Kimberly J. B. Sokorai

Sensorial, nutritional and microbiological quality of fresh cilantro leaves as influenced by ionizing radiation and storage☆

The impact of gamma irradiation on aroma, appearance, nutritional, textural, and microbiological quality attributes of fresh cilantro (Coriandrum sativum L.) was investigated. Irradiation at doses up to 2 kGy did not significantly influence aroma, amount of total volatile compounds, color or overall visual quality. Although firmness of cilantro was reduced by irradiation at day 0, there was no significant difference among treatments after 3, 7 and 14 days of storage at 3 °C. Irradiation did not have a consistent effect on antioxidant power or phenolic content during the 14-day storage. In contrast, vitamin C content was lower at day 14 in samples irradiated at 2 and 3 kGy. Cilantro irradiated at 3 kGy had higher decay rate and off-odor scores than other samples after 14 days of storage. The total aerobic plate count of irradiated cilantro was significantly lower than that of nonirradiated controls immediately after irradiation and during the entire storage period. Our results suggest that fresh cilantro irradiated at 2 kGy retained its sensorial quality and shelf life.

Radiation (Gamma) Resistance and Postirradiation Growth of Listeria monocytogenes Suspended in Beef Bologna Containing Sodium Diacetate and Potassium Lactate

Listeria monocytogenes, a psychrotrophic foodborne pathogen, is a frequent postprocessing contaminant of ready-to-eat (RTE) meat products, including frankfurters and bologna. Ionizing radiation can eliminate L. monocytogenes from RTE meats. When they are incorporated into fine-emulsion sausages, sodium diacetate (SDA) and potassium lactate (PL) mixtures inhibit the growth of L. monocytogenes. The radiation resistance of L. monocytogenes, and its ability to proliferate during long-term refrigerated storage (9 degrees C), when inoculated into beef bologna that contained 0% SDA-0% PL, 0.07% SDA-1% PL, and 0.15% SDA-2% PL, were determined. The radiation doses required to eliminate 90% of the viable L. monocytogenes cells were 0.56 kGy for bologna containing 0% SDA-0% PL, 0.53 kGy for bologna containing 0.07% SDA-1% PL, and 0.46 kGy for bologna containing 0.15% SDA-2% PL. L. monocytogenes was able to proliferate on bologna containing 0% SDA-0% PL during refrigerated storage, but the onset of proliferation was delayed by the addition of the SDA-PL mixtures. An ionizing radiation dose of 3.0 kGy prevented the proliferation of L. monocytogenes and background microflora in bologna containing 0.07% SDA-1% PL and in bologna containing 0.15% SDA-2% PL over 8 weeks of storage at 9 degrees C. Little effect on lipid oxidation and color of the control bologna, or bologna containing SDA-PL mixtures, was observed upon irradiation at either 1.5 or 3.0 kGy.

Retention of Quality and Nutritional Value of 13 Fresh-Cut Vegetables Treated with Low-Dose Radiation

Improving the microbial safety while maintaining quality of fresh fruits and vegetables will increase consumer confidence in fresh produce. This study was conducted to investigate the effects of irradiation at 1 kGy, a dose that potentially inactivates E. coli O157:H7 by 5 logs, on the quality of 13 common fresh-cut vegetables: iceberg, romaine, green and red leaf lettuce, spinach, tomato, cilantro, parsley, green onion, carrot, broccoli, red cabbage, and celery. The results showed that the appearance of irradiated samples was similar to the nonirradiated ones except that irradiated carrots, celery, cilantro, and green onions had higher appearance scores than corresponding nonirradiated vegetables. There was no difference in the instrumental texture between irradiated samples and nonirradiated ones. The aroma of several irradiated vegetables was significantly better than controls after 14-d storage, because these control samples decayed or senesced. The 1 kGy irradiation did not affect vitamin C content of most vegetables; however, irradiated green and red leaf lettuce had 24% to 53% lower vitamin C contents than the controls. Our results suggest that most fresh-cut fruits and vegetables tested can tolerate up to 1 kGy irradiation without significant losses in any of the quality attributes.

Factors affecting thermally induced furan formation.

