Tatiana Alves dos Reis

Aflatoxin B1 residues in eggs of laying hens fed a diet containing different levels of the mycotoxin

The present study was carried out to evaluate the excretion of aflatoxin B1 residues in eggs of young laying hens fed aflatoxin B1-contaminated rations for 8 weeks. To this end, 96 twenty-week-old hens were randomly distributed into four experimental groups (24 birds per group) and given rations containing either 0 (controls), 100 μg, 300 μg or 500 μg aflatoxin B1/kg feed. Egg aflatoxin B1 residues were determined by thin layer chromatography; two samples per treatment per week were used for analysis. Egg production and average egg weights were not affected (p < 0.05) in the groups receiving aflatoxin B1-contaminated rations. Residues of aflatoxin B were detected only in the eggs 1 of hens given 500 μg/kg feed, at levels that ranged from 0.05 to 0.16 μg/kg (average: 0.10 μg/kg). The results indicate that the feed to eggs aflatoxin B transmission 1 ratio was approximately 5000:1, emphasizing the importance of controlling aflatoxin levels in rations for laying hens.

Mycoflora and Co-Occurrence of Fumonisins and Aflatoxins in Freshly Harvested Corn in Different Regions of Brazil

Natural mycoflora and co-occurrence of fumonisins (FB1, FB2) and aflatoxins (AFB1, AFB2, AFG1 and AFG2) in freshly harvested corn grain samples from four regions of Brazil were investigated. Fusarium verticillioides was predominant in all samples. Analysis of fumonisins showed that 98% of the samples were contaminated with FB1 and 74.5% with FB1 + FB2, with toxin levels ranging from 0.015 to 9.67 μg/g for FB1 and from 0.015 to 3.16 μg/g for FB2. Twenty-one (10.5%) samples were contaminated with AFB1, seven (3.5%) with AFB2 and only one (0.5%) with AFG1 and AFG2 Co-contamination with aflatoxins and fumonisins was observed in 7% of the samples. The highest contamination of fumonisins and aflatoxins was observed in Nova Odessa (SP) and Várzea Grande (MT), respectively. The lowest contamination of these mycotoxins was found in Várzea Grande and Nova Odessa, respectively.

Mycobiota and mycotoxins in Brazil nut samples from different states of the Brazilian Amazon region

The objective of this study was to evaluate the presence of fungi and mycotoxins (aflatoxins and cyclopiazonic acid) in Brazil nut samples collected in different states of the Brazilian Amazon region: Acre, Amazonas, Amapá, and Pará. A total of 200 husk samples and 200 almond samples were inoculated onto Aspergillus flavus-parasiticus agar for the detection of fungi. Mycotoxins were analyzed by high-performance liquid chromatography. The mycobiota comprised the following fungi, in decreasing order of frequency: almonds - Phialemonium spp. (54%), Penicillium spp. (16%), Fusarium spp. (13%), Phaeoacremonium spp. (11%), and Aspergillus spp. (4%), husks - Phialemonium spp. (62%), Phaeoacremonium spp. (11%), Penicillium spp. (10%), Fusarium spp. (9%), and Aspergillus spp. A polyphasic approach was used for identification of Aspergillus species. Aflatoxins were detected in 22 (11%) of the 200 almond samples, with 21 samples presenting aflatoxin B(1) levels above 8μg/kg, the limit established by the European Commission for Brazil nuts for further processing. Nineteen (9.5%) of the 200 husk samples contained aflatoxins, but at levels lower than those seen in almonds. Cyclopiazonic acid (CPA) was detected in 44 (22%) almond samples, with levels ranging from 98.65 to 161.2μg/kg. Aspergillus nomius and A. flavus were the most frequent Aspergillus species. The presence of fungi does not necessarily imply mycotoxin contamination, but almonds of the Brazil nut seem to be a good substrate for fungal growth.

Polyphasic approach to the identification of Aspergillus section Flavi isolated from Brazil nuts.

The aim of this study was to use a polyphasic approach to identify Aspergillus section Flavi isolated from Brazil nuts collected in the Amazon forest: investigation of macro- and microscopic morphology, production of extrolites, heat-resistance fungi, and sequencing of DNA regions. The following Aspergillus section Flavi species were identified: Aspergillus flavus (75.5%), Aspergillus nomius (22.3%), and Aspergillus parasiticus (2.2%). All A. nomius and A. parasiticus isolates produced aflatoxins B and G, but not cyclopiazonic acid (CPA). A. flavus isolates were more diversified and a high frequency of mycotoxigenic strains was observed. The polyphasic approach permitted the reliable identification of section Flavi species. The rate of mycotoxigenic strains was high (92.7%) and mainly included A. flavus strains producing elevated levels of aflatoxins and CPA. These results highlight the possibility of co-occurrence of both toxins, increasing their potential toxic effect in this commodity.

Fungi, mycotoxins and phytoalexin in peanut varieties, during plant growth in the field

The aim of the present study was to analyze the mycobiota, occurrence of mycotoxins (aflatoxins and cyclopiazonic acid), and production of phytoalexin (trans-resveratrol) in two peanut varieties (Runner IAC 886 and Caiapó) during plant growth in the field. Climatic factors (rainfall, relative humidity and temperature) and water activity were also evaluated. The results showed a predominance of Fusarium spp. in kernels and pods, followed by Penicillium spp. and Aspergillus flavus. Aflatoxins were detected in 20% and 10% of samples of the IAC 886 and Caiapó varieties, respectively. Analysis showed that 65% of kernel samples of the IAC 886 variety and 25% of the Caiapó variety were contaminated with cyclopiazonic acid. trans-Resveratrol was detected in 6.7% of kernel samples of the IAC 886 variety and in 20% of the Caiapó variety. However, trans-resveratrol was found in 73.3% of leaf samples in the two varieties studied.

