Margit Dall Aaslyng

Cooking loss and juiciness of pork in relation to raw meat quality and cooking procedure

The study comprised two experiments with the aim to investigate the influence of raw meat quality and cooking procedure on cooking loss and juiciness of pork. The first experiment determined the cooking loss at 60, 70 and 80 °C centre temperature of 10 raw meat qualities (defined according to ultimate pH, drip loss, breed and rearing conditions) when cooked as steaks on a pan or as a roast in oven at a oven temperature of 90 or 190 °C. The differences in cooking loss between the raw meat qualities and the cooking procedures did decrease as the centre temperature increased and were almost negligble at 80 °C. Low water holding capacity (WHC) and low pH resulted in high cooking loss while no difference in cooking loss was observed between meat having medium or high WHC and pH. In the second experiment four raw meat qualities (standard, Duroc, low pH and heavy carcass weight) chosen from the first experiment to ensure a wide variation in cooking loss, were cooked in oven at 90 or 190 °C oven temperature. Juiciness was assessed three times during the chewing process. The results suggested that juiciness experienced initially in the chewing process depended only on the water content of the meat, whereas juiciness experienced later in the chewing process was determined by a combination of the water and intramuscular fat contents and the saliva production during chewing.

The effect of stress during lairage and stunning on muscle metabolism and drip loss in Danish pork

The effect on meat quality of a low stress handling system (LSS) compared with a traditional handling system (TS) was investigated in Duroc×(Landrace×Yorkshire; n=117) and (Hampshire×Duroc)×(Landrace×Yorkshire) pigs (n=110) under commercial conditions. In the low-stress handling system the pigs were kept in groups of 15 during lairage and movement up to the stunner. Before the stunner the groups were divided into three groups of five pigs for the CO(2)-stunning in a specially designed set-up. The pH and temperature were determined in m. longissimus dorsi (LD) and m. biceps femoris (BF) at various times post mortem. Immediately after exsanguination a biopsy was taken from the LD and analysed for the concentration of glycogen, lactate and creatine phosphate. The day after slaughter the pH was determined in the LD, BF, m. semimembranosus (SM) and m. semispinalis capitis (SC). The temperature was determined in the LD and BF, the internal reflectance was determined in the LD, SM and BF, the colour was determined in LD, the drip loss was determined in LD and BF, and the amount of blood splashing/bruising was evaluated in LD. There was a tendency for a higher concentration of creatine phosphate in the LSS-group (P=0.06). The pH in both the LD and BF on the day of slaughter decreased more slowly from 5 min post mortem to 40 min post mortem in the LSS-group than in the TS-group (P<0.001). From 40 min to 6 h post mortem the rate of the pH decline was similar in the two groups producing the lowest pH-level in the TS group. The day after slaughter the pH was similar in the two groups in the LD and SC, whereas in the BF and SM it was lower in the LSS-group than in the TS-group. The drip loss was lower in the LSS-group in both LD (P<0.01) and BF (P<0.05) whereas the internal reflectance was only different in LD with the lowest value in the LSS-group (P<0.001). The lightness (L*) was higher in the LSS-group (P<0.05). There was no effect of stunning system on the amount of blood splashing/bruishing in the LD. The study showed that by using a low stress stunning system it is possible to decrease drip loss, possibly by increasing the concentration of creatine phosphate and thereby delaying the acceleration of pH fall in muscles after death.

Elucidation of the relationship between cooking temperature, water distribution and sensory attributes of pork – a combined NMR and sensory study

Low-field NMR T(2) relaxation was measured continuously during cooking of pork samples (m. longissimus dorsi) to a final temperature of 75 °C. Simultaneously the remaining muscle was cooked in an oven to a core temperature of either 62 or 75 °C and subsequently evaluated by a sensory panel. Highly significant effects of final cooking temperature on the sensory attributes juiciness (initial and final), hardness, tenderness, crumbliness and chewing time were found. Juiciness and tenderness decreased with increasing temperature, while hardness, crumbliness and chewing time increased with increasing temperature. Distributed T(2) relaxation data revealed marked effects of temperature (62 vs. 75 °C) on the water distribution within the meat. Partial least squares (PLS) regressions were used to examine a potential prediction of sensory attributes from the distributed T(2) relaxation data, and high correlations were obtained. Moreover, loadings from the PLS regressions were analysed to evaluate the alterations in the water distribution as a function of temperature that contribute to changes in juiciness. This analysis revealed that the reduction in juiciness at 75 °C can be ascribed to changes in the size of the pores confining the myofibrillar water together with an expulsion of water.

