Sabine Zollner

Preclinical efficacy and safety of rVIII-SingleChain (CSL627), a novel recombinant single-chain factor VIII

INTRODUCTION The preclinical efficacy and safety of rVIII-SingleChain (CSL627), a novel recombinant single-chain factor VIII, was assessed in a series of animal studies. MATERIALS AND METHODS In the tail-clip bleeding model, hemophilia A mice were injected with escalating doses (1-150 IU/kg) of rVIII-SingleChain, B-domain deleted (BDD) rFVIII (ReFacto AF(®)), or full-length rFVIII products (Advate(®), Helixate(®)). Total blood loss and the percentage of animals in which hemostasis occurred were assessed in this observer-blinded, randomized study. In a second non-randomized study in hemophilia A mice, thromboelastographic analysis, thrombin generation, and activated partial thromboplastin time assays were performed. General safety and toxicity were assessed in three animal species, including determination of the prothrombotic potential of rVIII-SingleChain in a rabbit venous thrombosis model. RESULTS Under acute bleeding conditions, the effect of rVIII-SingleChain on total blood loss and hemostasis was indistinguishable from BDD and full-length rFVIII. rVIII-SingleChain and full-length rFVIII (both 20 IU/kg) corrected thromboelastographic parameters, activated partial thromboplastin time, and thrombin generation to a similar degree in hemophilia A mice. In a thrombosis model, the effect of rVIII-SingleChain on thrombus incidence was non-significant and comparable to BDD rFVIII at doses up to 500 IU/kg. Treatment with rVIII-SingleChain did not cause anaphylactic reaction or local intolerance in safety and toxicity studies, and demonstrated an excellent overall safety profile. CONCLUSIONS rVIII-SingleChain showed convincing hemostatic efficacy and excellent tolerability in animal studies, warranting continued investigation in human Phase I/III trials (AFFINITY).

Pharmacological characteristics of a novel, recombinant fusion protein linking coagulation factor VIIa with albumin (rVIIa‐FP)

Recombinant factor VIIa (rFVIIa) is approved for use in controlling bleeding episodes in people with hemophilia who have developed inhibitors to replacement therapy. Due to its short half‐life (t½), frequent injections are required, limiting its use as a prophylactic treatment. A novel, recombinant fusion protein linking coagulation factor VIIa with albumin (rVIIa‐FP) has been developed to extend the t½ of rFVIIa.

Improved kinetics of rIX‐FP, a recombinant fusion protein linking factor IX with albumin, in cynomolgus monkeys and hemophilia B dogs

Summary.  Background:  Prophylaxis of hemophilia B, at present, requires multiple infusions of human factor (F)IX concentrates per week. A FIX molecule with a prolonged half‐life has the potential to greatly improve the convenience of, and adherence to, prophylaxis.

Non-clinical pharmacokinetics and pharmacodynamics of rVIII-SingleChain, a novel recombinant single-chain factor VIII

INTRODUCTION rVIII-SingleChain (CSL627), a novel recombinant coagulation factor VIII (FVIII), is under investigation in a phase I/III clinical programme (AFFINITY) for the treatment of haemophilia A. Non-clinical studies were conducted to investigate the pharmacokinetic/pharmacodynamic profile of rVIII-SingleChain in comparison with full-length recombinant FVIII. MATERIALS AND METHODS Binding affinity of rVIII-SingleChain for von Willebrand factor was investigated by surface plasmon resonance analysis. The pharmacokinetic profile of rVIII-SingleChain was compared with a marketed full-length recombinant FVIII concentrate (Advate(®)) in haemophilia A mice, von Willebrand factor knock-out mice, Crl:CD (SD) rats, rabbits and cynomolgus monkeys. Systemic FVIII activity or antigen levels were recorded. Procoagulant activity was measured in an FeCl3-induced arterial occlusion model and by recording thrombin generation activity (ex vivo) after administration of 200-250 IU/kg rVIII-SingleChain or full-length FVIII to haemophilia A mice. RESULTS rVIII-SingleChain displayed a high affinity for von Willebrand factor (KD=44 pM vs. 139 pM for full-length recombinant FVIII). In all animal species tested, rVIII-SingleChain had more favourable pharmacokinetic properties than full-length recombinant FVIII: clearance was decreased and area under the curve and terminal half-life were enhanced vs. full-length recombinant FVIII, while in vivo recovery and volume of distribution were equivalent. rVIII-SingleChain showed a prolonged thrombin generation potential and prolonged procoagulant activity vs. full-length recombinant FVIII in an FeCl3-induced arterial occlusion model. CONCLUSIONS rVIII-SingleChain had a higher affinity for von Willebrand factor than full-length recombinant FVIII and displayed favourable pharmacokinetic/pharmacodynamic properties in non-clinical models.

