Valerie Van Craeyveld

Structurally different wheat-derived arabinoxylooligosaccharides have different prebiotic and fermentation properties in rats.

To evaluate the prebiotic potential and intestinal fermentation products of wheat bran-derived arabinoxylooligosaccharides (AXOS) in relation to their structure, 5 preparations with structurally different AXOS were included ( approximately 4% wt:wt) in rat diets that mimicked the average Western human diet composition. Xylooligosaccharides (XOS), fructooligosaccharides (FOS), and inulin were used as references. The observed effects mainly depended on the average degree of polymerization (avDP) of the AXOS preparations. The AXOS and XOS preparations with a low avDP (<or=3) resulted in increased colonic acetate and butyrate production and boosted bifidobacteria concentrations in the cecum, but did not significantly lower the concentrations of branched SCFA, which are considered to be markers of protein fermentation by intestinal microbiota. In contrast, an AXOS preparation with a higher avDP (61) effectively suppressed branched SCFA concentrations and thus tipped the balance away from protein fermentation. However, it neither increased colonic butyrate concentrations nor stimulated cecal bifidobacteria development. Two AXOS preparations with a similar avDP (12 and 15) but different average degrees of arabinose substitution (avDAS) (0.69 and 0.27) affected the measured intestinal characteristics similarly, suggesting that the influence of the avDAS was apparently limited and possibly overshadowed by that of the avDP. Among those tested, an AXOS preparation with an avDP of 5 and an avDAS of 0.27 exhibited the best combination of desirable effects on gut health characteristics. Compared with this optimal AXOS preparation, FOS and inulin resulted in similar bifidogenic effects with increased production of colonic acetate (inulin) but not of butyrate. These new insights into the structure-activity relation of AXOS open up new perspectives for the production and application of AXOS preparations with optimized prebiotic and fermentation properties.

Arabinoxylan-oligosaccharides (AXOS) affect the protein/carbohydrate fermentation balance and microbial population dynamics of the Simulator of Human Intestinal Microbial Ecosystem

Arabinoxylan‐oligosaccharides (AXOS) are a recently newly discovered class of candidate prebiotics as – depending on their structure – they are fermented in different regions of gastrointestinal tract. This can have an impact on the protein/carbohydrate fermentation balance in the large intestine and, thus, affect the generation of potentially toxic metabolites in the colon originating from proteolytic activity. In this study, we screened different AXOS preparations for their impact on the in vitro intestinal fermentation activity and microbial community structure. Short‐term fermentation experiments with AXOS with an average degree of polymerization (avDP) of 29 allowed part of the oligosaccharides to reach the distal colon, and decreased the concentration of proteolytic markers, whereas AXOS with lower avDP were primarily fermented in the proximal colon. Additionally, prolonged supplementation of AXOS with avDP 29 to the Simulator of Human Intestinal Microbial Ecosystem (SHIME) reactor decreased levels of the toxic proteolytic markers phenol and p‐cresol in the two distal colon compartments and increased concentrations of beneficial short‐chain fatty acids (SCFA) in all colon vessels (25–48%). Denaturant gradient gel electrophoresis (DGGE) analysis indicated that AXOS supplementation only slightly modified the total microbial community, implying that the observed effects on fermentation markers are mainly caused by changes in fermentation activity. Finally, specific quantitative PCR (qPCR) analysis showed that AXOS supplementation significantly increased the amount of health‐promoting lactobacilli as well as of Bacteroides–Prevotella and Clostridium coccoides–Eubacterium rectale groups. These data allow concluding that AXOS are promising candidates to modulate the microbial metabolism in the distal colon.

Extensive dry ball milling of wheat and rye bran leads to in situ production of arabinoxylan oligosaccharides through nanoscale fragmentation.

