Taku Katagiri

Development of a new multi-walled carbon nanotube (MWCNT) aerosol generation and exposure system and confirmation of suitability for conducting a single-exposure inhalation study of MWCNT in rats

Abstract Because the primary route of human exposure to multi-walled carbon nanotube (MWCNT) is via inhalation, a new dry MWCNT aerosol generation and exposure system for whole-body inhalation exposure using a cyclone and sieve has been developed. The system was tested for operational performance at 0.2, 1 and 5 mg/m3. Additionally, it was examined whether this system can be employed in animal whole-body inhalation studies by exposing rats to MWCNT aerosol for 6 h at 5 mg/m3. The system could consistently provide aerosols with a similar particle size distribution and configuration at all the target exposure concentrations. Almost all MWCNTs were fibrous, and the presence of many well-dispersed, nano-sized particles was confirmed. Additionally, the animal study revealed that large amounts of MWCNTs were inhaled into the lung, resulting in an inflammatory response, with increased LDH and albumin levels, and granulomatous change. Therefore, the aerosol generation and exposure system appears useful for MWCNT inhalation studies using rats.

Toxicity due to 2- and 13-wk Inhalation Exposures of Rats and Mice to N, N-Dimethylformamide

Toxicity due to 2‐ and 13‐wk Inhalation Exposures of Rats and Mice to N,N‐Dimethylformamide: Hideki Senoh, et al. Japan Bioassay Research Center, Japan Industrial Safety and Health Association—In order to better characterize the toxicity of N,N‐dimethylformamide (DMF) and to provide its basic toxicity data for risk assessment of workers exposed to DMF, F344 rats and BDF1 mice of both sexes were exposed by inhalation (6 h/d × 5 d/wk) to 100, 200, 400, 800 or 1,600 ppm DMF for 2 wk, and 50, 100, 200, 400 or 800 ppm DMF for 13 wk. Three male and 7 female rats died during the 2‐wk exposure to 1,600 ppm DMF, but no death of the exposed rats or mice occurred under any other exposure conditions. Massive, focal and single cell necroses were observed in the liver of DMF‐exposed rats and mice. The massive necrosis associated with the centrilobular fibrosis occurred at the highest exposure concentration. The single cell necrosis was associated with fragmentation of the nucleoli as well as an increased mitotic figure. The 13‐wk exposures of rats and mice to DMF were characterized by increases in the relative liver weight and the incidence of the centrilobular hepatocellular hypertrophy as well as increased serum levels of AST, ALT, LDH, total cholesterol and phospholipid. Lower confidence limits of the benchmark dose yielding the response with a 10% extra risk (BMDL10) were determined for the relative liver weight and the incidence of hepatocellular hypertrophy of the 13‐wk exposed animals. The BMDL10 resulted in 1 ppm for the increased relative liver weight of male rats and mice and 17 ppm for the hepatocellular hypertrophy of male mice.

In vitro chromosomal aberrations induced by various shapes of multi-walled carbon nanotubes (MWCNTs)

IARC has classified one type of multi‐walled carbon nanotubes (MWCNTs), MWNT‐7, as possibly carcinogenic to humans (Group 2B); however, other types of MWCNT were categorized as not classifiable as to their carcinogenicity to humans (Group 3). In vitro chromosomal aberration assays of MWNT‐7 showed polyploid formation but not structural abnormalities. This study investigated the influence of the shape and size of MWCNT on in vitro induction of chromosomal aberrations.

[Background data of spontaneous tumors in F344/DuCrlCrlj rats].

