Suyong Lee

Effect of Nutrim Oat Bran and Flaxseed on Rheological Properties of Cakes

ABSTRACT Cake shortening contents were replaced with Nutrim oat bran (OB) and flaxseed powder, and the effects of these substitutions on the physical and rheological properties of cakes were investigated. Cakes with shortening replaced up to 40% by weight possessed a volume similar to that of the control cake produced with shortening. Replacement using Nutrim OB and flaxseed powder revealed significant color changes in both the cake crust and crumb. At high levels of substitution, the cake crust became lighter, while the crumb darkened. At >40% by weight substitution with either Nutrim OB or flaxseed, the cakes displayed increased hardness; however, cohesiveness and springiness increased gradually with increasing substitution. Increased substitution with Nutrim OB caused an increase in the measured shear viscosity and oscillatory storage and loss moduli of the cakes. Increased substitution with flaxseed caused decreases in these rheological parameters. Additional rheological experiments were performed to ...

Environmentally friendly preparation of pectins from agricultural byproducts and their structural/rheological characterization

Apple pomace which is the main waste of fruit juice industry was utilized to extract pectins in an environmentally friendly way, which was then compared with chemically-extracted pectins. The water-based extraction with combined physical and enzymatic treatments produced pectins with 693.2 mg g(-1) galacturonic acid and 4.6% yield, which were less than those of chemically-extracted pectins. Chemically-extracted pectins exhibited lower degree of esterification (58%) than the pectin samples obtained by physical/enzymatic treatments (69%), which were also confirmed by FT-IR analysis. When subjected to steady-shear rheological conditions, both pectin solutions were shown to have shear-thinning properties. However, decreased viscosity was observed in the pectins extracted by combined physical/enzymatic methods which could be mainly attributed to the presence of more methyl esters, thus limiting polymer chain interactions. Moreover, the pectins which were extracted by combined physical/enzymatic treatments, showed less elastic properties under high shear rate conditions, compared to the chemically-extracted pectins.

Effect of Shortening Replacement with Oatrim on the Physical and Rheological Properties of Cakes

ABSTRACT Oatrim (oat β-glucan amylodextrins) was evaluated as a fat substitute in a cake system. The physical and rheological properties of cakes containing shortening replaced with 20, 40, and 60% by weight of Oatrim were characterized. The increase in the specific gravity of the cakes and the decrease in the viscosity as more shortening was replaced with Oatrim were correlated with the change in the cake volume. The number of air bubbles present in the cake batters varied significantly; however, the size of the observed bubbles did not change. The cakes containing more Oatrim displayed a higher starch gelatinization temperature due to the amylodextrins in the Oatrim. The dynamic rheological properties of the cakes were investigated during baking and correlated with the differential scanning calorimetry results. The oscillatory shear storage moduli decreased upon initial heating, then increased due to starch gelatinization, and finally reached a plateau value that varied based on the sample composition. ...

Utilization of pectin-enriched materials from apple pomace as a fat replacer in a model food system

Water soluble pectin-enriched materials (PEMs) from apple pomace, were evaluated as a fat replacer in a model food system. When PEM solutions were subjected to steady-shear measurements, shear-thinning behavior was observed. The flow behaviors could be described by the Cross model (R(2)=0.99), and temperature effects were investigated by the Arrhenius equation. The addition of PEMs significantly increased the pasting parameters of wheat flour as measured by a starch pasting rheometer. Gelatinization temperature and enthalpy increased with increasing PEM concentrations. When PEMs were incorporated into cookie formulations in place of shortening (semisolid fat generally used in baked foods) up to 30% by the weight of shortening, the cookie spread diameter was reduced while an increase in the moisture content was observed. Moreover, replacement of shortening with PEMs contributed to a more tender texture and lighter surface color.

Purification and identification of adipogenesis inhibitory peptide from black soybean protein hydrolysate

Adipogenesis inhibitory peptide was isolated and identified from black soybean (Rhynchosia volubilis Lour.) hydrolysate. An adipogenesis inhibitor was purified using consecutive methods including: ultrafiltration (MWCO; 3 and 10kDa), gel filtration chromatography (Superdex Peptide 10/300 GL column), and reverse-phase high-performance liquid chromatography (microBondapak C(18) column). Also, the adipogenesis inhibition effect of the purified peptide was measured by observation of droplet of 3T3-L1 adipocyte by Oil Red O staining in the highest active fraction in each step. The peptide was shown to inhibit the differentiation of the 3T3-L1 pre-adipocyte, which was confirmed by morphological study. The adipogenesis inhibitory peptide was purified 71.43-fold from black soybean hydrolysate throughout a five-step purification procedure. The adipogenesis inhibitor was identified to be a tripeptide, Ile-Gln-Asn, having an IC(50) value of 0.014 mg protein/ml. Furthermore, the synthetic tripeptide (Ile-Gln-Asn) exhibited the similar adipogenesis effects to the purified peptide. Thus, these results showed the potential anti-obesity effect of the purified peptide through control of adiposity.

Physicochemical and hypocholesterolemic characterization of oxidized oat β-glucan.

