Márcia Helena Rissato Zamariolli Damianovic

Nitrogen and carbon removal from synthetic wastewater in a vertical structured-bed reactor under intermittent aeration

The removal of nitrogen and organic matter using a single reactor has been a common focus of investigation, and reactors operated in batch mode and under intermittent aeration have attracted special attention. This study aimed to evaluate the application of a new reactor configuration consisting of a fixed-bed reactor that was operated under conditions of continuous feeding and intermittent aeration. The reactor was built using acrylic, with a working volume of 6.1L. The fixed bed used for biomass support was composed of polyurethane foam cylinders vertically oriented inside the reaction zone. The reactor was operated under intermittent aeration (2h aerated and 1h non-aerated) and a recirculation ratio Q(r)/Q=5. Three different operating conditions (Phase I, Phase II, and Phase III) corresponding to hydraulic retention times (HRT) of 12h, 8h, and 10h, respectively, were tested. In Phase I, the system achieved total nitrogen (TN) and chemical oxygen demand (COD) removal efficiencies of 82% and 89%, respectively. At HRTs of 8 h and 10 h, the reactor was unstable with respect to TN removal, and the average resultant removal efficiencies were 49% and 45%, respectively. However, COD removal efficiencies remained high with mean values of 85% and 88% for Phases II and III, respectively. Based on these results, it can be concluded that this new reactor configuration constitutes an alternative method for effective removal of organic matter and nitrogen from wastewater.

Pentachlorophenol (PCP) dechlorination in horizontal-flow anaerobic immobilized biomass (HAIB) reactors

This study verifies the potential applicability of horizontal-flow anaerobic immobilized biomass (HAIB) reactors to pentachlorophenol (PCP) dechlorination. Two bench-scale HAIB reactors (R1 and R2) were filled with cubic polyurethane foam matrices containing immobilized anaerobic sludge. The reactors were then continuously fed with synthetic wastewater consisting of PCP, glucose, acetic acid, and formic acid as co-substrates for PCP anaerobic degradation. Before being immobilized in polyurethane foam matrices, the biomass was exposed to wastewater containing PCP in reactors fed at a semi-continuous rate of 2.0 microg PCP g(-1) VS. The applied PCP loading rate was increased from 0.05 to 2.59 mg PCP l(-1)day(-1) for R1, and from 0.06 to 4.15 mg PCP l(-1)day(-1) for R2. The organic loading rates (OLR) were 1.1 and 1.7 kg COD m(-3)day(-1) at hydraulic retention times (HRT) of 24h for R1 and 18 h for R2. Under such conditions, chemical oxygen demand (COD) removal efficiencies of up to 98% were achieved in the HAIB reactors. Both reactors exhibited the ability to remove 97% of the loaded PCP. Dichlorophenol (DCP) was the primary chlorophenol detected in the effluent. The adsorption of PCP and metabolites formed during PCP degradation in the packed bed was negligible for PCP removal efficiency.

Removal of COD and nitrogen from animal food plant wastewater in an intermittently-aerated structured-bed reactor.

This study evaluated the performance of a continuous flow structured-bed reactor in the simultaneous removal of total nitrogen (TN) and chemical oxygen demand (COD) in the effluent from an animal food plant. The reactor had an intermittent aeration system; hydraulic retention time (HRT) of one day; temperature of 30 °C; and recirculation ratio of five times the flow. An experimental central composite rotational delineation (CCRD) type design was used to define the aeration conditions and nitrogen load (factors) to be studied. Response surface methodology was used to analyse the influence of the factors above the results, the removal of TN and COD. It was observed that the aeration factor showed the greatest significance for the results and that the affluent TKN concentration did not have a significant effect, at a 95% level of confidence, on COD removal. Throughout the experiment, the COD/N ratio remained between 3.2 and 3.8. The best results for COD and TN removal, 80% and 88%, respectively, were obtained with 158 min of aeration on a cycle of 180 min and 255 mg L(-1) of Total Kjeldahl Nitrogen (TKN) in the substrate.

