Rosa Loponte

Yellow mealworm larvae (Tenebrio molitor, L.) as a possible alternative to soybean meal in broiler diets

Abstract The aim of the study was to evaluate the feasibility of replacing soybean meal (SBM) with Tenebrio molitor larvae (TML) meal in broiler diets. A total of 80 30-d-old male Shaver brown broilers were divided into two groups fed on two isoproteic and isoenergetic diets differing for protein source (SBM vs. TML). Up to 62 d of age, body weight and feed intake were recorded weekly and body weight gain, feed conversion ratio (FCR), protein efficiency ratio (PER) and European efficiency factor (EEF) were calculated. At 62 d, blood samples were collected from 16 birds/group for evaluation of blood profiles. Feed intake was not different between groups considering the entire period of the trial. The FCR was more favourable in the TML than SBM group from 46 d of age and in the entire period of the trial (4.13 vs. 3.62). The PER was higher in the SBM than in the TML group (1.92 vs. 1.37) while the EEF was higher in broilers fed on the TML diet (132.6 vs. 156.2). Albumin-to-globulin ratio was higher in broilers fed on SBM than in the other group (0.44 vs. 0.30). aspartate aminotransferase and alanine aminotransferase were higher in TML than SBM (195.1 vs. 178.6 U/l and 82.07 vs. 46.71 U/l, respectively). Uric acid was higher in broilers fed on SBM than TML (5.40 vs. 4.16 mg/dl). TML did not affect feed intake and growth rate of broilers from 30 to 62 d of age when compared to an isoproteic and isoenergetic SBM diet, but FCR of the TML group was more favourable than that of the SBM group. The lowest albumin-to-globulin ratio in broilers fed on TML suggests a higher immune response, probably due to the prebiotic effects of chitin.

Use of Tenebrio molitor larvae meal as protein source in broiler diet: Effect on growth performance, nutrient digestibility, and carcass and meat traits

The aim of this research was to study the effect of insect meal from larvae ( larvae meal [TML]) as complete replacement of soybean meal (SBM) on growth performance, nutrient digestibility, and carcass and meat traits of broilers. A total of eighty 30-d-old male Shaver brown broilers were homogenously divided into 2 groups (each consisting of 8 replicates of 5 birds). Up to 62 d of age, the groups were fed 2 isoproteic and isoenergetic diets differing for the ingredient used as the main protein source: the control group was fed a corn-SBM-based diet, whereas in the TML group, the SBM was completely replaced by TML. Broiler growth performance was measured during the trial. At 62 d of age, 2 broilers per replicate (16 per group) were slaughtered and apparent ileal digestibility coefficients and carcass and meat traits were determined. The use of TML as the main protein source in the broiler diet had no significant effect on most growth performance and carcass traits and chemical and physical properties of meat, the latter being important for marketing purposes. The feed conversion ratio in the entire experimental period (from 30 to 62 d) was improved in the TML group compared with the SBM group ( < 0.05). The apparent ileal digestibility coefficients of DM, OM, and CP in broilers fed the SBM diet were greater ( < 0.01) than the other group. The full digestive system in broilers fed SBM had a lower ( < 0.05) absolute and relative weight than that of broilers fed TML. Also, the weight and the percentage of the spleen in the SBM group were lower ( < 0.05) than those in the TML group. The length of the entire intestine in the group fed TML was greater ( < 0.05) than the other group and the same happened when intestinal length was expressed as percentage of broiler BW ( < 0.05). Among the different intestinal tracts, the ileum and ceca of broilers fed TML had a greater ( < 0.05) length than that of broilers fed SBM. Also, ceca weight (as an absolute value or percentage on live weight) in broilers fed TML was greater ( < 0.05) than that of broilers fed SBM. Breast pH and cooking losses in broilers fed TML were greater ( < 0.05) than those of broilers fed SBM. Chemical characteristic of meat obtained from right breast of slaughtered broilers were unaffected by dietary treatments. larvae meal can be a suitable alternative protein source for growing broilers and also when used as principal protein contributor to the diet.