2,2,6,6-Tetramethyl-1-piperidine oxoammonium ion (TEMPO)-mediated oxidation was applied to oat beta-glucans, and the physicochemical and hypocholesterolemic properties of the resulting derivatives were investigated. The (13)C NMR spectra revealed that C6 primary alcohol groups were selectively oxidized into carboxyl groups. The oxidized derivatives exhibited enhanced water solubility and improved in vitro bile acid binding capacity. When hypercholesterolemic rats were fed diets containing the oxidized beta-glucan, the levels of triglyceride, total cholesterol, LDL-C, and VLDL-C in the rats significantly decreased (p < 0.05), consequently improving the serum lipid profiles. Dietary supplementation with beta-glucans reduced also the total cholesterol level in liver. Furthermore, more fecal eliminations of total cholesterol and triglyceride were observed, which were favorably correlated to their reduced levels in the serum and liver. As a result, oxidized oat beta-glucan exhibits potential use as an active cholesterol-lowering ingredient.

Quality improvement of rice noodle restructured with rice protein isolate and transglutaminase

In an effort to improve the properties of rice dough and quality of gluten-free rice noodle, transglutaminase (TGase) and rice protein isolate (RPI) were applied to rice noodle making process. The storage and loss moduli of rice dough increased by TGase treatment, whereas they decreased with RPI supplementation. The combined treatment of RPI+TGase on rice dough fully recovered the reduced moduli caused by RPI only supplementation to control level, and increased most of viscosity parameters of rice noodle in RVA analysis. This additional treatment of TGase also increased development time, and maximum and peak torques of RPI-supplemented rice dough in Mixolab® analysis. Cooking loss and water turbidity of rice noodle decreased by 54.8% and 66.6%, respectively, after TGase+RPI treatment. Scanning electron micrographs showed cracked noodle surface became smoothed with TGase treatment, which was more obvious with RPI+TGase treatment. These results suggest RPI+TGase treatment could improve the quality of rice noodle without the use of gluten-like ingredients.

(1–3)(1–6)-β-Glucan-enriched materials from Lentinus edodes mushroom as a high-fibre and low-calorie flour substitute for baked foods

BACKGROUND Extensive physiological and biological emphasis has been placed on pharmaceutical and medicinal uses of mushrooms containing β-glucans, but their incorporation into processed functional foods is quite limited. Thus, low-grade Lentinus edodes mushrooms were utilised to produce β-glucan-enriched materials (BGEMs), which were evaluated as a high-fibre and low-calorie substitute for wheat flour. RESULTS The fractions obtained from Lentinus edodes mushrooms contained 514 g kg⁻¹ of (1-3)-β-glucans with (1-6)-β-linked side chains and the chemical structure was confirmed by ¹³C NMR and FTIR spectroscopy. Replacement of a portion of the wheat flour with BGEMs resulted in the solutions with lower values of pasting parameters and also caused significant changes in starch gelatinisation. When BGEMs were incorporated into cake formulations, batter viscosity increased with more shear-thinning behaviours and elastic properties improved. Overall, the cakes containing more BGEMs showed decreased volume and increased hardness while no significant differences were observed between the control and BGEM cakes containing 1 g of β-glucan per serving. CONCLUSION As a wheat flour substitute, the BGEMs that were prepared from low-grade Lentinus edodes mushrooms, could be successfully used to produce cakes containing 1 g of β-glucan per serving with quality attributes similar to those of the control.

Small and Large Deformation Rheology for Hard Wheat Flour Dough as Influenced by Mixing and Resting

The effects of mixing and resting on the physicochemical properties of doughs prepared with strong and weak hard wheat flours were investigated, specifically concerning aspects related to their rheological behavior and molecular mobility. Small deformation dynamic tests showed that, during the initial resting period, the complex modulus G* decreased and phase angle decreased for undermixed dough, whereas overmixed dough showed opposite trends. G* values for optimally mixed dough did not vary during the resting period investigated. This was more obvious for the strong dough. Large deformation tests more clearly showed differences among optimal, under-, and overmixed dough, and also between doughs prepared with strong and weak flour. Optimally mixed dough exhibited the highest peak stress and strain for both samples. In addition, the peak stress of dough prepared with the strong flour was higher than that of dough prepared with weak flour. Inconsistent results between small and large deformation tests implied that small and large deformation tests reflected different structural aspects of dough. NMR measurements were performed to estimate the relaxation properties of the sample upon resting. Decreased water mobility during resting, indicated by decreasing T(1) relaxation time, was possibly attributed to increasing molecular interactions caused by continued hydration. Evidence of additional molecular interactions created by mixing was also observed.

Effect of Lentinus edodes β-Glucan-Enriched Materials on the Textural, Rheological, and Oil-Resisting Properties of Instant Fried Noodles

With the recent well-being trend, a great deal of effort has been made to develop instant fried noodles with beneficial health effects. Thus, β-glucan-enriched materials (BGEMs) were obtained from Lentinus edodes mushroom and their effects on the quality attributes of instant fried noodles were characterized in terms of rheological, textural, and oil-resisting properties. When BGEMs were mixed with wheat flour, different thermomechanical profiles were observed by a Mixolab, enhancing dough stability and water absorption. The use of BGEMs raised the viscoelastic properties of noodle dough with a great increase in the elastic property. In addition, the dough samples prepared with more BGEMs exhibited greater elongational viscosity. In the case of fried noodle strands, the incorporation of BGEMs led to a significant increase in the breaking stress and produced a surface microstructure with smaller voids. Moreover, the oil uptake of fried noodles containing BGEMs was significantly reduced by 22%. Therefore, it showed that BGEMs had positive impacts on the quality attributes of instant fried noodles and could also be used as an oil barrier to produce fried noodles with a reduced content of oil and calories.