Furan, a potential carcinogen, can be induced by heat from sugars, ascorbic acid, and fatty acids. The objective of this research was to investigate the effect of pH, phosphate, temperature, and heating time on furan formation. Heat-induced furan formation from free sugars, ascorbic acid, and linoleic acid was profoundly affected by pH and the presence of phosphate. In general, the presence of phosphate increased furan formation in solutions of sugars and ascorbic acid. In a linoleic acid emulsion, phosphate increased the formation of furan at pH 6 but not at pH 3. When an ascorbic acid solution was heated, higher amounts of furan were produced at pH 3 than at pH 6 regardless of phosphates presence. However, in linoleic acid emulsion, more furan was produced at pH 6 than at pH 3. The highest amount of furan was formed from the linoleic acid emulsion at pH 6. In fresh apple cider, a product with free sugars as the major components (besides water) and little fatty acids, ascorbic acid, or phosphate, small or very low amounts of furan was formed by heating at 90-120 degrees C for up to 10 min. The results indicated that free sugars may not lead to significant amounts of furan formation under conditions for pasteurization and sterilization. Importantly, this is the first report demonstrating that phosphate (in addition to pH) plays a significant role in thermally induced furan formation.

Effect of citric acid on the radiation resistance of Listeria monocytogenes and frankfurter quality factors.

Listeria monocytogenes is a common contaminant of ready-to-eat meat products, including frankfurters. Ionizing (gamma) radiation can eliminate L. monocytogenes from frankfurters. Citric acid (CA) is an antioxidant synergist and anti-microbial agent that can be applied to the surfaces of cured meat products prior to packaging. The effect of CA on the radiation resistance of L. monocytogenes that was surface-inoculated onto frankfurters was determined. The D(10) values, the radiation doses required to inactivate 90% of viable L. monocytogenes, were 0.61, 0.60, 0.54, and 0.53 kGy, on frankfurters dipped in 0, 1, 5 or 10% CA solution, respectively. CA, although an antioxidant synergist, did not increase antioxidant activity (AA) on frankfurter surfaces as determined by the ferric reducing antioxidant power (FRAP) assay. Lipid oxidation, as determined by the Thiobarbituric acid reactive substances (TBARS) assay, was not affected by CA or ionizing radiation. Color of frankfurters, determined by Hunter L, a, b, indicated that ionizing radiation induced a small, but visually imperceptible, loss of redness (a-value). Frankfurter firmness, as measured by maximum shear force, was not affected by ionizing radiation or CA. CA enhanced the lethality of ionizing radiation without negatively impacting frankfurter color, lipid oxidation, firmness, or antioxidant activity.

Combination of Hot-Water Surface Pasteurization of Whole Fruit and Low-Dose Gamma Irradiation of Fresh-Cut Cantaloupe

Improvements in methods for disinfecting fresh-cut cantaloupe could reduce spoilage losses and reduce the risk of foodborne illness from human pathogen contamination. The objective of this study was to investigate the feasibility of using hot-water treatment in combination with low-dose irradiation to reduce native microbial populations while maintaining the quality of fresh-cut cantaloupe. Whole cantaloupes were washed in tap water at 20 or 76 degrees C for 3 min. Fresh-cut cantaloupe cubes, prepared from the washed fruit, were then packaged in clamshell containers, and half the samples were exposed to 0.5 kGy of gamma radiation. Native microflora populations and sensory qualities were evaluated during the subsequent 7 days of storage at 4 degrees C. The hot-water surface pasteurization reduced the microflora population by 3.3 log on the surface of whole fruits, resulting in a lower microbial load on the fresh-cut cubes compared with cubes cut from fruit treated with cold water. Irradiation of cubes prepared from untreated fruit to an absorbed dose of 0.5 kGy achieved a low microbial load similar to that of cubes prepared from hot-water-treated fruit. The combination of the two treatments was able to further reduce the microflora population. During storage, the headspace atmosphere of the packages was not significantly influenced by any of the treatments. Color, titratable acidity, pH, ascorbic acid, firmness, and drip loss were not consistently affected by treatment with irradiation, hot water, or the combination of the two. Cubes prepared from hot-water-treated whole fruit had slightly lower soluble solids content. The combination of hot-water pasteurization of whole cantaloupe and low-dose irradiation of packaged fresh-cut melon can reduce the population of native microflora while maintaining the quality of this product.

