Miyoko Waki

Removal of phosphate, magnesium and calcium from swine wastewater through crystallization enhanced by aeration.

In order to confirm the possibility of removing P04-P, Mg and Ca from swine wastewater through artificial crystallization by aeration, laboratory and pilot scale experiments were carried out using actual swine wastewater. The pH of swine wastewater increased up to approximately 8.5 with continuous aeration, and a large part of the soluble PO4-P, Mg and Ca was crystallized. The ingredients of the crystals were estimated as MAP and HAP according to their mole ratio of NH4-N, PO4-P, Mg and Ca. The sedimentation speed of crystals in swine wastewater was about 3 m h(-1), and over 90% of them had settled after standing 1 h. A pilot scale reactor with the dual functions of crystallization by aeration and settling was operated continuously using actual swine wastewater, with aeration conditions of HRT 4.1 h and 26m3 airh(-1) m(-2) cross section (18m3 air h(-1) m(-3) volume). During 50 days of operation, pH at the aeration column held stable at 8.0, and 65% of PO4-P, 51% of Mg, and 34% of Ca were removed.

Effects of struvite formation and nitratation promotion on nitrogenous emissions such as NH3, N2O and NO during swine manure composting.

To reduce nitrogenous emissions from composting, two different countermeasures were applied simultaneously in swine manure composting. One was forming struvite by adding Mg and P at the start of composting, and the other was to promote nitratation (nitrite being oxidized nitrate) by adding nitrite-oxidizing bacteria after the thermophilic phase of composting. In the laboratory- and mid-scale composting experiments, 25-43% of NH3, 52-80% of N2O and 96-99% of NO emissions were reduced. From the nitrogen balance, it was revealed that the struvite formation reduced not only NH3, but also other nitrogenous emissions except N2O. The amount of total nitrogen losses was reduced by 60% by the two combined countermeasures, against 51% by the struvite formation alone. However, the nitratation promotion dissolved struvite crystals due to the pH decline, diminishing the effect of struvite as a slow-release fertilizer.

Continuous hydrogen production from glucose by using extreme thermophilic anaerobic microflora.

Continuous hydrogen production from glucose at 75 degrees C was examined at HRTs of 0.67, 1, 2, and 3 d by using extreme thermophilic microflora, which consisted of several subspecies of Caldanaerobacter subterraneus. The maximum hydrogen yield of 3.32 mol-H2/mol-glucose degraded was obtained at the highest HRT, 3 d. Both the maximum volumetric and specific rates of hydrogen production (1.22 L-H2/L/d and 4.15 L-H2/g-VSS/d, respectively) were obtained at the lowest HRT, 0.67 d. A 16S rDNA analysis showed that the community structure of the microflora did not change at any of the HRTs.

Rate determination and distribution of anammox activity in activated sludge treating swine wastewater.

This paper presents a quantitative investigation and analysis of anammox activity in sludge taken from biological swine wastewater treatment plants. An incubation experiment using a (15)N tracer technique showed anammox activity in sludge taken from 6 out of 13 plants with the rate ranging from 0.0036 micromol-N(2)/g-VSS/h to 3.1 micromol-N(2)/g-VSS/h, and in a biofilm with the highest activity at 25.8 micromol-N(2)/g-VSS/h. It is notable that 9 out of 11 sludges in which the pH was maintained between 6.6 and 8.1 retained anammox activity, while those with either a lower or higher pH did not. Moreover, anammox-positive sludge had a significantly higher concentration of NO(2)(-)-N plus NO(3)(-)-N than did anammox-negative sludge. A significant difference was not observed between anammox-positive and -negative sludge regarding BOD/NH(4)(+)-N in the influent, DO concentration in aeration tanks, and the concentrations of NH(4)(+)-N, free nitric acid, and free ammonia.

Effect of electron donors on anammox coupling with nitrate reduction for removing nitrogen from nitrate and ammonium

Anammox coupling with nitrate reduction under various electron donors was studied using sludge acclimatized to have anammox and denitrification activities. Due to a deficiency in electron donors for NO(3)(-) reduction, anammox activity in an inorganic medium containing NO(3)(-) and NH(4)(+) was lower than that in NO(2)(-) and NH(4)(+). Anammox could use NO(2)(-) competitively against denitrifiers under a very limited NO(2)(-) concentration, and additions of swine wastewater or acetate stimulated anammox activity in an inorganic medium containing NO(3)(-) and NH(4)(+) with no inhibition effects. However, a high concentration of swine wastewater caused an exponential increase in denitrification activity. The addition of hydrogen and iron stimulated anammox activity in an inorganic medium containing NO(3)(-) and NH(4)(+), but iron showed an inhibitory effect on anammox in a medium containing NO(2)(-) and NH(4)(+). Hydrogen was shown to be advantageous since it did not increase denitrification even when its addition was increased.

