Stella Maris Chiacchiera

Mycoflora and incidence of aflatoxin B1, zearalenone and deoxynivalenol in poultry feeds in Argentina

In Argentina, there is rather little information about the natural occurrence of mycotoxins in feedstuffs. The aim of this work was to determine the fungal flora and natural incidence of aflatoxin B1 (AFB1), zearalenone (ZEA) and deoxynivalenol (DON) in poultry feeds from 5 factories of Río Cuarto, Córdoba. Three hundred samples were taken from May 1995 to May 1996. Fungal counts of poultry feeds ranged 104 to 106 CFU g-1. The lowest counts were obtained on the first months from the sampling (May to September 1995) with mean values significantly different from those found at the last of the sampling (October 1995 to April 1996). The most prevalent species isolated of poultry feed samples belonged to the genera Penicillium that was present in 98% of the samples, Fusarium (87%) and Aspergillus (52%). Fusarium species isolated were: F moniliforme in 73% of the samples, F subglutinans (35%), F graminearum (20%) and within Aspergillus species: A. parasiticus (33%) and A. flavus (8%) were identified. In poultry feeds aflatoxin B1 (AFB1) was the most significant mycotoxin with levels ranging from 17 to 197 ng/g. For deoxynivalenol (DON) the levels ranged from 240 to 410 ng/g. Only three out of 300 samples were contaminated with zearalenone (ZEA) in concentrations of 30, 120 and 280 ng/g. These are preliminary data on this subject in our region.

Occurrence of ochratoxin A and ochratoxigenic mycoflora in corn and corn based foods and feeds in some South American countries.

Cereals and cereal- derived products constitute the base of human and animal feeding in South American countries. This review attempts to give an overview of the ochratoxin A (OTA) occurrence and potential sources of OTA contamination in those products. The environmental conditions as humidity and temperature in the colonization of the substrates by Aspergillus section Nigri isolated from corn kernels were also discussed. The available information on the ochratoxigenic mycoflora and OTA presence in corn, corn based food and feed is limited. Only few surveys have been carried out in Argentina, Ecuador and Brazil; which showed that Aspergillus niger aggregate and A. ochraceus species would be the main source of OTA. It’s possible to emphasize that, the species A. carbonarius has not been isolated from these substrates and Penicillium verrucosum was isolated only from pig feeds of Argentinean samples in low percentage. Studies about the ecophysiology of ochratoxigenic fungi and OTA occurrence are in progress in Latin America to reduce the impact of this toxin in the food chain.

Enumeration and identification of Aspergillus group and Penicillium species in poultry feeds from Argentina

A total of 180 samples of poultry feeds were collected during 1996 and 1997 from different factories in the south of the province of Córdoba-Argentina. They were examined for the occurrence of Penicillium spp. and Aspergillus group species. Likewise, the capacity to produce aflatoxins by the Aspergillus section flavi group was determined. The predominant species of Aspergillus were A. flavus and A. parasiticus. For Penicillium spp., P. brevicompactum, P. purpurogenum and P. oxalicum were identified. Less frequently isolated were A. candidus, A. fumigatus, A. niger, A. orizae, A. parvulus, A. tamarii, A. terreus, and P. expansum, P. funiculosum, P. minioluteum, P. pinophylum, P. restrictum, P. variabile and others. The mean value counts ranged from 1 × 103 to 9.5 × 104 CFU/g for the Aspergillus spp. and from 1.2 × 103 to 2.5 × 105 CFU/g for the Penicillium spp. When cultured on autoclaved rice kernels for 1 week in the dark at 25°C, mycotoxin production by strains of A. flavus was as follows: 21 of the 45 assayed strains (47%) produced aflatoxins. From them, 24% of the isolates produced AFB1 and AFB2 with levels from 181 to 14 545 and 6 to 3640 μg/kg respectively. Only 10 strains produced AFB1 with levels from 10 to 920 μg/kg. Fifty percent of the A. parasiticus strain was toxicogenic; six aflatoxicogenic profiles were identified. Only 10% of the strains produced all of the aflatoxins. These results showed that a potential exists for the production of mycotoxins by the Aspergillus section flavi and the Penicillium spp. They also suggested an association of mycotoxicosis with poultry feeds in Argentina.