Content of heterocyclic amines and polycyclic aromatic hydrocarbons in pork, beef and chicken barbecued at home by Danish consumers.

It is a well-known fact that, when meat is barbecued, several harmful components, including heterocyclic amines (HCA) and polycyclic aromatic hydrocarbons (PAH), may be formed. The aim of this study was to determine the HCA and PAH content in meat (pork, chicken and beef) when barbecued at home by Danish consumers according to their normal practice. With regard to HCA, beef contained the highest concentrations of 9H-pyrido[3,4-b]indole (norharman) and 2-methyl-β-carboline (harman), while chicken contained more 2-amino-1-methyl-6-phenylimidazo[4,5-b]pyridine (PhIP) than pork and beef. The analysis of PAH showed a markedly higher concentration of PAH in beef compared with pork and chicken. In general, a correlation between the HCA content and the surface colour of the meat was found, the darker the colour the higher the HCA concentrations.

Low stress pre-slaughter handling: effect of lairage time on the meat quality of pork.

Abstract The effect of lairage time on meat quality was investigated when crossbred pigs were subjected to low stress pre-slaughter handling, where pigs were treated in mixed groups of 15 from the farm to group CO 2 stunning, and where electric goads were not used at any time. Two experiments were carried out, one in spring ( n =270) using very standardised conditions and one producer, and one in summer ( n =630) using a representative randomly chosen sample of producers. In the first experiment three lairage times were used, less than 30 min (average 26 min), 90 min (average 83 min) and more than 150 min (average 170 min) and no showering. The pH and temperature were measured in the m. longissimus dorsi at various times post mortem, and colour ( L * , a * , b * ), internal reflectance and drip loss the day after slaughter. Sensory evaluation was carried out on 16 randomly chosen samples from the shortest and longest lairage time groups. Drip loss, pH ultimate and internal reflectance were also measured in the m. biceps femoris and pH ultimate and internal reflectance in the m. semimembranosus. Finally, pH ultimate was measured in the m. semispinalis capitis. In the second experiment only two lairage times were used, less than 30 min (average 17 min) and more than 130 min (average 150 min) and with intermittent showering and only a subset of the meat quality measurements were made. Lairage time had no effect on any of the meat quality parameters measured in experiment 1. In experiment 2 the shortest lairage time led to a higher temperature in the m. longissimus dorsi at 2 min post mortem, a higher drip loss in the m. biceps femoris and higher internal reflectance values in both muscles the day after slaughter. The differences were, however, very small and may have been an effect of showering.

Comparison of glucose, glucose 6-phosphate, ribose, and mannose as flavour precursors in pork; the effect of monosaccharide addition on flavour generation.

The effect of glucose, glucose 6-phosphate, mannose and ribose on the generation of aroma volatiles in pork was investigated. The monosaccharides were added individually to minced pork prior to heat treatment (160°C for 10min) in the following concentrations: glucose (27.5μmol/g), ribose (1.2μmol/g), mannose (8.3μmol/g) and glucose 6-phosphate (0.5μmol/g). The natural concentrations of the monosaccharides in the pork used were found to be 4.0μmol/g for glucose, 0.1μmol/g for ribose, 0.3μmol/g for mannose and 2.6μmol/g for glucose 6-phosphate. The major aroma compounds identified in the headspace of the heated samples were pyrazines, aldehydes (Strecker and lipid-derived), ketones, and sulphides. Glucose generated the highest amounts of volatiles followed by glucose 6-phosphate. However, when related to the added concentration of glucose 6-phosphate, this phosphorylated monosaccharide showed the highest aroma generating potential. The addition of ribose did not increase the concentration of volatiles compared with pork without the added monosaccharide. The fates of ribose 5-phosphate and ribose in pork were studied over time. The concentrations of ribose and ribose 5-phosphate clearly decreased during 2h equilibration, which may be due to enzymatic activities. These precursors may, therefore, be less important pork flavour precursors than glucose and glucose 6-phosphate.