In vitro crude protein digestibility of Tenebrio molitor and Hermetia illucens insect meals and its correlation with chemical composition traits

The aims of this study were to evaluate the correlation between in vitro crude protein digestibility coefficients of insect meals from Tenebrio molitor (TI) and Hermetia illucens (HI) and their chemical composition traits as well as to develop regression equations able to estimate the in vitro crude protein digestibility (CPd) from proximate analysis of insect meals. Twelve samples of insect meals (6 from TM larvae, TM 1-6 and 6 from HI larvae, HI 1-6) were obtained from different producers and analysed for chemical composition and in vitro crude protein digestibility by a two-step enzymatic method (digestion with pepsin and trypsin-enriched pancreatin). For both insect meal samples, CPd was negatively correlated to ADF and chitin contents, while just for HI there was a positive correlation (P<0.01) between CP percentage of the samples and CPd. For both insect meals the former variable chosen in the stepwise analysis was the chitin, explaining the 79.45% of CPd variability for Tenebrio molitor samples and the 98.30% for Hermetia illucens. In the second step, the amount of protein linked to ADF was added in the model for T. molitor and CP for H. illucens samples. The coefficients chitin is the main constituent of insect body able to affect the crude protein digestibility of Tenebrio molitor and Hermetia illucens larvae meals estimated by an in vitro enzymatic method.

Productive performance and blood profiles of laying hens fed Hermetia illucens larvae meal as total replacement of soybean meal from 24 to 45 weeks of age

&NA; The aim of the research was to study the effects of an insect meal from Hermetia illucens larvae (HILM) as complete replacement of soybean meal (SBM) on productive performance and blood profiles of laying hens, from 24 to 45 wk of age. A total of 108 24‐week‐old Lohmann Brown Classic laying hens was equally divided into 2 groups (54 hens/group, 9 replicates of 6 hens/group). From 24 to 45 wk of age, the groups were fed 2 different isoproteic and isoenergetic diets: the control group (SBM) was fed a corn‐soybean meal based diet, while in the HILM group the soybean meal was completely replaced by Hermetia illucens larvae meal. Feed intake, number of eggs produced, and egg weight were recorded weekly along the trial. At 45 wk of age, blood samples were collected from 2 hens per replicate. The use of HIML led to a more favorable (P < 0.01) feed conversion ratio in hens but lay percentage, feed intake, average egg weight, and egg mass were higher (P < 0.01) in hens fed the SBM diet. Hens fed insect meal produced a higher percentage of eggs from small (S), medium (M), and extra‐large (XL) classes (P < 0.01) than SBM, while the SBM group had a higher percentage of eggs from the large (L) class (P < 0.01). The levels of globulin and albumin to globulin ratio were, respectively, higher and lower (P < 0.05) in HILM than the SBM group. Cholesterol and triglycerides were higher (P < 0.05 and P < 0.01, respectively) in hens from SBM than in the HILM group. Blood levels of Ca were higher (P < 0.01) in hens fed insect meal, while creatinine was higher (P < 0.01) in blood of hens fed SBM. Hermetia illucens larvae meal can be a suitable alternative protein source for laying hens even if the complete replacement of soybean meal needs further investigation to avoid the negative effects on feed intake.

Growth performance, blood profiles and carcass traits of Barbary partridge (Alectoris barbara) fed two different insect larvae meals (Tenebrio molitor and Hermetia illucens)

To investigate the effect of two insect meals (from Hermetia illucens, HI and Tenebrio molitor, TM larvae) on productive performance and blood profiles of Barbary partridge, ninety, seven days old partridges were divided into 5 groups (6 replicates, 3 partridges/replicate). Up to 64d, the groups fed 5 isoproteic and isoenergetic diets: the control fed a corn-soybean meal diet (SBM group); in TM25 and TM50 groups the 25 and 50% of SBM proteins were substituted by the protein from TM, respectively; in HI25 and HI50 groups the 25 and 50% of SBM were substituted by the protein from HI, respectively. The birds fed TM25 and both the HI levels reached a higher (P<0.01) live weight at 64d than the control. Considering the entire experimental period the TM groups had a more favorable FCR than SBM. The carcass weights of all the insect groups were higher (P<0.01) than the control. The weight of the full digestive tract in SBM group was the highest (P<0.01). The caecal weight, the intestinal and caecal length were the highest (P<0.01) in the SBM group. The SBM group the highest value of albumin/globulin (P<0.01) and creatinine (P<0.05). TM seems to be more effective than HI in improving FCR. The reduced albumin/globulin ratio in the insect meal fed groups could be ascribed to the chitin content and this result was not affected by the amount of chitin intake, suggesting that also the lowest values are able to express their potential effects in partridges.

