Patcharee Tungtrakul

Effect of Fluidized Bed Drying Temperature on Various Quality Attributes of Paddy

Abstract As reported by many researchers, it was found that fluidized bed paddy drying using high drying air temperatures of over 100°C affected the head rice yield and whiteness of dried rice. However, only a few studies on fluidized bed paddy drying with drying air temperatures below 100°C were so far reported. The main objective of this work was therefore to study the effect of fluidized bed drying air temperature on various quality parameters of Suphanburi 1 and Pathumthani 1 Indica rice. Paddy was dried from the initial moisture contents of 25.0, 28.8, and 32.5% dry basis to 22.5 ± 1.2% dry basis using inlet drying air temperatures between 40 and 150°C at 10°C/step. After fluidized bed drying, paddy was tempered and followed by ambient air aeration until its final moisture content was reduced to 16.3 ± 0.5% dry basis. The results showed that the head rice yield of Suphanburi 1 was significantly related to the inlet drying temperature and initial moisture content whilst there was no significant relationship between the head rice yield, drying temperature and initial moisture content for Pathumthani 1. The whiteness of the two rice varieties was slightly decreased with increase in drying air temperature and initial moisture content. It was also found that the hardness of both cooked rice varieties exhibited insignificant difference (p < 0.05) comparing to rewetted rice, which was gently dried by ambient air aeration in thin layer. The thermal analysis by DSC also showed that partial gelatinization occurred during drying at higher temperatures. Using inlet drying air temperatures in the range of 40–150°C therefore did not affected the quality of cooked rice and paddy. The milling quality of paddy was also well maintained.

Germination Conditions Affect Physicochemical Properties of Germinated Brown Rice Flour

Germinated brown rice has been reported to be nutritious due to increased free gamma-aminobutyric acid (GABA). The physicochemical properties of brown rice (BR) and glutinous brown rice (GNBR) after germination as affected by different steeping times (24, 36, 48, and 72 h depending on the rice variety) and pHs of steeping water (3, 5, 7, and as-is) were determined and compared to those of the nongerminated one (control). As the steeping time increased or pH of steeping water decreased, germinated brown rice flours (GBRF) from both BR and GNBR had greater reducing sugar, free GABA and alpha-amylase activity; while the total starch and viscosity were lower than their respective controls. GBRFs from both BR and GNBR prepared after 24-h steeping time at pH 3 contained a high content of free GABA at 32.70 and 30.69 mg/100 g flour, respectively. The peak viscosity of GBRF obtained from both BR and GNBR (7.42 to 228.22 and 4.42 to 58.67 RVU, respectively) was significantly lower than that of their controls (255.46 and 190.17 RVU, respectively). The principal component analysis indicated that the important variables for discriminating among GBRFs, explained by the first 2 components at 89.82% of total explained variance, were the pasting profiles, alpha-amylase activity, and free GABA.

Germination conditions affect selected quality of composite wheat-germinated brown rice flour and bread formulations.

Brown rice has been reported to be more nutritious after germination. Germinated brown rice flours (GBRFs) from different steeping conditions (in distilled water [DI, pH 6.8] or in a buffer solution [pH 3] for either 24 or 48 h at 35 degrees C) were evaluated in this study. GBRF obtained from brown rice steeped at pH 3 for 48 h contained the highest amount of free gamma aminobutyric acid (GABA; 67 mg/100 g flour). The composite flour (wheat-GBRF) at a ratio of 70 : 30 exhibited significantly lower peak viscosity (PV) (56.99 - 132.45 RVU) with higher alpha-amylase activity (SN = 696 - 1826) compared with those of wheat flour (control) (PV = 136.46 RVU and SN = 1976). Bread formulations, containing 30% GBRF, had lower loaf volume and greater hardness (P < 0.05) than the wheat bread. However, the hardness of bread containing 30% GBRF (except at pH 6.8 and 24 h) was significantly lower than that of bread containing 30% nongerminated brown rice flour (BRF). Acceptability scores for aroma, taste, and flavor of breads prepared with or without GBRFs (30% substitution) were not significantly different, with the mean score ranging from 6.1 (like slightly) to 7 (like moderately). Among the bread formulations containing GBRF, the one with GBRF prepared after 24 h steeping at pH 3 had a slightly higher (though not significant) overall liking score (6.8). This study demonstrated that it is feasible to substitute wheat flour with up to 30% GBRF in bread formulation without negatively affecting sensory acceptance. Practical Application: Our previous study revealed that flours from germinated brown rice have better nutritional properties, particularly gamma-aminobutyric acid (GABA), than the nongerminated one. This study demonstrated feasibility of incorporating up to 30% germinated brown rice flour in a wheat bread formulation without negatively affecting sensory acceptance. In the current United States market, this type of bread may be sold as frozen bread which would have a longer shelf life. Further study is thus needed.

