Stephanie Bringer

Effect of oxygen on the metabolism of Zymomonas mobilis

The specific growth rate of the ethanol producing bacterium Zymomonas mobilis was 25–40% lower in the presence of oxygen than under anaerobic conditions, provided the cultures were supplied with a low substrate concentration (20 g glucose/l). However, the molar growth yield of these cultures was not influenced by oxygen. With washed cell suspensions, an oxygen consumption could be initiated by the addition of either glucose, fructose, or ethanol. Cell extracts catalyzed the oxidation of NADH with oxygen at a molar ratio of 2:1. Further experiments showed that this NADH oxidase is located in the cell membrane. The specific oxygen consumption rates of cell suspensions correlated with the intracellular NADH oxidizing activities; both levels decreased with increasing concentrations of the fermentation end-product ethanol. The addition of 5 mM NaCN completely inhibited both the intracellular oxygen reduction and also the oxygen consumption of whole cells. Both catalase and superoxide dismutase were present even in anaerobically grown cells. Aeration seemed to have little effect on the level of catalase, but the superoxide dismutase activity was 5-fold higher in cells grown aerobically. Under aerobic conditions considerable amounts of acetaldehyde and acetic acid were formed in addition to the normal fermentation products, ethanol and carbon dioxide.

Influence of ethanol on the hopanoid content and the fatty acid pattern in batch and continuous cultures of Zymomonas mobilis

By thin layer chromatographic, gas-liquid chromatographic, and mass spectrometric methods 1,2,3,4-tetrahydroxypentane-29-hopane (THBH) was shown to occur in Zymomonas mobilis. This compound contributed up to 20% to the total lipids.The fatty acid pattern and the content of hopanoids (hopene, hopanol, and THBH) were determined in batch and continuous cultures. In late exponential cells from batch cultures the relative amount of palmitic acid was increased partially at the expense of cis-vaccenic acid, when the initial glucose concentrations were increased. In a batch culture, THBH reached a maximum value in the early exponential growth phase.In an anaerobic continuous culture with a low glucose feed concentration, the THBH content and the relative amount of cis-vaccenic acid were low. The contribution of both compounds increased strongly with increasing glucose feed concentrations (i.e. at higher steady-state ethanol concentrations). The same result was found with aerobic continuous cultures which produced significant amounts of acetaldehyde and acetic acid, in addition to ethanol and carbon dioxide.It was concluded that stability and permeability of the cytoplasmic membrane of the ethanol producing bacterium Z. mobilis was regulated by variations in the distribution of hopanoids and fatty acids.

SoxR as a Single-Cell Biosensor for NADPH-Consuming Enzymes in Escherichia coli

An ultra-high-throughput screening system for NADPH-dependent enzymes, such as stereospecific alcohol dehydrogenases, was established. It is based on the [2Fe-2S] cluster-containing transcriptional regulator SoxR of Escherichia coli that activates expression of soxS in the oxidized but not in the reduced state of the cluster. As SoxR is kept in its reduced state by NADPH-dependent reductases, an increased NADPH demand of the cell counteracts SoxR reduction and increases soxS expression. We have taken advantage of these properties by placing the eyfp gene under the control of the soxS promoter and analyzed the response of E. coli cells expressing an NADPH-dependent alcohol dehydrogenase from Lactobacillus brevis (LbAdh), which reduces methyl acetoacetate to (R)-methyl 3-hydroxybutyrate. Under suitable conditions, the specific fluorescence of the cells correlated with the substrate concentration added and with LbAdh enzyme activity, supporting the NADPH responsiveness of the sensor. These properties enabled sorting of single cells harboring wild-type LbAdh from those with lowered or without LbAdh activity by fluorescence-activated cell sorting (FACS). In a proof-of-principle application, the system was used successfully to screen a mutant LbAdh library for variants showing improved activity with the substrate 4-methyl-2-pentanone.

Metabolic Engineering of Gluconobacter oxydans for Improved Growth Rate and Growth Yield on Glucose by Elimination of Gluconate Formation

ABSTRACT Gluconobacter oxydans N44-1, an obligatory aerobic acetic acid bacterium, oxidizes glucose primarily in the periplasm to the end products 2-ketogluconate and 2,5-diketogluconate, with intermediate formation of gluconate. Only a minor part of the glucose (less than 10%) is metabolized in the cytoplasm after conversion to gluconate or after phosphorylation to glucose-6-phosphate via the only functional catabolic routes, the pentose phosphate pathway and the Entner-Doudoroff pathway. This unusual method of glucose metabolism results in a low growth yield. In order to improve it, we constructed mutants of strain N44-1 in which the gene encoding the membrane-bound glucose dehydrogenase was inactivated either alone or together with the gene encoding the cytoplasmic glucose dehydrogenase. The growth and product formation from glucose of the resulting strains, N44-1 mgdH::kan and N44-1 ΔmgdH sgdH::kan, were analyzed. Both mutant strains completely consumed the glucose but produced neither gluconate nor the secondary products 2-ketogluconate and 2,5-diketogluconate. Instead, carbon dioxide formation of the mutants increased by a factor of 4 (N44-1 mgdH::kan) or 5.5 (N44-1 ΔmgdH sgdH::kan), and significant amounts of acetate were produced, presumably by the activities of pyruvate decarboxylase and acetaldehyde dehydrogenase. Most importantly, the growth yields of the two mutants increased by 110% (N44-1 mgdH::kan) and 271% (N44-1 ΔmgdH sgdH::kan). In addition, the growth rates improved by 39% (N44-1 mgdH::kan) and 78% (N44-1 ΔmgdH sgdH::kan), respectively, compared to the parental strain. These results show that the conversion of glucose to gluconate and ketogluconates has a strong negative impact on the growth of G. oxydans.

