponding transcription factor was therefore entitled Oxalic Acid repression Factor, OafA. Detailed physiological characterization of one of the ΔoafA mutants, compared to the wild type, showed that both strains produced substantial amounts of gluconic acid, but the mutant strain was more efficient in re-uptake of gluconic acid and converting it to oxalic acid, particularly at high pH (pH 5.0). Transcriptional profiles showed that 241 genes were differentially expressed due to the deletion of oafA and this supported the argument of OafA being a trans-acting transcription factor. Furthermore, expression of two phosphoketolases was down-regulated in the ΔoafA mutant, one of which has not previously been described in fungi. It was argued that the observed oxalate overproducing phenotype was a consequence of the efficient re-uptake of gluconic acid and thereby a higher flux through glycolysis. This results in a lower flux through the pentose phosphate pathway, demonstrated by the down-regulation of the phosphoketolases. Finally, the physiological data, in terms of the specific oxygen consumption, indicated a connection between the oxidative phosphorylation and oxalate production and this was further substantiated through transcription analysis.

Differential proteomic analysis highlights metabolic strategies associated with balhimycin production in Amycolatopsis balhimycina chemostat cultivations.

BackgroundProteomics was recently used to reveal enzymes whose expression is associated with the production of the glycopeptide antibiotic balhimycin in Amycolatopsis balhimycina batch cultivations. Combining chemostat fermentation technology, where cells proliferate with constant parameters in a highly reproducible steady-state, and differential proteomics, the relationships between physiological status and metabolic pathways during antibiotic producing and non-producing conditions could be highlighted.ResultsTwo minimal defined media, one with low Pi (0.6 mM; LP) and proficient glucose (12 g/l) concentrations and the other one with high Pi (1.8 mM) and limiting (6 g/l; LG) glucose concentrations, were developed to promote and repress antibiotic production, respectively, in A. balhimycina chemostat cultivations. Applying the same dilution rate (0.03 h-1), both LG and LP chemostat cultivations showed a stable steady-state where biomass production yield coefficients, calculated on glucose consumption, were 0.38 ± 0.02 and 0.33 ± 0.02 g/g (biomass dry weight/glucose), respectively. Notably, balhimycin was detected only in LP, where quantitative RT-PCR revealed upregulation of selected bal genes, devoted to balhimycin biosynthesis, and of phoP, phoR, pstS and phoD, known to be associated to Pi limitation stress response. 2D-Differential Gel Electrophoresis (DIGE) and protein identification, performed by mass spectrometry and computer-assisted 2 D reference-map http://www.unipa.it/ampuglia/Abal-proteome-maps matching, demonstrated a differential expression for proteins involved in many metabolic pathways or cellular processes, including central carbon and phosphate metabolism. Interestingly, proteins playing a key role in generation of primary metabolism intermediates and cofactors required for balhimycin biosynthesis were upregulated in LP. Finally, a bioinformatic approach showed PHO box-like regulatory elements in the upstream regions of nine differentially expressed genes, among which two were tested by electrophoresis mobility shift assays (EMSA).ConclusionIn the two chemostat conditions, used to generate biomass for proteomic analysis, mycelia grew with the same rate and with similar glucose-biomass conversion efficiencies. Global gene expression analysis revealed a differential metabolic adaptation, highlighting strategies for energetic supply and biosynthesis of metabolic intermediates required for biomass production and, in LP, for balhimycin biosynthesis. These data, confirming a relationship between primary metabolism and antibiotic production, could be used to increase antibiotic yield both by rational genetic engineering and fermentation processes improvement.

Industrial glucoamylase fed‐batch benefits from oxygen limitation and high osmolarity

The market for glucoamylase is large and very competitive and the production process has been optimized through several decades. So far a thorough characterization of the process has not been published, but previous academic reports suggest that the process suffers from severe byproduct formation. In this study we have carried out a thorough characterization of a process as close as possible to the industrial reality. The results show that the oxygen‐limited phases of the process have the highest glucoamylase yields on carbon and that the byproducts are efficiently reused in late phases of the process. An alternative process with low glucose concentration show that high osmolarity is beneficial for the process, and we conclude that oxygen limitation, high osmolarity, and the associated byproduct metabolism are important for the efficiency of the process. Biotechnol. Bioeng. 2012;109: 116–124.

Essential pathway identification: from in silico analysis to potential antifungal targets in Aspergillus fumigatus.

Computational metabolic flux modeling has been a great aid for both understanding and manipulating microbial metabolism. A previously developed metabolic flux model for Aspergillus niger, an economically important biotechnology fungus known for protein and organic acid production, is comprised of 1190 biochemically unique reactions that are associated with 871 open reading frames. Through a systematic in silico deletion of single metabolic reactions using this model, several essential metabolic pathways were identified for A. niger. A total of 138 reactions were identified as being essential biochemical reactions during growth on a minimal glucose medium. The majority of the reactions grouped into essential biochemical pathways covering cell wall biosynthesis, amino acid biosynthesis, energy metabolism and purine and pyrimidine metabolism. Based on the A. niger open reading frames associated with the reactions, we identified orthologous candidate essential genes in Aspergillus fumigatus. Our predictions are validated in part by the modes of action for some antifungal drugs and by molecular genetic studies of essential genes in A. fumigatus and other fungi. The use of metabolic models to predict essential reactions and pathways in Aspergillus spp. has promise to inform reverse genetic studies of gene essentiality and identify potential targets for antifungal development.