Biodistribution of the recombinant fusion protein linking coagulation factor IX with albumin (rIX-FP) in rats

INTRODUCTION The recombinant fusion protein linking coagulation factor IX with albumin (rIX-FP) is undergoing clinical trials for prophylaxis and on-demand treatment of haemophilia B patients. The aim of this study was to investigate the pharmacokinetics, whole-body and knee joint distribution of rIX-FP following intravenous administration to rats, compared with a marketed, non-fused rFIX and recombinant human albumin. MATERIAL AND METHODS [(3)H]-rIX-FP, [(3)H]-rFIX or [(3)H]-albumin were administered to rats followed by quantitative whole-body autoradiography over 24 or 240 hours, and the tissue distribution as well as elimination of radioactivity were measured. RESULTS Elimination of all radioactivity derived from the three proteins was shown to occur primarily via the urine. The tissue distribution of [(3)H]-rIX-FP and [(3)H]-rFIX (but not of [(3)H]-albumin) was comparable, both penetrating predominantly into bone, and well-perfused tissues, suggesting that the rIX moiety determines the distribution pattern of rIX-FP, while the albumin moity is responsible for the prolonged plasma and tissue retention. Detailed knee-joint analysis indicated rapid presence of [(3)H]-rIX-FP and [(3)H]-rFIX in synovial and mineralised bone tissue, mostly localised to the zone of calcified cartilage. Longest retention times were observed in the bone marrow and the endosteum of long bones. Intriguingly, [(3)H]-rIX-FP- and [(3)H]-albumin-derived radioactive signals were detectable up to 240 hours, while [(3)H]-rFIX-derived radioactivity rapidly declined after 1hour post-dosing correlating to the extended plasma half-life of [(3)H]-rIX-FP. CONCLUSION The prolonged plasma and tissue retention of rIX-FP achieved by albumin fusion may allow a reduction in dosing frequency leading to increased therapeutic compliance and convenience.

Recombinant fusion protein linking factor VIIa with albumin (rVIIa-FP): Tissue distribution in rats.

INTRODUCTION A novel fusion protein linking coagulation factor VIIa with albumin (rVIIa-FP) is currently undergoing clinical investigations. OBJECTIVE This study was conducted to examine the biodistribution of rVIIa-FP in comparison to recombinant factor VIIa (rFVIIa). MATERIALS AND METHODS [(3)H]-rVIIa-FP (10mgkg(-1)) or [(3)H]-rFVIIa (1.6mgkg(-1)) were administered intravenously to rats, followed by quantitative whole-body and knee joint autoradiography for 24 ([(3)H]-rFVIIa) or 240 ([(3)H]-rVIIa-FP) hours post-dose. Pharmacokinetic and excretion balance analyses were performed. RESULTS In contrast to [(3)H]-albumin, the tissue distributions of [(3)H]-rVIIa-FP and [(3)H]-rFVIIa were similar. Within the knee, both were rapidly present within synovial and mineralized regions. Importantly, rVIIa-FP- and albumin-derived radioactivity were detectable up to 72-120hours, whereas [(3)H]-rFVIIa signals were already close to detection limits at 24hours. The longest rVIIa-FP retention times were observed in bone marrow and endosteum, in which the retention times were up to 5 times longer for rVIIa-FP compared with rFVIIa. Up to 8hours post-dose, 100% of radioactivity was assigned to unchanged [(3)H]-rVIIa-FP. Elimination of both proteins occurred primarily via the urine. CONCLUSIONS The data suggest that the FVIIa moiety is directing rVIIa-FPs tissue distribution while the albumin moiety is responsible for the prolonged tissue retention. Importantly, rVIIa-FP is highly concentrated and retained over a long period in the growth plate of the knee joint-a vulnerable site in haemophilia patients. Overall, these improved tissue distribution characteristics of rVIIa-FP may enhance compliance and allow a more convenient dosing frequency.

Utility of a high VWF: FVIII ratio in preventing FVIII accumulation: a study in VWF-deficient mice.

Treatment of von Willebrand disease typically requires multiple infusions of von Willebrand factor (VWF)/factor VIII (FVIII) concentrate. Accumulation of FVIII is a clinical concern due to potential risk for thromboembolism. This study sought to determine whether VWF/FVIII concentrate of high VWF:FVIII ratio can prevent FVIII accumulation. VWF-deficient knockout mice received four 150 IU/kg VWF:ristocetin cofactor (RCo) infusions at 3-h intervals, with VWF/FVIII concentrates of a high (Haemate P/Humate-P) or low (Wilate) VWF:FVIII ratio. After each infusion, trough FVIII and VWF levels in plasma were determined. Separately, pharmacokinetic analysis was performed after single 250-IU/kg VWF:RCo infusions of each concentrate. Over the course of the four infusions, trough FVIII increased significantly in the group receiving Wilate (P < 0.001), but not Haemate P/Humate P (P = 0.058). After the first infusion, mean trough FVIII level in the Wilate group (31.7 IU/dl) was greater by 82% (P = 0.017) than that in the Haemate P/Humate P group (17.4 IU/dl). After the final infusion, mean trough FVIII of animals receiving Wilate (55.1 IU/dl) continued to exceed that of Haemate P/Humate P recipients (30.2 IU/dl) significantly (P < 0.001). Trough VWF levels were similar in the two groups. The VWF pharmacokinetics of the two concentrates coincided closely; however, the FVIII peak concentration and area under the curve were approximately twice as great in the mice treated with Wilate. In a murine model of severe von Willebrand disease, a VWF/FVIII concentrate with a high VWF:FVIII ratio prevented persistent exposure to elevated trough FVIII levels.