Nobuyuki Sumitomo

A new high-alkaline and high-molecular-weight pectate lyase from a Bacillus isolate: enzymatic properties and cloning of the gene for the enzyme.

A pectate lyase (Pel; pectate transeliminase: EC4.2.2.2.), designated Pel-15H, was found in an alkaline culture of Bacillus sp. strain KSM-P15 and purified to homogeneity by sequential column chromatographies. The molecular weight of the enzyme determined by SDS-polyacrylamide gel electrophoresis was approximately 70,000 and the pI was around pH 4.6. Pel-15H randomly trans-eliminated polygalacturonate in the presence of Ca2+ ions, and the maximum activity was observed at pH 11.5 and at 55°C in glycine-NaOH buffer. The gene for Pel-15H was cloned and sequenced, and the structural gene contained a 2,031-bp open reading frame that encoded 677 amino acids including a possible 28-amino-acid signal sequence. The mature enzyme (649 amino acids, molecular weight 69,550) showed very low similarity to Pels from Bacillus with 12.7-18.2% identity. Interestingly, part of the amino acid sequence of Pel-15H had fairly high similarity only to an N-terminal half of PelL and a C-terminal half of PelX from Erwinia chrysanthemi 3937, and a C-terminal half of PelX from E. chrysanthemi EC16 (approximately 35% identity for all).

Site-directed mutagenesis of the putative active site of endoglucanase K from Bacillus sp. KSM-330.

The roles of one Glu and four Asp residues of endoglucanase K from Bacillus sp. KSM-330, which are conserved in all the endo-beta-glucanases in the family D, were analyzed by site-directed mutagenesis. The gene for endoglucanase K was mutated to replace Asp-154, Asp-191, Asp-193 or Asp-300 by Asn, or to replace Glu-130 by Gln in the encoded enzyme. Mutant and wild-type genes were separately expressed in Bacillus subtilis and the resultant enzymes were purified from the culture broth. All mutant enzymes exhibited the same mobility on SDS-polyacrylamide gel electrophoresis as the wild-type enzyme and gave similar circular dichroism spectra to that of the wild-type enzyme. Substitution of Glu-130, Asp-191, Asp-193 or Asp-300 significantly decreased the specific activity of the enzyme toward CM-cellulose. Kinetic analysis of the abilities of these mutant enzymes to liberate p-nitrophenol from p-nitrophenylcellotrioside revealed that all the mutant enzymes had very much lower kcat values than that of the wild-type enzyme, while the Km values of these mutant enzymes were almost the same as that of the wild-type enzyme. Of these Glu and Asp residues, Glu-130 and Asp-191 seem to be most likely to be catalytic residues because substitutions of these residues resulted in the lowest kcat values of the mutant enzymes.

Molecular cloning and nucleotide sequence of the gene encoding an endo-1,4-β-glucanase from Bacillus sp. KSM-330

The gene encoding an acid endo-1,4-beta-glucanase from Bacillus sp. KSM-330 was cloned into the HindIII site of pBR322 and expressed in Escherichia coli HB101. The recombinant plasmid contained a 3.1 kb HindIII insert, 1.8 kb of which was sufficient for the expression of endoglucanase activity in E. coli HB101. Nucleotide sequencing of this region (1816 bp) revealed an open reading frame of 1389 bp. The protein deduced from this sequence was composed of 463 amino acids with an Mr of 51882. The deduced amino acid sequence from amino acids 56 through 75 coincided with the amino-terminal sequence of the endoglucanase, Endo-K, purified from culture of Bacillus sp. KSM-330. The deduced amino acid sequence of Endo-K had 30% homology with that of the celA enzyme from Clostridium thermocellum NCIB 10682 and 25% homology with that of the enzyme from Cellulomonas uda CB4. However, the Endo-K protein exhibited no homology with respect to either the nucleotide or the amino acid sequences of other endoglucanases from Bacillus that had been previously characterized. These results indicate that the gene for Endo-K in Bacillus sp. KSM-330 has evolved from an ancestral gene distinct from that of other Bacillus endoglucanases.

Bifunctional pectinolytic enzyme with separate pectate lyase and pectin methylesterase domains from an alkaliphilic Bacillus

The gene for a novel enzyme having pectate lyase (Pel) and pectin methylesterase (Pme) activities found in the genome of an alkaliphilic Bacillus, KSM-P358, was sequenced. The structural gene contained a long open reading frame of 4314 bp corresponding to a 32-amino-acid signal peptide and a 1406-amino-acid mature enzyme with a molecular mass of 155,666. The mature enzyme contained two uncontiguous regions at amino acids 800–1051 and 1105–1406 exhibiting homology to a Pel from a Bacillus strain with 43.7% and a Pme from Erwinia chrysanthemi with 33.4% identity, respectively. The recombinant enzyme expressed in Bacillus subtilis cells had a molecular mass of 160 kDa and exhibited pH and temperature optima for Pel activity of 10 and 40 °C and those for the Pme activity of 8.5 and 45 °C. The genes for the domains for the Pel and Pme could be separately expressed in Escherichia coli cells, and the catalytic properties of the respective protein fragments were essentially identical to those of the intact enzyme. This novel enzyme is ‘mosaic’ in that some regions before the two domains exhibited limited but substantial similarity to some regions of carbohydrate-active enzymes. The regions contained parts of a gene for Pels from a Bacillus sp. and Pseudomonas fluorescens, a xylanase from P. fluorescens subsp. cellulosa, a 1,4-β-mannanase from a Pyromyces sp., a putative Pel from a Streptomyces coelicolor cosmid, a (1,3-1,4)-β-glucanase from Clostridium thermocellum.

Increased dipicolinic acid production with an enhanced spoVF operon in Bacillus subtilis and medium optimization

Dipicolinic acid (DPA) is a multi-functional agent for cosmetics, antimicrobial products, detergents, and functional polymers. The aim of this study was to design a new method for producing DPA from renewable material. The Bacillus subtilis spoVF operon encodes enzymes for DPA synthase and the part of lysine biosynthetic pathway. However, DPA is only synthesized in the sporulation phase, so the productivity of DPA is low level. Here, we report that DPA synthase was expressed in vegetative cells, and DPA was produced in the culture medium by replacement of the spoVFA promoter with other highly expressed promoter in B. subtilis vegetative cells, such as spoVG promoter. DPA levels were increased in the culture medium of genetically modified strains. DPA productivity was significantly improved up to 29.14 g/L in 72 h culture by improving the medium composition using a two-step optimization technique with the Taguchi methodology. Graphical Abstract Expression of DPA synthase operon in vegetative cells in B. subtilis and the optimization of the medium composition significantly improved DPA productivity.