Sukanta Dhar

Development of n-type microcrystalline SiOx:H films and its application by innovative way to improve the performance of single junction µc-Si:H solar cell

Light trapping is one of the fundamental necessities of thin film based solar cell for its performance elevation. Back reflection of unused light of first pass is the key way to improve the light trapping phenomena. In this study we have reported the development of n-type hydrogenated microcrystalline silicon oxide (n-µc-SiO:H) layers of different characteristics. The deposition has been done by Plasma Enhanced Chemical Vapor Deposition (PECVD) technique. The detailed characterization of the films include the following: (1) electrical properties (2) optical properties like E04 (3) structural studies which include crystalline fraction by Raman spectroscopy and grain size by X-ray diffraction measurement, FTIR spectroscopy, AFM and TEM studies. n-µc-SiO:H layer has been introduced as the n-layer of single junction p–i–n structure µc-Si solar cells. By various techniques the optimum use of n-µc-SiO:H layer for enhancing the performance of µc-Si:H solar cells has been done. It has been found that by using suitable bilayer of two different n-µc-SiO:H layers, it is possible to increase the solar cell performances. The maximum efficiency obtained without any back reflector is 8.44% that is about 8.9% higher than that obtained by using n-µc-Si:H layer as n-layer in the solar cells.

Modeling and Analysis of Lifetime Curve of Amorphous Silicon/Crystalline Silicon Heterostructure Solar Cell

The modeling and analysis of recombination properties is one of the critical aspects in the design and development of high efficiency amorphous silicon (a-Si)/crystalline silicon (c-Si) heterostructure solar cell (SH-SC). In this paper, we have developed a recombination model pertinent for a-Si/c-Si SH-SC. Based on the model, an analytical expression for the relationship between effective carrier lifetime (τeff) and excess carrier concentration (An), commonly termed as lifetime curve, is derived and the results are validated with the experimental data. The results show that the inverse of τeff, after correcting for the contributions of Auger and radiative recombination in silicon, when plotted as a function of An, shows a linear characteristic, with each of the slope and the intercept, providing definitive details about the recombination processes occurring in the device.

Silicon heterojunction solar cells with novel fluorinated n-type nanocrystalline silicon oxide emitters on p-type crystalline silicon

A novel fluorinated phosphorus doped silicon oxide based nanocrystalline material have been used to prepare heterojunction solar cells on flat p-type crystalline silicon (c-Si) Czochralski (CZ) wafers. The n-type nc-SiO:F:H material were deposited by radio frequency plasma enhanced chemical vapor deposition. Deposited films were characterized in detail by using atomic force microscopy (AFM), high resolution transmission electron microscopy (HRTEM), Raman, fourier transform infrared spectroscopy (FTIR) and optoelectronics properties have been studied using temperature dependent conductivity measurement, Ellipsometry, UV–vis spectrum analysis etc. It is observed that the cell fabricated with fluorinated silicon oxide emitter showing higher initial efficiency (η = 15.64%, Jsc = 32.10 mA/cm2, Voc = 0.630 V, FF = 0.77) for 1 cm2 cell area compare to conventional n-a-Si:H emitter (14.73%) on flat c-Si wafer. These results indicate that n type nc-SiO:F:H material is a promising candidate for heterojunction solar cell on p-type crystalline wafers. The high Jsc value is associated with excellent quantum efficiencies at short wavelengths (<500 nm).