Evaluation of an insect meal of the Black Soldier Fly (Hermetia illucens) as soybean substitute: Intestinal morphometry, enzymatic and microbial activity in laying hens

This research investigated the ileum morphometry and enzymatic activity, the caecal volatile fatty acid production and the apparent nutrient digestibility in laying hens fed a Hermetia illucens larvae meal (HILM) as a complete replacement of diet soybean meal (SBM). The hens fed HILM exhibited a lower live weight (P<0.05) and a higher incidence of the full digestive tract (P<0.05) than the SBM group. In the duodenum, the maltase exhibited a higher (P<0.05) activity in the HILM group while the intestinal alkaline phosphatase (IAP) had a higher (P<0.05) activity in the SBM group. In the ileum, the maltase and saccarase had a higher activity in the HILM hens (P≤0.01) while the IAP and ɤ glutamil transferase had a higher activity in the SBM group (P<0.05 and P<0.01, respectively). The HILM group showed a higher (P<0.05) villi height in the duodenum, while the opposite happened in the jejunum and the ileum. Only in the ileum the crypt depth resulted higher (P<0.05) in the HIML group than in the SBM. The higher production of acetate (P<0.05) and butyrate (P<0.01) affected the total production of volatile fatty acids of the HILM group. The coefficient of apparent digestibility of dry and organic matter as well as of crude protein was higher (P<0.05) in SBM group. The total replacement of SBM with HILM in laying hens diet from 24 to 45weeks of age resulted in a higher caecal production of butyric acid while the enzymatic activities of brush border membrane were partially reduced.

Laying performance, blood profiles, nutrient digestibility and inner organs traits of hens fed an insect meal from Hermetia illucens larvae

Given probable the increment in the nutritional needs of both humans and animals, animal production will have increased dramatically by 2050. Insect meals could be an alternative protein source for livestock, and they would also be able to reduce the environmental problems related to intensive animal production system. The aim of this study was to evaluate productive performance, blood analysis, nutrient digestibility, and changes in the internal organs of laying hens fed Hermetia illucens larvae meal (HI) at two different levels in substitution (25 or 50%) of soybean meal (SBM). A total of 162 Hy-line Brown hens (sixteen weeks old) were equally divided into three experimental groups and fed isoprotein and isoenergetic diets. Egg weight, feed intake, and feed conversion rate were not affected by the soybean meal substitution at both inclusion levels of insect meal. Egg mass was positively affected by the insect meal diets, as was the lay percentage, although only at the lowest inclusion level. Dry matter, organic matter, and crude protein digestibility coefficients were lower for the HI50 diet, probably due to the negative effect of chitin. A reduction in serum cholesterol and triglycerides was observed in both insect-meal fed groups, while serum globulin level increased only at the highest level of insect meal inclusion, and, consequently, the albumin to globulin ratio decreased. Overall, a protein replacement of 25% with an insect meal from Hermetia illucens larvae in the diet of laying hens seems to be more suitable and closer to the optimal level.

Effect of the housing system (free-range vs. open air cages) on growth performance, carcass and meat quality and antioxidant capacity of rabbits

Growth performances and meat quality of free-range or cage raised rabbits were compared in 36 male animals. Rabbits were raised in free-range areas (2000 cm2/head) or in open-air cages (800 cm2/head) from weaning to 99 days old. Daily weight gain and final live weight were higher (P < 0.05) for the rabbits raised in cages which presented a more favourable feed conversion ratio (P < 0.05) than in the free-range group. The average feed intake, liver and empty gastro-intestinal tract weights were higher (P < 0.05) in the free-range group, while the interscapular fat percentage was higher (P < 0.05) in the caged rabbits. Loins of free-range rabbits had higher amount of PUFA n-6 in neutral lipids (P < 0.05) whereas their polar lipids were richer in PUFA n-6 and n-3 than in those of the cage group. Muscular fat of free-raised rabbits was found to be less susceptible to be oxidized, having a higher antioxidant capacity than the caged group.