Distribution of phosphorus, copper and zinc in activated sludge treatment process of swine wastewater

Changes in swine wastewater chemical features during an activated sludge treatment process were surveyed on 11 farms, and analyzed with non-biodegradable elements, i.e., phosphorus (P), copper (Cu), and zinc (Zn). In piggery wastewater, they were linearly correlated with suspended solid (SS) concentrations and the major portion was in solid fractions. After the pretreatment step, they were removed, with 80% for total P, 85% for total Cu, and 84% for total Zn. After the activated sludge process, total P, Cu, and Zn were then removed at 83%, 96%, and 95%, respectively. Removing SS thoroughly at each step was shown to be the most important factor in preventing outflow of these elements, since there are linear correlations or a positive relationship between the removal of SS concentrations and their removal in solid form. Most of the P, Cu, and Zn in activated sludge effluent was in soluble form, and the concentrations of Cu and Zn in the effluent were low enough, while further P removal might be required.

Nitrogen removal by co-occurring methane oxidation, denitrification, aerobic ammonium oxidation, and anammox

The pathway for removing NO3− and NH4+ from wastewater in the presence of both CH4 and O2 was clarified by studying microbial activity and community. Batch incubation tests were performed to characterize the microbial activity of the sludge, which was acclimatized in a bioreactor in which O2 and CH4 were supplied to treat wastewater containing NO3− and NH4+. The tests showed that the sludge removed significant amounts of NO3− and NH4+ in the presence of CH4 and O2, and the presence of the activity of methane oxidation, denitrification, nitrification, and anammox in the sludge. It was estimated that the total inorganic nitrogen removal was attributed to denitrification associated with methane oxidation as 53.4%, microbial assimilation as 37.9%, and anammox as 8.7%. Nitrification also contributed to NH4+ decrease as 34.5% and anammox as 6.4%. Anammox activity was unambiguously demonstrated by 29N2 production in anaerobic batch incubation with 15N-labeled inorganic nitrogen compounds. The presence of methane-oxidizing bacteria and candidate denitrifiers in the sludge was shown by denaturing gradient gel electrophoresis of 16S rRNA gene fragments. Clone library analysis of the PCR-amplified 16S rRNA gene fragment using specific primers for aerobic ammonium oxidizer and anammox revealed the presence of these bacteria. The results reveal that complex nitrogen-removal processes occur in the presence of CH4 and O2 by methanotroph, denitrifier, aerobic ammonium oxidizer, and anammox.

Utilization of Bacillus sp. strain TAT105 as a biological additive to reduce ammonia emissions during composting of swine feces

Bacillus sp. strain TAT105 is a thermophilic, ammonium-tolerant bacterium that grows assimilating ammonium nitrogen and reduces ammonia emission during composting of swine feces. To develop a practical use of TAT105, a dried solid culture of TAT105 (5.3 × 109 CFU/g of dry matter) was prepared as an additive. It could be stored for one year without significant reduction of TAT105. Laboratory-scale composting of swine feces was conducted by mixing the additive. When the additive, mixed with an equal weight of water one day before use, was added to obtain a TAT105 concentration of above 107 CFU/g of dry matter in the initial material, the ammonia concentration emitted was lower and nitrogen loss was approximately 22% lower in the treatment with the additive than in the control treatment without the additive. The colony formation on an agar medium containing high ammonium could be used for enumeration of TAT105 in the composted materials. Graphical Abstract By adding the biological additive containing Bacillus sp. TAT105, NH3 emissions and nitrogen loss were reduced during the laboratory scale composting test of swine feces.

Estimation of Zn and Cu unit output loads from animal husbandry facilities

Zinc (Zn) and copper (Cu) are toxic to aquatic organisms at very low concentrations that do not affect humans. We measured the daily output of Zn and Cu in wastewater from livestock farms to aquatic environments because waste from animal husbandry operations contains high levels of Zn and Cu. At most pig farms in Japan, a mixture of urine, some faeces, and service water is treated in onsite wastewater treatment facilities and discharged into a water body. Some dairy farms also have wastewater treatment facilities. We surveyed 21 pig farms and six dairy farms. The unit (i.e., per head) output load from piggery wastewater treatment facilities ranged from 0.13 to 17.8 mg/head/d for Zn and from 0.15 to 9.4 mg/head/d for Cu. Over 70% of pig farms had unit output loads of Zn and Cu below 6 and 2 mg/head/d, respectively. For dairy farms, the unit output load from wastewater treatment facilities was estimated at 1.8-3.6 mg/head/d for Zn and 0.6 mg/head/d for Cu. The unit output load for Zn from piggery wastewater treatment facilities was similar to that from treatment facilities for human waste. However, pig farms generally raise several thousand to tens of thousands of pigs; pig farms are therefore presumed to be a significant point source of Zn in rural areas.

Responses of community structure of amoA-encoding archaea and ammonia-oxidizing bacteria in ammonia biofilter with rockwool mixtures to the gradual increases in ammonium and nitrate

To investigate community shifts of amoA‐encoding archaea (AEA) and ammonia‐oxidizing bacteria (AOB) in biofilter under nitrogen accumulation process.