Sulfidogenesis interference on methane production from carbohydrate-rich wastewater.

Two anaerobic fixed-structured bed reactors were fed with synthetic wastewater simulating the soluble fraction of sugarcane vinasse to evaluate the interference of sulfidogenesis on methanogenesis. The reactors running in parallel were subjected to the same operating conditions. The influent organic matter concentration (in term of chemical oxygen demand (COD)) remained close to 4,000 mgCOD L(-1) and the hydraulic retention time was 24 hours. One reactor, the methanogenic (control reactor), received sulfate only to provide the sulfur required as a nutrient to the methanogenic biomass. The other one, the sulfidogenic/methanogenic reactor (SMR), received sulfate concentration corresponding to COD/sulfate ratios of 4, 5 and 3. In the last phase, the COD removal efficiencies were higher than 96% in both reactors and the SMR achieved 97% of sulfate removal efficiency (COD/sulfate ratio of 3 and influent sulfate concentration close to 1,300 mgSO4(2-) L(-1)). Both reactors also had similar methane yields in this phase, close to 350 mLCH4 gCODremoved(-1) at standard temperature and pressure. These results indicated no significant inhibition of methanogenic activity under the sulfidogenic conditions assessed.

Removing organic matter from sulfate-rich wastewater via sulfidogenic and methanogenic pathways.

The simultaneous organic matter removal and sulfate reduction in synthetic sulfate-rich wastewater was evaluated for various chemical oxygen demand (COD)/sulfate ratios applied in a horizontal-flow anaerobic immobilized sludge (HAIS) reactor. At higher COD/sulfate ratios (12.5 and 7.5), the removal of organic matter was stable, likely due to methanogenesis. A combination of sulfate reduction and methanogenesis was clearly established at COD/sulfate ratios of 3.0 and 1.9. At a COD/sulfate ratio of 1.0, the organic matter removal was likely influenced by methanogenesis inhibition. The quantity of sulfate removed at a COD/sulfate ratio of 1.0 was identical to that obtained at a ratio of 1.9, indicating a lack of available electron donors for sulfidogenesis. The sulfate reduction and organic matter removal were not maximized at the same COD/sulfate ratio; therefore, competitive inhibition must be the predominant mechanism in establishing an electron flow.

Gas chromatographic methods for monitoring of wastewater chlorophenol degradation in anaerobic reactors

Wastewater samples from an anaerobic reactor were extracted with hexane and derivatized with diazomethane (method 1) and with acetic anidride (method 2). Gas chromatography with electron-capture detection (ECD) was employed for separating the parent compound and intermediates trichlorophenols (TCP) and dichlorophenols (DCP) which originated from the penta chlorophenol (PCP) degradation process. The relations between concentrations of PCP, TCP and DCP areas were linear in the range of concentrations of 0.2 to 8 mg/L and 0.025 mg/L to 5 mg/L for methods 1 and 2, respectively. The repeatability of the extraction methods was satisfactory, with variation coefficients lower than 11%. For method 1, at the fortification level of 0.2 mg/L, recovery of PCP, TCP, and DCP was 112%, 74% and 45%, respectively. For method 2, the corresponding recovery values at the fortification level of 0.1 mg/L were 91%, 93% and 103%, respectively. Storage of the frozen samples did not alter their PCP determination properties. The chromatographic methods adapted for chlorophenol determination in wastewater were suitable with relatively simple manipulation techniques. The obtained results were reproducible and allowed identification of intermediates formed during the PCP degradation process.

DEVELOPMENT OF HPLC METHOD FOR THE ANALYSIS OF CHLOROPHENOLS IN SAMPLES FROM ANAEROBIC REACTORS FOR WASTEWATER TREATMENT

This article describes an HPLC method for routine samples analysis of laboratory scale anaerobic immobilized sludge reactors used for degradation of pentachlorophenol (PCP) in synthetic wastewater. The method was developed to quantify pentachlorophenol and six chlorophenol isomers produced during the degradation of pentachlorophenol by anaerobic bacteria. The validated method was used for anaerobic reactor samples and was able to quantify the chlorophenol intermediates produced.