Quality Attributes of Germinated High-Amylose and Waxy Rice in Superheated Steam and Hot Air Drying

In this work, the effects of amylose content, drying medium, and drying temperature on the fissure, texture, and glycemic index of germinated paddy (GP) were investigated. The amylose content, drying temperature, and drying medium affected the degree of starch gelatinization and percentage of fissure kernels significantly. Hot air drying at 130 and 150°C insignificantly influenced the hardness of Phitsanulok 2 GP with high amylose content after cooking compared to that of shade-dried GP, and the drying temperatures significantly affected the hardness and stickiness of RD6 GP without amylose content. Superheated steam drying caused a significant change in textural properties for both paddy varieties because of complete starch gelatinization. The high-amylose paddy had higher gamma-aminobutyric acid and lower glycemic index than nonamylose paddy. Drying temperature and drying media did not change the gamma-aminobutyric acid and glycemic index of both GP varieties in comparison to their shade-dried samples.

Simple, Selective, and Rapid Quantification of 1-Deoxynojirimycin in Mulberry Leaf Products by High-Performance Anion-Exchange Chromatography with Pulsed Amperometric Detection

1-Deoxynojirimycin (DNJ) occurs in mulberry and other plants and is a highly potent glycosidase inhibitor reported to suppress blood glucose levels, thus preventing diabetes. Derivatization is required for quantification of DNJ upon use of spectral detection methods. Because of this difficulty, the DNJ contents of mulberry-based food products are rarely stated, even if DNJ is their active component. A simple, selective, and rapid method of high-performance anion-exchange chromatography with pulsed amperometric detection (HPAEC-PAD) to quantify DNJ in mulberry-based food products was developed. Stability testing of DNJ under heat treatment was also performed. A water extract of mulberry tea sample was subjected to HPAEC-PAD in a CarboPac MA1 column with a sodium hydroxide gradient. DNJ was clearly separated at a retention time of 7.26 min without interference and was selectively detected in the water extract. The detection limit was 5 ng. Heat stability studies suggested that DNJ was heat stable. HPAEC-PAD was not subject to interference, was highly selective for DNJ, and was superior to other high-performance liquid chromatography (HPLC) techniques in terms of sample preparation, resolution, and sensitivity. The method allowed simple, selective, and rapid analysis of DNJ in food matrices and might be useful for development of mulberry-based food products. Heat treatment could be an option for sterilizing mulberry-based products.

Effect of Drying Temperature on Drying Characteristics and Quality of Germinated Rices Prepared from Paddy and Brown Rice

Kernel fissuring generally occurs during the germination and drying processes when germinated rice is conventionally prepared from brown rice. Fermentation also occurs during germination. These problems result in a product of lower quality. As an alternative, germinated rice may be prepared from paddy. In this work, a comparative evaluation of the drying characteristics and quality of germinated rice prepared from paddy (GP) and brown rice (GBR) was conducted. The experimental results showed that GP had advantages over GBR; that is, it led to a product with higher γ-aminobutyric acid (GABA) content, a smaller number of fissured kernels, and a smaller number of attached microorganisms during both the germination and drying steps. The required germination time for the GP was also significantly shorter. More important, sensory analysis results revealed that the overall acceptability of cooked GP was higher than that of cooked GBR.

