João Coutinho

Methods to improve the composting process of the solid fraction of dairy cattle slurry

Cattle slurry solid fraction (SF) with different dry matter (DM) contents was collected from two dairy farms and composted in static and turned piles, with different sizes and cover types, to investigate the effects of pile conditions on the physical and chemical changes in SF during composting and to identify approaches to improve final compost quality. Thermophilic temperatures were attained soon after separation of SF, but the temperature of piles covered with polyethylene did not increase above 60 degrees C. The rate of organic matter (OM) mineralisation increased for turned piles in comparison to static piles, but the maximum amount of mineralisable OM (630-675gkg(-1)) was similar for all pile treatments. The C/N ratio declined from over 36 to a value of 14 towards the end of composting, indicating an advanced degree of OM stabilisation. Mature compost was obtained from raw SF feedstock as indicated by the low compost temperature, low C/N ratio, and low content of NH(4)(+) combined with increased concentrations of NO(3)(-). The efficiency of the composting process was improved and NH(3)-N losses were minimized by increasing DM content of the SF, reducing the frequency of pile turning and managing compost piles without an impermeable cover.

Microbiological and physicochemical characterization of olive mill wastewaters from a continuous olive mill in Northeastern Portugal

The microbiological and physicochemical characterization of samples from the different wastewaters generated during oil extraction in a continuous olive mill was performed. The main aim was to determine which of the physicochemical parameters were the best fitted to correctly characterize these residual waters. High correlations were obtained for COD, DOC, K, P and N contents with the sampling points, allowing the distinction of olive washing waters (OWW) from olive centrifuge waters (OCW) and olive mill wastewaters (OMW). These parameters were sufficient for a rapid and less costly chemical characterization of these waters. Phenols and oil and grease contents, together with low pH and dissolved oxygen contents, and high organic loads, were the most toxic for microbial populations. Microbial characterization showed that fungi were well adapted to these stressing environmental characteristics and the reuse of OMW after aerobic treatment with microbial species isolated from the effluent is considered.

Effect of cattle slurry pre-treatment by separation and addition of nitrification inhibitors on gaseous emissions and N dynamics: A laboratory study

The application of untreated or treated animal manure to soils can result in increased N and C gaseous emissions contributing to ecosystem change and global warming. In the present study, dairy cattle slurry (liquid manure) was subjected first to pre-treatment by separation using a screw press to obtain a liquid (LF) and a solid fraction (SF). Then, the different fractions and the whole slurry (WS) were combined with two nitrification inhibitors (NI), dicyandiamide (DCD) or 3,4-dimethylpyrazole phosphate (DMPP), were applied to soil to assess the effect of slurry treatment by separation and NI addition on soil N dynamics and CH4, CO2, NH3, NO and N2O emissions. The WS and the two slurry fractions, combined or not with DCD or DMPP, were applied to soil at an equivalent field dosage of 120 kg total N ha(-1). Controls including a soil only, soil-DCD and soil-DMPP treatments were also included. The mixtures were incubated for 93-d at 20 degrees C. Results obtained show that NI inhibited nitrification between 16 and 30-d in WS and LF, with DMPP having a longer effect over time compared to DCD. There was no significant effect of NI on nitrification for the SF treatment. Nitrification inhibitors did not significantly affect (P>0.05) the CH4, CO2 and N2O emissions, but significantly decreased (P<0.05) NO emissions. Furthermore, the two NIs had a similar effect on gaseous emissions. Throughout the entire experiment, the greatest amount of NO was released from the LF treatment (without NI), while the greatest amount of N2O was released from the SF treatment. Slurry separation had no impact on N emissions, while the combination of this process with one of the two NI led to a small reduction in total N emissions.

Effect of cattle slurry separation on greenhouse gas and ammonia emissions during storage.

Storage of cattle slurry leads to emissions of methane (CH(4)), nitrous oxide (N(2)O), ammonia (NH(3)), and carbon dioxide (CO(2)). On dairy farms, winter is the most critical period in terms of slurry storage due to cattle housing and slurry field application prohibition. Slurry treatment by separation results in reduced slurry dry matter content and has considerable potential to reduce gaseous emissions. Therefore, the efficiency of slurry separation in reducing gaseous emissions during winter storage was investigated in a laboratory study. Four slurry fractions were obtained: a solid and a liquid fraction by screw press separation (SPS) and a supernatant and a sediment fraction by chemically enhanced settling of the liquid fraction. Untreated slurry and the separated fractions were stored in plastic barrels for 48 d under winter conditions, and gaseous emissions were measured. Screw press separation resulted in an increase of CO(2) (650%) and N(2)O (1240%) emissions due to high releases observed from the solid fraction, but this increase was tempered by using the combined separation process (CSP). The CSP resulted in a reduction of CH(4) emissions ( approximately 50%), even though high emissions of CH(4) (46% of soluble C) were observed from the solid fraction during the first 6 d of storage. Screw press separation increased NH(3) emissions by 35%, but this was reduced to 15% using the CSP. During winter storage greenhouse gas emissions from all treatments were mainly in the form of CH(4) and were reduced by 30 and 40% using SPS and CSP, respectively.