Performance of a horizontal-flow anaerobic immobilized biomass (HAIB) reactor and dynamics of the microbial community during degradation of pentachlorophenol (PCP).

The anaerobic biological treatment of pentachlorophenol (PCP) and methanol as the main carbon source was investigated in a horizontal-flow anaerobic immobilized biomass (HAIB) reactor at 30+/-1 degrees C, during a 220-day trial period. The reactor biomass was developed as an attached biofilm on polyurethane foam particles, with 24h of hydraulic retention time. The PCP concentrations, which ranged from 2.0 to 13.0 mg/L, were controlled by adding synthetic substrate. The HAIB reactor reduced 97% of COD and removed 99% of PCP. The microbial biofilm communities of the HAIB reactor amended with PCP, without previous acclimatization, were characterized by polymerase chain reaction (PCR) and amplified ribosomal DNA restriction analysis (ARDRA) with specific Archaea oligonucleotide primers. The ARDRA technique provided an adequate analysis of the community, revealing the profile of the selected population along the reactor. The biomass activities in the HAIB reactor at the end of the experiments indicated the development of PCP degraders and the maintenance of the population of methanogenic Archaea, ensuring the high efficiency of the system treating PCP with added methanol as the cosubstrate. The use of the simplified ARDRA method enabled us to monitor the microbial population with the addition of high concentrations of toxic compounds and highlighting a selection of microorganisms in the biofilm.

Assessment of the ability of sludge to degrade PCP under anaerobic conditions

Abstract - The capacity of sludge from different sources to degrade pentachlorophenol (PCP) was evaluated. Three 2.5 liter reactors (R 1 , R 2 , and R 3 ) were inoculated with different anaerobic sludges, semi continuously fed and maintained in orbital motion at 30±1°C. R 1 was inoculated with aerobic sludge and river sediment collected downstream from a pulp and paper plant. 2 received sludge from an anaerobic reactor treatingR effluents from a paper recycling plant and R 3 received anaerobic sludge from a biodigestor treating industrial and domestic effluents. The sludges were first acclimatized to a culture medium generally recommended for organochloride anaerobic degradation studies. The reactors were then subjected to increasing concentrations of PCP from 0.05 to 10.0 mg.l -1 . PCP degradation and metabolite formation were monitored using gas chromatography, and the effects of PCP on the anaerobic process were verified by monitoring pH, volatile fatty acids, alkalinity, total suspended solids, and chemical oxygen demand. It was found that PCP did not affect reactor performance. All the sludges displayed the best PCP degradation capacity at a concentration of 0.2 mg.l

Poultry slaughterhouse wastewater treatment plant for high quality effluent

This paper assesses a wastewater treatment plant (WWTP) regarding the technology used, as well as organic matter and nutrient removal efficiencies aiming to optimize the treatment processes involved and wastewater reclamation. The WWTP consists of a dissolved air flotation (DAF) system, an upflow anaerobic sludge blanket (UASB) reactor, an aerated-facultative pond (AFP) and a chemical-DAF system. The removal efficiencies of chemical oxygen demand (COD) (97.9 ± 1.0%), biochemical oxygen demand (BOD) (98.6 ± 1.0%) and oil and grease (O&G) (91.1 ± 5.2%) at the WWTP, the nitrogen concentration of 17 ± 11 mg N-NH3 and phosphorus concentration of 1.34 ± 0.93 mg PO4(-3)/L in the final effluent indicate that the processes used are suitable to comply with discharge standards in water bodies. Nitrification and denitrification tests conducted using biomass collected at three AFP points indicated that nitrification and denitrification could take place in the pond.