Effects of Germination Process and Drying Temperature on Gamma-Aminobutyric Acid (GABA) and Starch Digestibility of Germinated Brown Rice

In this work, germination method, germination time, and drying temperature were investigated for their effects on gamma-aminobutyric acid (GABA) and starch digestibility. The germination method and germination time influenced the GABA and dietary fiber contents as well as starch and glucose, but both factors did not provide a faster hydrolysis of starch for germinated brown rice because of the dietary fiber. When the germinated samples were dried by a hot-air fluidized bed dryer at 130 or 150°C, the GABA content was not decreased and the amylose-lipid complexes occurred. Dissociation temperature of the complexes was given in a range of 100–117°C, which was lower than that of complexes in the non-germinated paddy. Thus, the amylose-lipid complexes in the germinated samples obtained at high temperature lost some crystalline structure when cooked by the boiling method. The corresponding rate of starch hydrolysis or glycemic index of the germinated samples changed insignificantly from that of the shade-dried germinated sample or non-germinated brown rice which was dried in shade.

Optimal Operating Conditions to Produce Nutritious Partially Parboiled Brown Rice in a Humidified Hot Air Fluidized Bed Dryer

V-type amylose–lipid complexes present in partially parboiled rice can decrease starch digestibility. Formation of such complexes can be accomplished using high-temperature fluidized bed drying; the degree of the complexes depends on the thermal condition. The effects of drying media (hot air and humidified hot air), operating conditions (drying air temperature and relative humidity [RH]), and the initial moisture content on the degree of V-type crystallinity and subsequent starch digestibility (or glycemic index, GI) and brown rice texture were examined experimentally. The results showed that paddy drying with humidified hot air (HHA) requires a longer time than hot air (HA). Higher drying air temperature, RH, and initial moisture content of paddy yield higher degrees of starch gelatinization and V-type amylose–lipid complexes. The brown rice dried by HA or HHA had lower starch digestibility and a harder texture than the reference sample. Within the range of parameters studied, to obtain the lowest GI for the dried brown rice, paddy at an initial moisture content of 33% (db) should be dried by HHA at 150°C and 6.4% RH.

Experiments on In-Store Paddy Drying Under Tropical Climate: Simulation and Product Quality

Abstract The main objective of this work is to study the rice whiteness and paddy qualities of rice in terms of hardness, stickiness, cohesiveness, and germination of rice. The prediction results of moisture content and whiteness are compared with the experimental results using a near-equilibrium drying model, which is modified by including whiteness kinetics of rice kernel. The long grain rice (Suphanburi 1 high amylose indica variety), which consists of 27% amylose was used for all experiments. The experiments were carried out at the average ambient temperature range of 28.6–30.8°C, average relative humidity of 65.2–80.6% with a fixed bed depth of 1.0 m. Specific air flow rates of 0.65 and 0.93 m3/min-m3 of paddy were forced continuously through the paddy bulk at initial moisture contents of 18.5% and 20.1% wet basis, respectively. The desired final moisture content of paddy is about 13.3 ± 0.6% wet basis. The results show that drying rate and the whiteness predictions are in good agreement with those from the experiments. The in-store drying using ambient air condition did not produce notable effect on the rice whiteness, head rice yield, and the percentage of paddy germination. However, the hardness, stickiness, and cohesiveness of rice were changed.

Improving head rice yield of glutinous rice by novel parboiling process

ABSTRACT Most commercial parboiled rice is produced from high-amylose content rice. Glutinous rice, which is lacking in amylose content, is generally consumed in Southeast Asian countries. Rare study of parboiling glutinous rice has been observed. In this study, glutinous rice was improved in head rice yield by a novel parboiling process. Two rough glutinous rice, rice department 6 (RD6) and black glutinous rice (BGR) cultivars, were soaked in hot water at 70 ± 5°C for 3 h. The ricer 3moisture content after soaking was 50–52% (d.b.), it was dried with hot air and superheated steam (SHS) at 110, 130, and 150°C in a fluidized bed dryer. The results show that SHS at all drying temperatures can improve the high head rice yield in both parboiled glutinous rice cultivars better than hot air drying. Higher temperature drying caused L* value to decrease but the b* value increases in RD6, whereas in BGR, all color values decreased and ΔE* was increased when the drying temperature increased. Increasing drying temperature presented a softer texture of both glutinous rice cultivars. Upper 130°C, completed gelatinization of both varieties can be obtained and seen by scanning electron microscope and differential scanning calorimeter (DSC). This technique of using high-temperature fluidized bed drying can produce completely parboiled glutinous rice in a single process instead of two conventional processes, steaming and drying, in series.