R. Companyó

High-throughput multiclass method for antibiotic residue analysis by liquid chromatography–tandem mass spectrometry☆

A simple and rapid method has been developed for the residue analysis of 39 antibiotics (tetracyclines, quinolones, penicillins, sulfonamides and macrolides) in foodstuffs of animal origin. The method combines an effective extraction technique, which uses water-methanol as extracting solvent, with ultra-high-pressure liquid chromatography-tandem mass spectrometry, allowing both confirmation and quantification in a single chromatographic run. The multiresidue method has been validated in chicken muscle matrix according to European Union Decision 2002/657/EC. It has been implemented as a routine method in a Public Health Laboratory, instead of the five plates test and LC methods previously used.

Development and validation of a multiclass method for the analysis of antibiotic residues in eggs by liquid chromatography–tandem mass spectrometry

A multiclass method for the analysis of residues, in egg matrices, of 41 antimicrobial agents belonging to seven families (sulfonamides, diaminopyridine derivates, quinolones, tetracyclines, macrolides, penicillins and lincosamides) was developed and validated according to the requirements of European Commission Decision 2002/657. Compounds were extracted with a pressurized liquid extraction (PLE) technique using a 1:1 mixture of acetonitrile and a succinic acid buffer (pH 6.0) at 70 °C. As this resulted in clear extracts, no further clean-up was necessary. Analytes were determined by ultra-high-pressure liquid chromatography-tandem mass spectrometry (UHPL-MS/MS) in a chromatographic run of 13 min. Calibration was carried out with spiked blank samples subjected to the entire analytical procedure. Five compounds, two of them isotopically labelled, were used as internal standards. Most analytes were quantified with errors below 10%. Precision in terms of reproducibility standard deviation was between 10% and 20% in most cases. CCα values were in the range 0.5-3.8 μg kg⁻¹ for the non-authorized compounds. The proposed method would enable an experienced analyst to process about 25 samples per day.

Restricted access materials for sample clean-up in the analysis of trace levels of tetracyclines by liquid chromatography. Application to food and environmental analysis.

Restricted access materials (RAM) based on alkyl diol silica (ADS) porous particles were evaluated for the sample clean-up in tetracyclines analysis in milk and water samples by liquid chromatography. RAM with C(4), C(8) and C(18) bonded to the inner pore surfaces were tested, with C(8) providing the best performance. A switching column LC system which combines an ADS C(8) RAM column and an analytical C(18) column connected to a fluorimetric detector was used for tetracyclines analysis. The RAM clean-up removed large peaks that otherwise appeared in the initial time window of the chromatograms, attributed to proteins in milk samples and humic substances in water samples. Thus, quantification of analytes in real samples, especially of the most polar compounds such as oxytetracycline and tetracycline, was clearly improved.

Targeted analysis with benchtop quadrupole-orbitrap hybrid mass spectrometer: application to determination of synthetic hormones in animal urine.

Sensitive and unequivocal determination of analytes/contaminants in complex matrices is a challenge in the field of food safety control. In this study, various acquisition modes (Full MS/AIF, Full MS+tMS/MS, Full MS/dd MS/MS and tSIM/ddMS/MS) and parameters of a quadrupole-orbitrap hybrid mass spectrometer (Q Exactive) were studied in detail. One of the main conclusions has been that, reducing the scan range for Full MS (using the quadrupole) and targeted modes give higher signal-to-noise (S/N) ratios and thereby better detection limits for analytes in matrix. The use of Q Exactive in a complex case, for the confirmatory analysis of hormones in animal urine is presented. A targeted SIM data dependent MS/MS (tSIM/ddMS/MS) acquisition method for determination of eight synthetic hormones (trenbolone, 17α ethinylestradiol, zeranol, stanozolol, dienestrol, diethylstilbestrol, hexestrol, taleranol) and a naturally occurring hormone (zearalenone) in animal urine were optimized to have sensitive precursors from targeted SIM mode and trigger MS/MS scans over the entire chromatograph peak. The method was validated according to EC/657/2002. CCα (decision limit) for the analytes ranged between 0.11 μg L(-1) and 0.69 μg L(-1) and CCβ (detection capability) ranged between 0.29 μg L(-1) and 0.90 μg L(-1).

Antibiotics in food: Legislation and validation of analytical methodologies

In this paper, European food safety legislation is presented, and special attention is devoted to monitoring residues of veterinary drugs in foodstuffs of animal origin. After a short review of the state of the art of analytical methodology for antibiotic residue analysis, the paper focuses on validation of analytical methods, with Decision 657/2002/EC as reference document. Finally, the main issues of the quality control of the analytical data, i.e. analysis of reference materials and participation in proficiency tests, are briefly addressed.

Hydrophilic interaction chromatography for the analysis of aminoglycosides.