Mycoflora and fumonisin contamination in Brazilian sorghum from sowing to harvest

BACKGROUND The aim of this study was to characterise the mycoflora and the presence of fumonisin in sorghum grains, correlating the results with the environment and abiotic factors. RESULTS Fifty samples (five collections of ten samples each) of sorghum were analysed. All samples were found to be contaminated with fungi, with higher frequencies of Cladosporium spp. (61.8%) and Helminthosporium spp. (33.4%). Fusarium verticillioides was isolated from 15.1% of the samples, with 38% of them being contaminated with fumonisin B(1) (FB(1)) at levels ranging from 50 to 368.78 ng g(-1). Regarding abiotic factors, temperature, water activity and rainfall showed a positive correlation with the frequency of F. verticillioides and FB(1) production. There was a significant positive correlation between relative air humidity and FB(1) production. The results obtained from sexual crosses between standard F mating tester strains and the isolated strains confirmed that the strains isolated were F. verticillioides. CONCLUSION It can be concluded that the decrease in F. verticillioides and fumonisin contamination occurred owing to atypical climatic factors during the period of sorghum cultivation, when there was any occurrence of rain and the level of water activity of grains did not reach 0.58.

Effects of gamma radiation on the growth of Alternaria alternata and on the production of alternariol and alternariol monomethyl ether in sunflower seeds.

The objective of the present study was to evaluate the effects of different gamma radiation doses on the growth of Alternaria alternata and on the production of toxins alternariol (AOH), and alternariol monomethyl ether (AME) in sunflower seed samples. After irradiation with 2, 5 and 7 kGy, the spore mass was resuspended in sterile distilled water and the suspension was inoculated into sunflower seeds. The number of colony-forming units per gram (CFU/g) was determined after culture on Dichloran Rose Bengal Chloramphenicol and Dichloran Chloramphenicol Malt Extract Agar. The presence of AOH and AME was investigated by liquid chromatography coupled to mass spectrometry. The radiation doses used resulted in a reduction of the number of A. alternata CFU/g and of AOH and AME levels when compared to the nonirradiated control group. Maximum reduction of the fungus (98.5%) and toxins (99.9%) was observed at a dose of 7 and 5 kGy, respectively. Under the present conditions, gamma radiation was found to be an alternative for the control of A. alternata and, consequently, of AOH and AME production in sunflower seeds.

Evaluation of fungal burden and aflatoxin presence in packed medicinal plants treated by gamma radiation.

This study was developed to evaluate the fungal burden, toxigenic molds, and mycotoxin contamination and to verify the effects of gamma radiation in four kinds of medicinal plants stored before and after 30 days of irradiation treatment. Eighty samples of medicinal plants (Peumus boldus, Camellia sinensis, Maytenus ilicifolia, and Cassia angustifolia) purchased from drugstores, wholesale, and open-air markets in São Paulo city, Brazil, were analyzed. The samples were treated using a (60)Co gamma ray source (Gammacell) with doses of 5 and 10 kGy. Nonirradiated samples were used as controls of fungal isolates. For enumeration of fungi on medicinal plants, serial dilutions of the samples were plated in duplicate onto dichloran 18% glycerol agar. The control samples revealed a high burden of molds, including toxigenic fungi. The process of gamma radiation was effective in reducing the number of CFU per gram in all irradiated samples of medicinal plants after 30 days of storage, using a dose of 10 kGy and maintaining samples in a protective package. No aflatoxins were detected. Gamma radiation treatment can be used as an effective method for preventing fungal deterioration of medicinal plants subject to long-term storage.

Intoxicação experimental de suínos por fumonisinas

The effects of prolonged oral exposure (28 days) to fumonisin were studied in young pigs. Animals were divided into three experimental groups and fed ad libitum using ratio containing: A) 0mg of FB1.kg-1 (as control); B) 10mg of FB1.kg-1; C) 30mg of FB1.kg-1. Pigs were observed twice a day; their weights and feed intake were registered weekly. Between the 20th and 24th day of intoxication, pigs in group C presented a decrease in feed intake and weight gain, and showed characteristic signs of porcine pulmonary edema, which was the death cause of one of the animals in this group on the 23rd day of the trial. After 28 days, animals were necropsized, their organs were submitted to macroscopic and histopathological analyses, and to the study of intestinal morphology and histology. Among the pigs that showed clinic signs of intoxication, pulmonary and hepatic lesions were observed. In intestine segments, a decrease on the height of the villus and the depth of the crypts as well as an increase on gland proportion per epithelial tissue were observed. It was concluded that substantial productivity losses may be induced on pigs fed ration contaminated with low levels of fumonisins.

Mycotoxin analysis of industrial beers from Brazil: The influence of fumonisin B1 and deoxynivalenol in beer quality

Worldwide, barley is the main source of carbohydrate in the brewing process. However, corn is often used as an adjunct to improve and accelerate the fermentation process. Considering that, these two substrates are susceptible to fungal contamination as well as mycotoxins. The objective of the current study is to determine the incidence of the mycotoxins deoxynivalenol (DON) and fumonisin B1 (FB1) in industrial beers. The method applied for mycotoxin analyses included high performance liquid chromatography. The mean levels for recovery experiments were 89.6% for DON and 93.3% for FB1. DON was not detected in any of the analyzed samples whereas FB1 was found in 49% of the 114 samples. The current survey demonstrated levels of FB1 contamination in industrial beer, possibly due to the addition of contaminated adjuncts. It is necessary to establish maximum levels of mycotoxins in beer in Brazil and other countries in order to reduce health risks.