Mansel W. Griffiths

Combining nonthermal technologies to control foodborne microorganisms

Novel nonthermal processes, such as high hydrostatic pressure (HHP), pulsed electric fields (PEFs), ionizing radiation and ultrasonication, are able to inactivate microorganisms at ambient or sublethal temperatures. Many of these processes require very high treatment intensities, however, to achieve adequate microbial destruction in low-acid foods. Combining nonthermal processes with conventional preservation methods enhances their antimicrobial effect so that lower process intensities can be used. Combining two or more nonthermal processes can also enhance microbial inactivation and allow the use of lower individual treatment intensities. For conventional preservation treatments, optimal microbial control is achieved through the hurdle concept, with synergistic effects resulting from different components of the microbial cell being targeted simultaneously. The mechanisms of inactivation by nonthermal processes are still unclear; thus, the bases of synergistic combinations remain speculative. This paper reviews literature on the antimicrobial efficiencies of nonthermal processes combined with conventional and novel nonthermal technologies. Where possible, the proposed mechanisms of synergy is mentioned.

Survival of bifidobacteria in yogurt and simulated gastric juice following immobilization in gellan-xanthan beads.

A novel acid-stable bead made of gellan gum and xanthan gum was used to immobilize Bifidobacteria. The beads (0.75% gellan and 1% xanthan gum) had an average diameter of 3 mm and did not shrink in 25% lactic acid solution, pH 1.5, or 20% acetic acid solution, pH 1.5, after storage at 4 degrees C for 4 weeks. Bifidobacterium infantis ATCC 15697, the most acid-tolerant strain tested, was immobilized in gellan-xanthan beads and its survival in peptone water, pH 4, pasteurized yogurt, and simulated gastric juice was monitored. In peptone water, pH 4, the reduction in cell count of immobilized cells of B. infantis ATCC 15697 was not significantly different from that obtained with free cells during 6 weeks of storage at 4 degrees C. However, counts of immobilized cells of B. infantis ATCC 15697 remained significantly higher than free cells (P < 0.0001) when both were exposed to simulated gastric juices at pH 2.5, 2.0 and 1.5. At pH 2.5, the viable count of free cells dropped from 1.23 x 10(9) CFU/ml to an undetectable level (< 10 CFU/ml) in 30 min, while the viable count of immobilized cells decreased by only 0.67 log cycle in the same time period. Immobilized cells also survived significantly better than free cells (P <0.05) in pasteurized yogurt after refrigerated storage for 5 weeks.

Antimicrobial drug residues in milk and meat: causes, concerns, prevalence, regulations, tests, and test performance.

This paper presents a historical review of antimicrobial use in food animals, the causes of residues in meat and milk, the types of residues found, their regulation in Canada, tests used for their detection, and test performance parameters, with an emphasis on immunoassay techniques. The development of residue detection methods began shortly after the introduction of antimicrobials to food animal production in the late 1940s. From initial technical concerns expressed by the dairy industry to the present public health and international trade implications, there has been an ongoing need for reliable, sensitive, and economical methods for the detection of antimicrobial residues in food animal products such as milk and meat. Initially there were microbial growth inhibition tests, followed by more sensitive and specific methods based on receptor binding, immunochemical, and chromatographic principle. An understanding of basic test performance parameters and their implications is essential when choosing an analytical strategy for residue testing. While each test format has its own attributes, none test will meet all the required analytical needs. Therefore the use of a tiered or integrated system employing assays designated for screening and confirmation is necessary to ensure that foods containing violative residues are not introduced into the food chain.

Probiotics affect virulence-related gene expression in Escherichia coli O157:H7.