The effect of mobile-phase constituents (pH and ionic strength) and chromatographic behaviour of ten aminoglycosides (streptomycin, dihydrostreptomycin, spectinomycin, apramycin, paramomycin, kanamycin A, gentamycin C1, gentamycin C2/C2a, gentamycin C1a and neomycin) in the bare silica, amino, amide and zwitterionic phases of hydrophilic interaction chromatography (HILIC) were studied systematically. Among the stationary phases studied, the zwitterionic phase provided the best separation of aminoglycosides. The effect of pH, ionic concentration and column temperature on retention time, peak shape and sensitivity was studied using a central composite design. pH affected sensitivity of the detection of analytes but not the retention time. High ionic strength in the mobile phase was necessary to control the ionic interactions between ionised aminoglycosides and the hydrophilic phase, thereby influencing peak shape and retention time. Column temperature affected sensitivity of the detection but not the retention time. During method development, crosstalk between the MS/MS channels of the analytes was observed and resolved.

Analysis of sulfonamides in animal feeds by liquid chromatography with fluorescence detection.

Two analytical methodologies for the simultaneous analysis of eight sulfonamide antibiotics in animal feeds were developed. Analytes were extracted in a simple and rapid procedure by manual shaking with an ethyl acetate/ultrapure water mixture (99:1, v/v) without further sample cleanup. Mean recoveries ranging from 72.7% to 99.4% with relative standard deviations below 9% were achieved from spiked animal feed samples. Determination was carried out by high-performance liquid chromatography using fluorometric detection with precolumn derivatization. The separation of the derivatized compounds was performed using two different chromatographic columns: a conventional C(18) column and a recently available core-shell particle Kinetex C(18) column. Both methods were validated in-house in six different feed matrices, and the two approaches were compared. The experiments showed that the method using the Kinetex column was superior with regard to speed of analysis and precision, both under repeatability and intermediate reproducibility conditions. The limits of detection and quantification were also greatly improved, below 0.10 and 0.34 μg/g, respectively. Finally, this novel approach was successfully applied to the analysis of real feed samples.

Validation of a method for the analysis of nine quinolones in eggs by pressurized liquid extraction and liquid chromatography with fluorescence detection.

A multiresidue method for the analysis, in egg matrices, of residues of nine quinolones used in veterinary medicine, has been developed and validated according to the provisions of Council Decision 2002/657. Compounds were extracted by a pressurized liquid extraction (PLE) technique using a 1:1 mixture of acetonitrile and a phosphoric acid buffer (pH 3.0) at 70°C. The obtained extract was clear enough, so that no further clean-up was necessary. Analytes were determined by liquid chromatography (LC) with fluorescence detection (FL). Two chromatographic columns were compared: a high-purity silica Inertsil C(8) column and a newly developed Kinetex C(18) core-shell technology column. Validation was carried out at four concentration levels, using both chromatographic columns. Precision in terms of reproducibility standard deviation was between 7% and 23%, and good recoveries were obtained. Decision limit (CCα) and detection capability (CCβ) values obtained with the Inertsil and Kinetex columns were in the 0.2-19.8 μg kg(-1) and 0.4-33.5 μg kg(-1) concentration ranges, respectively. The proposed method allows residues of quinolones banned for use with laying hens to be detected and quantified in eggs. About twenty-four samples per day can be processed.

Determination of aminoglycoside residues in kidney and honey samples by hydrophilic interaction chromatography‐tandem mass spectrometry

Two methods based on liquid chromatography-tandem mass spectrometry were developed for the determination of ten aminoglycosides (streptomycin, dihydrostreptomycin, spectinomycin, apramycin, paromomycin, kanamycin A, gentamycin C1, gentamycin C2/C2a, gentamycin C1a, and neomycin B) in kidney samples from food-producing animals and in honey samples. The methods involved extraction with an aqueous solution (for the kidney samples) or sample dissolution in water (for the honey samples), solid-phase extraction with a weak cation exchange cartridge and injection of the eluate into a liquid chromatography-tandem mass spectrometry system. A zwitterionic hydrophilic interaction chromatography column was used for separation of aminoglycosides and a triple quadrupole mass analyzer was used for detection. The methods were validated according to Decision 2002/657/EC. The limits of quantitation ranged from 2 to 125 μg/kg in honey and 25 to 264 μg/kg in the kidney samples. Interday precision (RSD%) ranged from 6 to 26% in honey and 2 to 21% in kidney. Trueness, expressed as the percentage of error, ranged from 7 to 20% in honey and 1 to 11% in kidney.

Analysis of thyreostatic drugs in thyroid samples by ultra-performance liquid chromatography tandem mass spectrometry detection.

A method based on ultra-performance liquid chromatography-electrospray ionisation-tandem mass spectrometry for the determination of six thyreostatic drugs in thyroid tissue has been optimised and validated in accordance with the Decision 2002/657/EC. Samples are extracted with methanol and the extracts cleaned-up on silica cartridges. The recoveries range from 40% for 6-phenyl-2-thiouracil to 79% for 2-thiouracil. Quantification is carried out with blank tissue samples spiked with the analytes in the range 25-500 microg kg(-1). 5,6-Dimethyl-2-thiouracil is used as internal standard. CCalpha and CCbeta are in the ranges 4.3-16.1 microg kg(-1) and 8.7-20.7 microg kg(-1), respectively. Accuracy, expressed as percentage of error, is lower than 6% and relative standard deviation in reproducibility conditions falls between 5.6 and 10.3%. Nowadays, the proposed method is routinely implemented in the laboratory of the Agència de Salut Pública de Barcelona and allows processing of up to 20 samples per day.