Natural occurrence of Fusarium species and fumonisin-production by toxigenic strains isolated from poultry feeds in Argentina

Fusarium species and fumonisin production by toxigenic strains were investigated. During 1996–1998, 158 samples of poultry feeds were collected from a factory located in the department of Río Cuarto Córdoba province, Argentina. The most common species of Fusarium were F. moniliforme (60.7%) and F. nygamai (35.4%) followed by F. semitectum, F. subglutinans, F. proliferatum, F. dlamini, F. solani, F. oxysporum and F. napiforme. Fungal counts ranged from 1 × 103 to 8 × 105 CFU/g with mean values from 1.5 × 103 to 2.3 × 105 CFU/g. The highest counts were for F. dlamini, F. subglutinans, F. moniliforme and F. nygamai. Strains of F. moniliforme, F. nygamai, and F. proliferatum were screened for their potential to produce fumonisin B1 (FB1), fumonisin B2 (FB2) and fumonisin B3 (FB3) in corn grain. The samples were analysed using a modified high performance liquid chromatography method. The strains assayed, 43 strains, produced three fumonisins. There was a high degree of variability in the quantities of FB1, FB2, and FB3 produced. The toxin produced in highest levels by the majority of the strains was FB1. The range of concentration varied from 5.4 to 3,991, 1.01 to 189 and 0.4 to 765 ppm per gram of corn for FB1, FB2 and FB3 respectively. The toxigenic pattern of strains was normal, although two strains of F. moniliforme produced exceptionally high concentrations of FB3 and minor concentrations of FB2 and FB1. This is the first report from Argentina on Fusarium species in poultry feeds and fumonisin production by these strains.

Occurrence of Fusarium spp. and Fumonisin in Durum Wheat Grains

A survey was carried out to determine Fusarium species and fumonisin contamination in 55 durum wheat (Triticum turgidum L. var. durum) samples collected during two harvest seasons (2007 and 2008) using HPLC and further LC-MS/MS confirmation. All samples showed Fusarium contamination with infection levels ranging from 8 to 66%, F. proliferatum being the species most frequently isolated during 2007 and the second most frequently isolated one during the 2008 harvest season, respectively. Natural contamination with fumonisins was found in both harvest seasons. In 2007, 97% of the samples showed total fumonisin (FB(1) + FB(2)) levels ranging from 10.5 to 1245.7 ng/g, while very low levels of fumonisins were detected in samples collected during 2008. These results could be explained by differences in the amount of rainfall during both periods evaluated. A selected number (n = 48) of F. proliferatum isolates showed fumonisin production capability on autoclaved rice. This is the first report of the presence of natural fumonisins in durum wheat grains.

Fungi and Mycotoxins in Feed Intended for Sows at Different Reproductive Stages in Argentina

The aim of this study was to evaluate fungi and contamination levels of aflatoxin B1, ochratoxin A, fumonisin B1, and zearalenone in raw materials and finished feed intended for sows at different reproductive stages. Total fungi, Aspergillus, Penicillium, and Fusarium species occurrence, were examined. Aspergillus flavus, A. niger aggregate spp., and F. verticillioides were the prevalent species. Fungal counts exceeded the levels proposed as feed hygienic quality limits (1 × 104 colony forming units) at all reproductive stages. Aflatoxin B1, ochratoxin A, fumonisin B1, and zearalenone were detected by high-pressure liquid chromatography. Aflatoxin levels in 80% samples of finished sow feeds were over the permitted levels of 0.02 μg g−1 (mean 228.2 ± 95 μg Kg−1). Fumonisin B1 was detected in all tested raw materials at levels that varied from 50.3 to 1137.64 μg Kg−1 and finished feed samples at levels that ranged from 99.8 to 512.4 μg Kg−1. Aflatoxin B1, zearalenone, and ochratoxin A were not detected in raw materials. All finished feeds were negative for zearalenone contamination whereas all nonpregnant gilt samples were contaminated with low OTA levels (mean 0.259 ± 0.123). This fact requires periodic monitoring to prevent the occurrence of mycotoxicosis in animal production, to reduce the economic losses, and to minimize hazards to human health.