INTRODUCTION We investigated the 2-year survival rate and incidence of spontaneous tumors in F344/DuCrlCrlj rats used in carcinogenicity studies of chemical substances. Records for animals used in the control groups of carcinogenicity studies which were conducted during the last 10 years were obtained from the database of the Japan Bioassay Research Center (JBRC). Six hundred ninety-nine males and 550 females were used in 14 and 11 inhalation studies, respectively, and 500 animals of each sex were used in 10 male and 10 female oral studies. METHODS In each study, SPF (specific pathogen free) animals were housed for 2 years (104 weeks) as control groups in the carcinogenicity studies. All animals underwent necropsy and histopathological examination. Each study was conducted in accordance with the Good Laboratory Practice. RESULTS The incidence of interstitial cell tumors was highest in both inhalation studies and oral studies (inhalation studies 86.1%, oral studies 68.6%). Tumors which had an incidence of 6% or higher were adenoma of the pituitary, C-cell adenoma of the thyroid, and mononuclear cell leukemia (LGL leukemia) of the spleen in male and female rats; fibroma of the subcutaneous tissue, adrenal pheochromocytoma, and islet cell adenoma of the pancreas in male rats; and endometrial stromal polyps and fibroadenoma of the mammary gland in female rats. Tumors other than the above had rare incidence rates. A clear difference in the incidence of spontaneous tumors was not observed between the inhalation and oral studies. The incidences of spontaneous tumors in control groups of previous oral studies are similar to our findings. There are no other reports of the spontaneous tumor incidence in the control groups of inhalation studies using F344/DuCrlCrlj rats. The 2-year survival rate was about 77% in both the inhalation and oral studies, and a gender difference was not observed. The F344/DuCrlCrlj rats used at JBRC had a higher 2-year survival rate than F344/N rats. This difference is possibly due to the low incidence of LGL leukemia in the F344/DuCrlCrlj rat. CONCLUSIONS The incidences of spontaneous tumors in F344/DuCrlCrlj rats used in control groups of both inhalation and oral studies during the last 10 years at JBRC are similar to each other and similar to those reported in other studies. This is the first report on the incidence of spontaneous tumors in inhalation studies and contributes to the toxicological evaluation of studies using F344/DuCrlCrlj rats.

Inhalation carcinogenicity of 1,1,1-trichloroethane in rats and mice.

Abstract Carcinogenicity of 1,1,1-trichloroethane (TCE) was examined by an inhalation exposure of F344 rats and BDF1 mice of both sexes to TCE at 0, 200, 800 or 3200 ppm for 6 h/d, 5 d/week for 104 weeks. In male rats, the incidences of bronchiolo-alveolar adenomas and peritoneal mesotheliomas were significantly increased in the 800 and 3200 ppm-exposed groups, respectively. The incidence of bronchiolo-alveolar adenomas in the 3200 ppm-exposed groups exceeded the range of historical control data in the Japan Bioassay Research Center. In female rats, the tumor incidences were not increased in any organs of the TCE-exposed groups. In male mice, a significant positive trend with dose was shown for incidences of bronchiolo-alveolar carcinomas, combined incidences of bronchiolo-alveolar adenomas/carcinomas and hepatocellular adenomas. The incidence of Harderian gland adenomas was significantly increased in the 3200 ppm-exposed group, and malignant lymphomas of spleen at this highest dose exceeded the range of historical control data. In female mice, the combined incidence of bronchiolo-alveolar adenomas/carcinomas was significantly increased in the 3200 ppm-exposed group, and the incidences of hepatocellular adenomas and combined incidences of hepatocellular adenomas/carcinomas were significantly increased in the 200, 800 and 3200 ppm-exposed groups with dose dependence except the combined incidence of hepatocellular adenomas/carcinomas in the 200 ppm-exposed group. The incidences of bronchiolo-alveolar adenomas in the 3200 ppm-exposed group and combined incidences of hepatocellular adenomas/carcinomas in the 200 ppm-exposed groups exceeded the ranges of historical control data. Thus, this study provided clear evidence of inhalation carcinogenicity for TCE in both rats and mice.

Spontaneous Harderian Gland Adenocarcinoma in a Female F344 Rat: A Case Report

Harderian gland tumors are extremely rare in female F344 rats. An expansive enlarging lesion of the Harderian gland with compression, distortion and invasion of the surrounding muscle was found in a 110-week-old female F344/DuCrj rat, which was diagnosed as a Harderian gland adenocarcinoma. Epithelial growth patterns such as glandular, lobular, papillary and duct forming patterns were exhibited in most areas of the tumor. The tumor cells were pleomorphic and atypical. In one part of the tumor, poorly differentiated areas were found. This case was observed in the middle dose group of a carcinogenicity study of diphenylamine, which was not carcinogenic, we determine to be this case was a spontaneous tumor.