Combined fluxomics and transcriptomics analysis of glucose catabolism via a partially cyclic pentose phosphate pathway in Gluconobacter oxydans 621H.

ABSTRACT In this study, the distribution and regulation of periplasmic and cytoplasmic carbon fluxes in Gluconobacter oxydans 621H with glucose were studied by 13C-based metabolic flux analysis (13C-MFA) in combination with transcriptomics and enzyme assays. For 13C-MFA, cells were cultivated with specifically 13C-labeled glucose, and intracellular metabolites were analyzed for their labeling pattern by liquid chromatography-mass spectrometry (LC-MS). In growth phase I, 90% of the glucose was oxidized periplasmically to gluconate and partially further oxidized to 2-ketogluconate. Of the glucose taken up by the cells, 9% was phosphorylated to glucose 6-phosphate, whereas 91% was oxidized by cytoplasmic glucose dehydrogenase to gluconate. Additional gluconate was taken up into the cells by transport. Of the cytoplasmic gluconate, 70% was oxidized to 5-ketogluconate and 30% was phosphorylated to 6-phosphogluconate. In growth phase II, 87% of gluconate was oxidized to 2-ketogluconate in the periplasm and 13% was taken up by the cells and almost completely converted to 6-phosphogluconate. Since G. oxydans lacks phosphofructokinase, glucose 6-phosphate can be metabolized only via the oxidative pentose phosphate pathway (PPP) or the Entner-Doudoroff pathway (EDP). 13C-MFA showed that 6-phosphogluconate is catabolized primarily via the oxidative PPP in both phases I and II (62% and 93%) and demonstrated a cyclic carbon flux through the oxidative PPP. The transcriptome comparison revealed an increased expression of PPP genes in growth phase II, which was supported by enzyme activity measurements and correlated with the increased PPP flux in phase II. Moreover, genes possibly related to a general stress response displayed increased expression in growth phase II.

Fermentation of arabinose to ethanol by Sarcina ventriculi

SummaryIn the absence of oxygen, a strain of sarcina ventriculi, isolated from soil, could rapidly and completely ferment up to 20 g/l of arabinose. The principal products were ethanol, acetate, CO2 and H2. The yield of alcohol, up to 30% by weight of the sugar fermented, was not appreciably influenced by the pH of fermentation in the range 4–7. Sugar concentrations up to 100 g/l did not affect initial growth, but fermentation was incomplete at high sugar levels. This was probably due to the accumulation of end products other than ethanol, because the cells could grow in the presence of up to 25 g/l of added ethanol. Glucose, galactose and arabinose were sequentially utilized, in that order, when initially present as a mixed substrate. These sugars are major components of the hemicellulose from some agricultural residues. Practical implications for the general problem of pentose conversion to alcohol are discussed briefly.

Evidence for a key role of cytochrome bo3 oxidase in respiratory energy metabolism of Gluconobacter oxydans.

The obligatory aerobic acetic acid bacterium Gluconobacter oxydans oxidizes a variety of substrates in the periplasm by membrane-bound dehydrogenases, which transfer the reducing equivalents to ubiquinone. Two quinol oxidases, cytochrome bo3 and cytochrome bd, then catalyze transfer of the electrons from ubiquinol to molecular oxygen. In this study, mutants lacking either of these terminal oxidases were characterized. Deletion of the cydAB genes for cytochrome bd had no obvious influence on growth, whereas the lack of the cyoBACD genes for cytochrome bo3 severely reduced the growth rate and the cell yield. Using a respiration activity monitoring system and adjusting different levels of oxygen availability, hints of a low-oxygen affinity of cytochrome bd oxidase were obtained, which were supported by measurements of oxygen consumption in a respirometer. The H(+)/O ratio of the ΔcyoBACD mutant with mannitol as the substrate was 0.56 ± 0.11 and more than 50% lower than that of the reference strain (1.26 ± 0.06) and the ΔcydAB mutant (1.31 ± 0.16), indicating that cytochrome bo3 oxidase is the main component for proton extrusion via the respiratory chain. Plasmid-based overexpression of cyoBACD led to increased growth rates and growth yields, both in the wild type and the ΔcyoBACD mutant, suggesting that cytochrome bo3 might be a rate-limiting factor of the respiratory chain.