Significance of fat supplemented diets on pork quality - : Connections between specific fatty acids and sensory attributes of pork

The influence of two diets with different fatty acid compositions has been studied with regard to overall pork quality and significance of specific fatty acids on sensory attributes in fried chops and oven roasts. Twenty castrates and 20 females were in a balanced experimental set-up fed with a standard diet supplemented with α-tocopherol (200mg/kg feed) where the fat source was either 3% of palm oil or 3% rapeseed oil. After slaughter, despite differences in lipid composition and sensory attributes, no significant difference in overall meat quality parameters and flavour precursors was found. Comparison of the two diets showed that supplementation with rapeseed oil resulted in a significantly higher content of C18:3n-3 (polar lipid (PL), neutral lipid (NL)), C18:2n-6c (NL) and C20:2 (NL) in LD and C18:1n-9c, C18:2n-6c, C18:3n-3, C20:3n-3, C22:5n-3 in backfat, while supplementation with palm oil resulted in a higher content of C16:0 (NL), C16:1 (PL), C18:1n-9t (NL) in LD and C16:0, C17:0, C18:0, C16:1, C20:4n-6 in backfat. A positive and significant correlation between the contents of C18:2n-6c, C20:3n-6 in the PL fraction and the sensory attributes fried meat odour and sweet odour were found in fried pork chops from female pigs. Likewise, positive correlations were seen between the content of C18:1n-9c in the PL fraction and sensory attributes such as sourish odour, piggy odour and piggy flavour in whole oven roasts. These data substantiate the view that specific fatty acids in the PL fraction influences flavour attributes in pork.

Sensory characteristics of meat cooked for prolonged times at low temperature

The present study evaluated the sensory characteristics of low temperature long time (LTLT) treated Semitendinosus from pork and beef and Pectoralis profundus from chicken. Semitendinosus and Pectoralis profundus muscles were heat treated at 53 °C and 58 °C for T(c) + 6 h, T(c) + 17 h, and T(c) + 30 h (only Semitendinosus from pork and beef). T(c) was the time for the samples to equalize with the temperature in the water bath. Tenderness increased with increasing heating temperature and time in pork and beef, but not in chicken. Juiciness decreased with increasing heating temperature and time in all species, and cooking loss increased with increasing temperature. A done appearance was developed with increasing heating time at 58 °C in pork and beef, while in chicken the done appearance was only affected by temperature. Flavor attributes were less affected by the LTLT treatment for all species.

Flavour development in pork. influence of flavour precursor concentrations in longissimus dorsi from pigs with different raw meat qualities.

Flavour development and overall eating quality of pan-fried pork chops of longissimus dorsi from eight different raw meat qualities aged for 4 and 15 days were assessed by a trained sensory panel. The raw meat qualities were obtained through combinations of strategic feeding/fasting (control vs. low glycogen concentration), slaughter live-weight (84kg vs. 110kg), and gender (female vs. castrate). The flavour development was investigated for possible correlation with the concentrations of selected individual flavour precursors present in the raw meat: monosaccharides, IMP and degradation products, fatty acids, lactate and thiamine. Differences in precursor concentrations between the raw meat qualities were observed with feeding/fasting and ageing as the main factors with the largest influence of all experimental factors. However, the concentrations of the precursors could not explain the differences in sensory perception of the pan-fried pork chops. Overall, the differences were small.

Eating quality of pork from pure breeds and DLY studied by focus group research and meat quality analyses.

The eating quality of pan-fried pork chops from the pure breeds of Duroc, Hampshire, Black spotted and Wild pigs, and of the cross-breed of Duroc, Landrace and Yorkshire (DLY) was investigated by focus group research in combination with analyses of raw meat quality. The three focus groups, all consisting of young consumers, generally agreed in their description of the eating quality of the five breeds. The focus group methodology was found to be an informative method for the sensory evaluation of pork chops. Chemical and physical analyses of raw meat quality were performed in parallel with the focus group research, and this combination proved useful. The chemical and physical analyses generally supported the focus group evaluation, and differences between the breeds could be explained. Duroc was the breed with the overall best eating quality, while Hampshire had the lowest overall eating quality. DLY, Black spotted, and Wild pigs were intermediate, though not similar.