Robert Kemp

Evaluation of combined effects of ageing period and freezing rate on quality attributes of beef loins

The objective of our study was to evaluate the combined effects of ageing period and different freezing rates on meat quality attributes of beef loins. Pairs of loins (M. longissimus at 1 day post mortem) from 12 carcasses were divided into four equal portions and randomly assigned to four ageing/freezing treatments (aged only, frozen only, and 3 or 4 weeks ageing at -1.5°C then frozen). Two freezing methods (fast freezing by calcium chloride immersion or slow freezing by air freezer at -18°C) were applied to the loin sections. Fast freezing had no effect on shear force (P>0.05), but significantly improved the water-holding capacity of the aged/frozen loins by reducing purge and drip losses. Ageing-then-freezing significantly improved shear force values of loins compared to both the aged only and frozen only loins. These observations suggest that fast freezing will add more value to the aged/frozen/thawed meat by minimising the amount of water-loss due to the freezing/thawing process.

Effects of dry-aging on meat quality attributes and metabolite profiles of beef loins

The objectives of this study were to evaluate different dry-aging regimes and their impacts on quality attributes and metabolite profiles of beef loins. Thirty loins (M. longissimus lumborum) from 15 beef carcasses at 2 days post-mortem were obtained. Each loin was cut in half yielding 60 sections, which were randomly assigned to six treatments including 4 dry-aging (2 temperatures (1 or 3°C) × 2 air-velocities (0.2 or 0.5 m/s)) and 2 wet-aging regimes for 3 weeks; n=10/treatment. The sensory panel found that dry-aged loins had better flavour and overall liking (P<0.05), but there were no differences in tenderness and juiciness. No differences in drip/cook-loss and colour were observed. Metabolite analysis showed that 7 metabolites, including several flavour precursors, were more abundant in the dry-aged beef compared to the wet-aged beef, which may contribute to the enhanced flavours of the dry-aged beef. Overall, dry-aging loins at 3°C with 0.2m/s resulted in the greatest improvement in beef palatability.

The initial freezing point temperature of beef rises with the rise in pH: A short communication

This study tested the hypothesis that the initial freezing point temperature of meat is affected by pH. Sixty four bovine M. longissimus thoracis et lumborum were classified into two ultimate pH groups: low (<5.8) and high pH (>6.2) and their cooling and freezing point temperatures were determined. The initial freezing temperatures for beef ranged from -0.9 to -1.5°C (∆=0.6°C) with the higher and lower temperatures associated with high and low ultimate pH respectively. There was a significant correlation (r=+0.73, P<0.01) between beef pH and freezing point temperature in the present study. The outcome of this study has implications for the meat industry where evidence of freezing (ice formation) in a shipment as a result of high pH meat could result in a container load of valuable chilled product being downgraded to a lower value frozen product.

Spray chilling of deer carcasses—Effects on carcass weight, meat moisture content, purge and microbiological quality

Twenty red deer carcasses were included in the study. Two treatments were applied to the carcasses; control (air chilling) and spray chilling (n=10 for each treatment). Carcass weight and temperature change were registered during over-night chilling. Meat moisture content was measured in the shoulder, loin, flap and leg before and after the chilling treatments; purge, cooking loss and tenderness were measured in loin samples stored at -1.5 °C for 3 and 9 weeks. Microbiological status was assessed on swabs taken at the lumbar end of the loin before and after the chilling treatments. Spray chilling reduced carcass weight loss significantly; air chilled and spray chilled carcasses lost 1 kg and less than 0.01 kg, respectively. No effects of spray chilling on tenderness, purge and cooking loss were found. Bacterial levels were low in general even after 9 weeks of vacuum packaged chilled storage.

Rapid tenderisation of lamb M. longissimus with very fast chilling depends on rapidly achieving sub-zero temperatures

A study was undertaken to determine whether variations within the defined temperature-by-time profile for very fast chilling (VFC), might explain variations in tenderness found with VFC. Loins from 32 lambs were subjected to one of five cooling regimes; defined by the average temperature between the meat surface and centre reached at a specific time post mortem. These were: -0.3 °C at 22 h (Control), 2.6 °C at 1.5 h (Fast(supra-zero)), 0.7 °C at 5.5 h (Slow(supra-zero)), -1.6 °C at 1.5 h (Fast(sub-zero)) and -2.3 °C at 5.5 h (Slow(sub-zero)), respectively. Shear force values considered very tender by consumers (less than 50 N, MIRINZ tenderometer) were found 2 days post mortem in Fast(sub-zero) loins only. Both time and temperature at the end of the cooling period contributed to variations in shear force. To achieve low shear force, the loins needed to be cooled to less than 0 °C at 1.5 h post mortem.