Mutational Analysis of the Pentose Phosphate and Entner-Doudoroff Pathways in Gluconobacter oxydans Reveals Improved Growth of a Δedd Δeda Mutant on Mannitol

ABSTRACT The obligatory aerobic acetic acid bacterium Gluconobacter oxydans 621H oxidizes sugars and sugar alcohols primarily in the periplasm, and only a small fraction is metabolized in the cytoplasm. The latter can occur either via the Entner-Doudoroff pathway (EDP) or via the pentose phosphate pathway (PPP). The Embden-Meyerhof pathway is nonfunctional, and a cyclic operation of the tricarboxylic acid cycle is prevented by the absence of succinate dehydrogenase. In this work, the cytoplasmic catabolism of fructose formed by oxidation of mannitol was analyzed with a Δgnd mutant lacking the oxidative PPP and a Δedd Δeda mutant devoid of the EDP. The growth characteristics of the two mutants under controlled conditions with mannitol as the carbon source and enzyme activities showed that the PPP is the main route for cytoplasmic fructose catabolism, whereas the EDP is dispensable and even unfavorable. The Δedd Δeda mutant (lacking 6-phosphogluconate dehydratase and 2-keto-3-deoxy-6-phosphogluconate aldolase) formed 24% more cell mass than the reference strain. In contrast, deletion of gnd (6-phosphogluconate dehydrogenase) severely inhibited growth and caused a strong selection pressure for secondary mutations inactivating glucose-6-phosphate dehydrogenase, thus preventing fructose catabolism via the EDP also. These Δgnd zwf* mutants (with a mutation in the zwf gene causing inactivation of the glucose-6-phosphate dehydrogenase) were almost totally disabled in fructose catabolism but still produced about 14% of the carbon dioxide of the reference strain, possibly by catabolizing substrates from the yeast extract. Overexpression of gnd in the reference strain improved biomass formation in a similar manner as deletion of edd and eda, further confirming the importance of the PPP for cytoplasmic fructose catabolism.

Influence of oxygen limitation, absence of the cytochrome bc1 complex and low pH on global gene expression in Gluconobacter oxydans 621H using DNA microarray technology

The genome-wide transcriptional responses of the strictly aerobic α-proteobacterium Gluconobacter oxydans 621H to oxygen limitation, to the absence of the cytochrome bc(1) complex, and to low pH were studied using DNA microarray analyses. Oxygen limitation caused expression changes of 486 genes, representing 20% of the chromosomal genes. Genes with an increased mRNA level included those for terminal oxidases, the cytochrome bc(1) complex, transhydrogenase, two alcohol dehydrogenases, heme biosynthesis, PTS proteins, proteins involved in cyclic diGMP synthesis and degradation, two sigma factors, flagella and chemotaxis proteins, several stress proteins, and a putative exporter protein. The downregulated genes comprised those for respiratory dehydrogenases, enzymes of central metabolism, PQQ biosynthesis, outer membrane receptors, Sec proteins, and proteins involved in transcription and translation. A ΔqrcABC mutant of G. oxydans showed a growth defect during cultivation on mannitol at pH 4 under oxygen saturation. Comparison of the transcriptomes of this mutant versus the wild type under these conditions revealed 51 differentially expressed genes. Interestingly, almost all of the 45 genes with increased expression in the ΔqrcABC mutant at pH 4 were also upregulated in the wild type grown at pH 6 under oxygen limitation. These results support an active role of the cytochrome bc(1) complex in G. oxydans respiration. The transcriptome comparison of G. oxydans wild type at pH 4 versus pH 6 in mannitol medium under oxygen-saturated conditions uncovered only 72 differentially expressed genes. The 35 upregulated genes included those for cytochrome bd oxidase, major polyol dehydrogenase, iron storage and oxidative stress proteins. Among the 37 downregulated genes were some encoding enzymes dealing with carbon dioxide, such as biotin carboxylase, biotin carboxyl carrier protein, and carboanhydrase. These results give first insights into global transcriptional responses of G. oxydans.

Improving d-mannitol productivity of Escherichia coli: impact of NAD, CO2 and expression of a putative sugar permease from Leuconostoc pseudomesenteroides.

The highly productive whole-cell biotransformation of D-fructose to D-mannitol with recombinant, resting cells of Escherichia coli BL21(DE3) requires the combined expression of mdh, fdh and glf which encode mannitol and formate dehydrogenases and a sugar facilitator, respectively. However, long-term stability of the system was restricted, possibly due to loss of the cofactor NAD, high concentrations of formate, formation of CO(2) affecting the internal pH of the cells, accumulation of high intracellular concentrations of D-mannitol, and export of D-mannitol. Downstream of the mdh gene of Leuconostoc pseudomesenteroides, we identified an open reading frame encoding for a putative mannitol permease. The gene was cloned and expressed in E. coli. Biochemical analyses revealed an activity as secondary carrier for D-fructose. Therefore, the carrier was named FupL and participation in D-mannitol transport was excluded. In biotransformation experiments, the productivity of D-mannitol formation obtained with the strain expressing the additional fupL gene was enhanced by 20%.