Presence of Multiple Mycotoxins and Other Fungal Metabolites in Native Grasses from a Wetland Ecosystem in Argentina Intended for Grazing Cattle

The aim of this study was to evaluate the occurrence of several fungal metabolites, including mycotoxins in natural grasses (Poaceae) intended for grazing cattle. A total number of 72 and 77 different metabolites were detected on 106 and 69 grass samples collected during 2011 and 2014, respectively. A total of 60 metabolites were found across both years. Among the few mycotoxins considered toxic for ruminants, no samples of natural grasses were contaminated with aflatoxins, ochratoxin A, ergot alkaloids, and gliotoxin, among others. However, we were able to detect important metabolites (toxic to ruminants) such as type A trichothecenes, mainly T-2 toxin and HT-2 toxin (up to 5000 µg/kg each), and zearalenone (up to 2000 µg/kg), all at very high frequencies and levels. Other fungal metabolites that were found to be prevalent were other Fusarium metabolites like beauvericin, equisetin and aurofusarin, metabolites produced by Alternaria spp., sterigmatocystin and its precursors and anthrachinone derivatives. It is important to point out that the profile of common metabolites was shared during both years of sampling, and also that the occurrence of important metabolites is not a sporadic event. Considering that this area of temperate grassland is used for grazing cattle all year long due to the richness in palatable grasses (Poaceae), the present work represents a starting point for further studies on the occurrence of multi-mycotoxins in natural grasses in order to have a complete picture of the extent of cattle exposure. Also, the present study shows that the presence of zeranol in urine of beef cattle may not be a consequence of illegal use of this banned substance, but the product of the natural occurrence of zearalenone and α-zearalenol in natural grasses intended for cattle feeding.

Survey of Aspergillus section Flavi presence in agricultural soils and effect of glyphosate on nontoxigenic A. flavus growth on soil‐based medium

To evaluate the cultivable mycobiota from agricultural soils exposed to pesticides, the aflatoxigenic capacity of Aspergillus section Flavi strains and the effect of glyphosate on lag phase and growth rates of native nontoxigenic Aspergillus flavus under different water potential (MPa) conditions on soil‐based medium.

Natural co-occurrence of fungi and mycotoxins in poultry feeds from Entre Ríos, Argentina

A total of 120 pelleted poultry feed samples from Entre Ríos Province, Argentina, were evaluated. The aims were to investigate (1) the presence of relevant toxigenic fungi, as well as to determine the ability to produce aflatoxins (AFs) by Aspergillus section Flavi isolated strains; and (2) the natural co-occurrence of AFs, fumonisins (FBs), gliotoxin, diacetoxyscirpenol (DAS), HT-2 and T-2 toxin by high-performance liquid chromatography–tandem mass spectrometry (HPLC-MS/MS). Total fungal counts were below the established value (1 × 104 CFU g−1). Aspergillus flavus and A. parasiticus were the only aflatoxigenic species isolated. Co-occurrence of fumonisin B1 (FB1), HT-2 and T-2 toxin was detected in 100% of the feeds, with mean levels from 4502 to 5813; 6.7 to 21.6 and 19.6 to 30.3 µg kg−1, respectively. A large number of starter samples were co-contaminated with aflatoxin B1 (AFB1), FB1, HT-2 and T-2 toxins. Gliotoxin and DAS were not found in this survey.

Influence of the pesticides glyphosate, chlorpyrifos and atrazine on growth parameters of nonochratoxigenic Aspergillus section Nigri strains isolated from agricultural soils

This investigation was undertake to determine the effect of glyphosate, chlorpyrifos and atrazine on the lag phase and growth rate of nonochratoxigenic A. niger aggregate strains growing on soil extract medium at −0.70, −2.78 and −7.06 MPa. Under certain conditions, the glyphosate concentrations used significantly increased micelial growth as compared to control. An increase of about 30% was observed for strain AN 251 using 5 and 20 mg L−1 of glyphosate at −2.78 MPa. The strains behaved differently in the presence of the insecticide chlorpyrifos. A significant decrease in growth rate, compared to control, was observed for all strains except AN 251 at −2.78 MPa with 5 mg L−1. This strain showed a significant increase in growth rate. With regard to atrazine, significant differences were observed only under some conditions compared to control. An increase in growth rate was observed for strain AN 251 at −2.78 MPa with 5 and 10 mg L−1 of atrazine. By comparison, a reduction of 25% in growth rate was observed at −7.06 MPa and higher atrazine concentrations. This study shows that glyphosate, chlorpyrifos and atrazine affect the growth parameters of nonochratoxigenic A. niger aggregate strains under in vitro conditions.