Treatment by acidification followed by solid-liquid separation affects slurry and slurry fractions composition and their potential of N mineralization.

The aim of the present work was to assess the effect of treatments by acidification, solid-liquid separation or acidification followed by solid-liquid separation on the physical and chemical composition of pig slurry (S) and pig slurry fractions (non acidified and acidified solid (SF and ASF) and liquid (LF and ALF) fractions), as well as on the potential of N mineralization of these pig slurry derived materials. Acidification strongly decrease the inorganic carbon content of S, SF and LF and it also affects the distribution of P, Ca and Mg between the solid and liquid fraction leading to an ALF more equilibrated than LF in terms of nutrients. Acidification increases the potential of organic N mineralization in SF and decreases the potential of N immobilization in S and LF. It can be concluded that the proposed treatment generates valuable slurry fractions with distinct characteristics and potential of N mineralization that may be incorporated to soil at different periods after sowing to comply with plant nutrient requirements.

Ultraviolet-B radiation and nitrogen effects on growth and yield of maize under Mediterranean field conditions

The effects of an increase in UV-B radiation on growth and yield of maize (Zea mays L.) were investigated at four levels of applied nitrogen (0, 100, 200 and 300 kg ha−1 of N) under Mediterranean field conditions. The experiment simulated a 20% stratospheric ozone depletion over Portugal. Enhanced UV-B and N deficiency decreased yield and total biomass production by 22–49%. High UV-B dose reduced yield, total biomass and growth of N-fertilized maize plants but did not affect N-stressed plants to the same extent. The response of grain yield to N was smaller with enhanced UV-B radiation. The underlying mechanisms for these results are discussed. This is the final, accepted and revised manuscript of this article. Use alternative location to go to the published article. Requires subscription. (Less)

Influence of Two Nitrification Inhibitors (DCD and DMPP) on Annual Ryegrass Yield and Soil Mineral N Dynamics after Incorporation with Cattle Slurry

Nitrogen (N) losses through nitrate leaching, occurring after slurry spreading, can be reduced by the use of nitrification inhibitors (NIs) such as dicyandiamide (DCD) and 3,4‐dimethyl pyrazole phosphate (DMPP). In the present work, the effects of DCD and DMPP, applied at two rates with cattle slurry, on soil mineral N profiles, annual ryegrass yield, and N uptake were compared under similar pedoclimatic conditions. Both NIs delayed the nitrate formation in soil; however, DMPP ensured that the soil mineral N was predominantly in the ammonium form rather than in the nitrate form for about 100 days, whereas with DCD such effect was observed only during the first 40 days after sowing. Furthermore, the use of NIs led to an increase of the dry‐matter (DM) yields in a range of 32–54% and of the forage N removal in a range of 34–68% relative to the slurry‐only (SO) treatment (without NIs). A DM yield of 8698 kg ha−1 was obtained with the DMPP applied at the greater rate against only 7444 kg ha−1 obtained with the greater rate of DCD (4767 kg ha−1 in the SO treatment). Therefore, it can be concluded that DMPP is more efficient as an NI than DCD when combined with cattle slurry.

Nitrate leaching from sandy loam soils under a double-cropping forage system estimated from suction-probe measurements

AbstractNitrate leaching from a double-cropping forage system was measured over a 2-year period (June 1994–May 1996) in the Northwest region of Portugal using ceramic cup samplers. The crops were grown for silage making and include maize (from May to September) and a winter crop (rest of the year) consisting of a mixture of cereals and Italian ryegrass. The experiment was performed on two different sites with a history of many years under the same crop and fertiliser management, but differing in the amounts of N applied as fertiliser and by regular cattle slurry applications. The annual nitrate leaching losses measured ranged from 154 to 338 kg N ha-1. These amounts lead to annual mean concentrations between 22 and 41 mg

Simple technologies for on-farm composting of cattle slurry solid fraction.

NO_3^ -