ABSTRACT The attachment of enterohemorrhagic Escherichia coli O157:H7 (EHEC O157) to host intestinal epithelial cells is essential for the development of hemorrhagic colitis and hemolytic-uremic syndrome in humans. Genes involved in attachment are carried within a pathogenicity island named the locus of enterocyte effacement (LEE), known to be directly activated by quorum sensing (QS). In the present study, we investigated autoinducer-2 (AI-2) production and the expression of several virulence-related genes in EHEC O157 grown in the absence and presence of a Lactobacillus acidophilus-secreted molecule(s). Transcription of important EHEC O157 virulence-related genes was studied by constructing promoter-reporter fusions and reverse transcriptase PCR. Shiga toxin (Stx) production was assayed by an enzyme immunoassay. When EHEC O157 was grown in the presence of chromatographically selected fractions of L. acidophilus La-5 cell-free spent medium, we observed a significant reduction of both extracellular AI-2 concentration and the expression of important virulence-related genes, although no significant difference in Stx production was observed. We show here that L. acidophilus La-5 secretes a molecule(s) that either acts as a QS signal inhibitor or directly interacts with bacterial transcriptional regulators, controlling the transcription of EHEC O157 genes involved in colonization.

Postadaptational Resistance to Benzalkonium Chloride and Subsequent Physicochemical Modifications of Listeria monocytogenes

ABSTRACT Many studies have demonstrated that bacteria, including Listeria monocytogenes, are capable of adapting to disinfectants used in industrial settings after prolonged exposure to sublethal concentrations. However, the consequent alterations of the cell surface due to sanitizer adaptation of this pathogen are not fully understood. Two resistant and four sensitive L. monocytogenes strains from different sources were progressively subcultured with increasing sublethal concentrations of a surfactant, benzalkonium chloride (BC). To evaluate the effects of acquired tolerance to BC, parent and adapted strains were compared by using several morphological and physiological tests. Sensitive strains showed at least a fivefold increase in the MIC, while the MIC doubled for resistant strains after the adaptation period. The hydrophobicities of cells of parent and adapted strains were similar. Serological testing indicated that antigen types 1 and 4 were both present on the cell surface of adapted cells. The data suggest that efflux pumps are the major mechanism of adaptation in sensitive strains and are less important in originally resistant isolates. A different, unknown mechanism was responsible for the original tolerance of resistant isolates. In an originally resistant strain, there was a slight shift in the fatty acid profile after adaptation, whereas sensitive strains had similar profiles. Electron micrographs revealed morphological differences after adaptation. The changes in cell surface antigens, efflux pump utilization, and fatty acid profiles suggest that different mechanisms are used by resistant and sensitive strains for adaptation to BC.

Rapid detection of Escherichia coli O157:H7 with multiplex real-time PCR assays.

ABSTRACT A SYBR Green LightCycler PCR assay using a single primer pair allowed simultaneous detection of stx1 and/or stx2 of Escherichia coli O157:H7. A distinct sequence of the Shiga-like toxin genes was amplified to yield products of 227 and/or 224 bp, respectively. The two products were distinguished by melting point curve analysis.

Inactivation of Salmonella Typhimurium in orange juice containing antimicrobial agents by pulsed electric field.

Combinations of different hurdles, including moderately high temperatures (<60 degrees C), antimicrobial compounds, and pulsed electric field (PEF) treatment, to reduce Salmonella in pasteurized and freshly squeezed orange juices (with and without pulp) were explored. Populations of Salmonella Typhimurium were found to decrease with an increase in pulse number and treatment temperature. At a field strength of 90 kV/cm, a pulse number of 20, and a temperature of 45 degrees C, PEF treatment did not have a notable effect on cell viability or injury. At and above 46 degrees C, however, cell death and injury were greatly increased. Salmonella numbers were reduced by 5.9 log cycles in freshly squeezed orange juice (without pulp) treated at 90 kV/cm, 50 pulses, and 55 degrees C. When PEF treatment was carried out in the presence of nisin (100 U/ml of orange juice), lysozyme (2,400 U/ml), or a mixture of nisin (27.5 U/ml) and lysozyme (690 U/ml), cell viability loss was increased by an additional 0.04 to 2.75 log cycles. The combination of nisin and lysozyme had a more pronounced bactericidal effect than did either nisin or lysozyme alone. An additional Salmonella count reduction of at least 1.37 log cycles was achieved when the two antimicrobial agents were used in combination. No significant difference (P > 0.05) in cell death was attained by lowering the pH value; only cell injury increased. Inactivation by PEF was significantly more extensive (P < 0.05) in pasteurized orange juice than in freshly squeezed orange juice under the same treatment conditions. This increase might be due to the effect of the chemical composition of the juices.