Ionizing Radiation Sensitivity of Listeria monocytogenes ATCC 49594 and Listeria innocua ATCC 51742 Inoculated on Endive (Cichorium endiva)

Ionizing radiation inactivates the pathogenic bacteria that can contaminate leafy green vegetables. Leaf pieces and leaf homogenate of endive (Cichorium endiva) were inoculated with the pathogen Listeria monocytogenes (ATCC 49594) or Listeria innocua (ATCC 51742), a nonpathogenic surrogate bacterium. The radiation sensitivity of the two strains was similar, although L. innocua was more sensitive to the type of suspending leaf preparation. During refrigerated storage after irradiation, the population of L. monocytogenes on inoculated endive was briefly suppressed by 0.42 kilogray (kGy), a dose calibrated to achieve a 99% reduction. However, the pathogen regrew after 5 days until it exceeded the bacterial levels on the control after 19 days in storage. Treatment with 0.84 kGy, equivalent to a 99.99% reduction, suppressed L. monocytogenes throughout refrigerated storage. Doses up to 1.0 kGy had no significant effect on the color of endive leaf material, regardless of whether taken from the leaf edge or the leaf midrib. The texture of leaf edge material was unaffected by doses up to 1.0 kGy, whereas the maximum dose tolerated by leaf midrib material was 0.8 kGy. These results show that endive leaves may be treated with doses sufficient to achieve at least a 99.99% reduction of L. monocytogenes with little or no impact on the products texture or color.

Effect of pH on the survival of Listeria innocua in calcium ascorbate solutions and on quality of fresh-cut apples

Fresh-cut apple slices were dipped in calcium ascorbate (CaA) solution at pH values ranging from 2.5 to 7.0 to inhibit browning. After treatment, the cut apples were stored at 4 and 10 degrees C for up to 21 days. Color and texture of the apples were determined on days 1, 14, and 21. In a separate experiement, the pH of CaA solution was adjusted with acetic acid to six different pH levels, and the solution was inoculated with Listeria innocua. The survival of the bacterium and the stability of CaA were determined at 0, 20, and 96 h. The cut apples maintained fresh quality when the pH of the CaA solution was above 4.5, but slight discoloration of apple slices dipped in pH 4.5 solution was observed after 14 days at 10 degrees C. At pH 5.0, the CaA dip maintained the quality of the apples at both temperatures for at least 21 days. The L. innocua population was reduced by 4 to 5 log CFU/ml at pH 4.5 after 96 h. At pH 5, the bacterial population in the CaA solution was reduced by approximately 2 log CFU/ml during the same period. The CaA solution was stable at pH 5 for at least 96 h. Reduction of the pH to between 4.5 and 5.0 might reduce the risk of foodborne illness due to consumption of fresh-cut apples treated with a CaA solution contaminated with Listeria.

Inactivation of Listeria innocua, Salmonella Typhimurium, and Escherichia coli O157:H7 on surface and stem scar areas of tomatoes using in-package ozonation.

A novel in-package ozonation device was evaluated for its efficacy in inactivating three microorganisms (viz., Listeria innocua, attenuated Salmonella Typhimurium, and Escherichia coli O157:H7) on tomatoes and for its effect on fruit quality. The device produced ozone inside sealed film bags, reaching a concentration of 1,000 ppm within 1 min of activation. The three bacterial cultures were inoculated onto either the smooth surface or the stem scar areas of the tomatoes, which were then sealed in plastic film bags and subjected to in-package ozonation. L. innocua on tomatoes was reduced to nondetectable levels within 40 s of treatment on the tomato surface, with inactivation of ca. 4 log CFU per fruit on the stem scar area. An increase in treatment time did not result in a proportional increase in bacterial reduction. For E. coli O157:H7 and Salmonella, there was little difference (<1 log) in the effectiveness of the system when comparing surface and scar-inoculated bacteria. Both bacteria were typically reduced by 2 to 3 log CFU per fruit after 2- to 3-min treatments. No negative effects on fruit color or texture were observed during a 22-day posttreatment storage study of ozone-treated tomatoes. These results suggest that the three bacteria responded differently to ozonation and that in-package ozonation may provide an alternative to chemical sanitizers commonly used by the industry.

Changes in quality, liking, and purchase intent of irradiated fresh-cut spinach during storage.

The use of ionizing radiation to enhance microbial safety of fresh spinach at a maximum dose of 4 kGy has been approved by the U.S. Food and Drug Administration (FDA). However, whether spinach can tolerate those high doses of radiation is unclear. Therefore, this study was conducted to investigate the effects of irradiation and storage on quality, liking, and purchase intent of fresh-cut spinach. The oxygen radical absorbance capacity values and total phenolic content were not consistently affected by irradiation. However, the ascorbic acid content of irradiated sample decreased rapidly during storage, resulting in these samples being lower in ascorbic acid content than controls after 7 and 14 d of storage at 4 °C. Sensory evaluation by a 50-member panel revealed that purchase intent and ratings for liking of appearance, aroma, texture, flavor, and overall were not affected by irradiation at doses up to 2 kGy. Therefore, irradiation at doses up to 2 kGy may be used to enhance microbial safety without affecting consumer acceptance or overall antioxidant values of irradiated spinach.