Direct Quantitation and Detection of Salmonellae in Biological Samples without Enrichment, Using Two-Step Filtration and Real-Time PCR

ABSTRACT A new two-step filtration protocol followed by a real-time PCR assay based on SYBR green I detection was developed to directly quantitate salmonellae in two types of biological samples: i.e., chicken rinse and spent irrigation water. Four prefiltration filters, one type of final filter, and six protocols for recovery of salmonellae from the final filter were evaluated to identify an effective filtration protocol. This method was then combined with a real-time PCR assay based on detection of the invA gene. The best results were obtained by subsequent filtration of 100 ml of chicken rinse or 100 ml of spent irrigation water through filters with pore diameters of >40 μm to remove large particles and of 0.22 μm to recover the Salmonella cells. After this, the Salmonella cells were removed from the filter by vortexing in 1 ml of physiological saline, and this sample was then subjected to real-time quantitative PCR. The whole procedure could be completed within 3 h from sampling to quantitation, and cell numbers as low as 7.5 × 102 CFU per 100-ml sample could be quantified. Below this limit, qualitative detection of concentrations as low as 2.2 CFU/100 ml sample was possible on occasion. This study has contributed to the development of a simple, rapid, and reliable method for quantitation of salmonellae in food without the need for sample enrichment or DNA extraction.

Development and Optimization of a Novel Immunomagnetic Separation- Bacteriophage Assay for Detection of Salmonella enterica Serovar Enteritidis in Broth

ABSTRACT Salmonella is the second-leading cause of food-borne illness in most developed countries, causing diarrhea, cramps, vomiting, and often fever. Many rapid methods are available for detection of Salmonella in foods, but these methods are often insensitive or expensive or require a high degree of technical ability to perform. In this paper we describe development and characterization of a novel assay that utilizes the normal infection cycle of bacteriophage SJ2 for detection of Salmonella enterica serovar Enteritidis in broth. The assay consists of four main stages: (i) capture and concentration of target cells by using immunomagnetic separation (IMS); (ii) infection of the target bacterium with phage; (iii) amplification and recovery of progeny phage; and (iv) assay of progeny phage on the basis of their effect on a healthy population of host cells (signal-amplifying cells). The end point of the assay can be determined by using either fluorescence or optical density measurements. The detection limit of the assay in broth is less than 104 CFU/ml, and the assay can be performed in 4 to 5 h. The results of this study demonstrate that the IMS-bacteriophage assay is a rapid, simple, and sensitive technique for detection of Salmonella serovar Enteritidis in broth cultures which can be applied to preenriched food samples.

Biocontrol of Listeria monocytogenes and Escherichia coli O157:H7 in meat by using phages immobilized on modified cellulose membranes.

ABSTRACT The ability of phages to specifically interact with and lyse their host bacteria makes them ideal antibacterial agents. The range of applications of bacteriophage can be extended by their immobilization on inert surfaces. A novel method for the oriented immobilization of bacteriophage has been developed. The method was based on charge differences between the bacteriophage head, which exhibits an overall net negative charge, and the tail fibers, which possess an overall net positive charge. Hence, the head would be more likely to attach to positively charged surfaces, leaving the tails free to capture and lyse bacteria. Cellulose membranes modified so that they had a positive surface charge were used as the support for phage immobilization. It was established that the number of infective phages immobilized on the positively charged cellulose membranes was significantly higher than that on unmodified membranes. Cocktails of phages active against Listeria or Escherichia coli immobilized on these membranes were shown to effectively control the growth of L. monocytogenes and E. coli O157:H7 in ready-to-eat and raw meat, respectively, under different storage temperatures and packaging conditions. The phage storage stability was investigated to further extend their industrial applications. It was shown that lyophilization can be used as a phage-drying method to maintain their infectivity on the newly developed bioactive materials. In conclusion, utilizing the charge difference between phage heads and tails provided a simple technique for oriented immobilization applicable to a wide range of phages and allowed the retention of infectivity.