This study investigated the potential of ball milling as a dry process for in situ production of arabinoxylan oligosaccharides (AXOS) in arabinoxylan (AX)-rich wheat and rye bran. An extensive lab-scale ball mill treatment (120 h, 50% jar volume capacity) increased the wheat bran water-extractable arabinoxylan (WE-AX) level from 4% (untreated bran) to 61% of the wheat bran AX. Extractable AX fragments had an arabinose/xylose ratio (A/X ratio) of 0.72 and a molecular mass (MM) of 15 kDa. Ball milling of rye bran gave rise to similar results, with the A/X ratio of the extractable AX being considerably lower (0.51). Optimization of the ball mill treatment by varying the degree of filling of the milling jar permitted us to obtain equally high WE-AX levels (>70%) in wheat and rye bran within a 24 h ball-milling period. Ball milling at optimal conditions (24 h, 16% jar volume capacity) yielded wheat bran AXOS, with an A/X ratio of 0.65 and a MM of 6 kDa. Ball milling (24 h, 50% jar volume capacity) of pericarp-enriched wheat bran increased the WE-AX level from 1% (untreated pericarp) to 63%. The extractable material had a high A/X ratio (0.97) and a low MM (5 kDa). Fluorescence microscopy revealed that the extensive ball mill treatment led to the almost complete disappearance of discernible tissue structures in the ball-milled material, indicating bran particle size reductions down to the nanoscale level. It further visualized the aggregation of the treated material. These results show that AXOS can be produced in situ from wheat or rye bran in a single-stage dry milling process, rendering a wet extraction step redundant. The higher A/X ratio of the obtained AXOS than of enzymically produced wheat bran-derived AXOS offers perspectives for the production of a wide range of AXOS structures. Moreover, ball milling makes upgrading of the low-value pericarp layer feasible.

In Vitro Fermentation of Arabinoxylan Oligosaccharides and Low Molecular Mass Arabinoxylans with Different Structural Properties from Wheat (Triticum aestivum L.) Bran and Psyllium (Plantago ovata Forsk) Seed Husk

Ball milling was used for producing complex arabinoxylan oligosaccharides (AXOS) and low molecular mass arabinoxylans (AX) from wheat bran, pericarp-enriched wheat bran, and psyllium seed husk. The arabinose to xylose ratio of the samples produced varied between 0.14 and 0.92, and their average degree of polymerization (avDP) ranged between 42 and 300. Their fermentation for 48 h in an in vitro system using human colon suspensions was compared to enzymatically produced wheat bran AXOS with an arabinose to xylose ratio of 0.22 and 0.34 and an avDP of 4 and 40, respectively. Degrees of AXOS fermentation ranged from 28% to 50% and were lower for the higher arabinose to xylose ratio and/or higher avDP materials. Arabinose to xylose ratios of the unfermented fractions exceeded those of their fermented counterparts, indicating that molecules less substituted with arabinose were preferably fermented. Xylanase, arabinofuranosidase, and xylosidase activities increased with incubation time. Enzyme activities in the samples containing psyllium seed husk AX or psyllium seed husk AXOS were generally higher than those in the wheat bran AXOS preparations. Fermentation gave rise to unbranched short-chain fatty acids. Concentrations of acetic, propionic, and butyric acids increased to 1.9-2.6, 1.9-2.8, and 1.3-2.0 times their initial values, respectively, after 24 h incubation. Results show that the human intestinal microbiota can at least partially use complex AXOS and low molecular mass AX. The tested materials are thus interesting physiologically active carbohydrates.

Selected nondigestible carbohydrates and prebiotics support the growth of probiotic fish bacteria mono-cultures in vitro

Aims:  To search for nondigestible but fermentable (NDF) carbohydrates and prebiotics with a potency to promote the growth of selected bacteria in vitro.

Ball Milling Improves Extractability and Affects Molecular Properties of Psyllium (Plantago ovata Forsk) Seed Husk Arabinoxylan

Psyllium (Plantago ovata Forsk) seed husk (PSH) is very rich in arabinoxylan (AX). However, its high gelling capacity and the complex nature of the AX make it difficult to process. In this study, ball milling was investigated as a tool for enhancing PSH AX water extractability and molecular mass (MM). A 48 h laboratory-scale ball mill treatment under standardized optimal conditions reduced the PSH average particle size from 161 microm for the untreated sample to 6 microm. Concurrently, it increased the water-extractable AX (WE-AX) level from 13 (untreated PSH) to 90% of the total PSH AX. While the WE-AX of the untreated PSH had a peak MM of 216 kDa and an arabinose to xylose (A/X) ratio of 0.20, WE-AX fragments from ball mill-pretreated PSH had a peak MM of 22 kDa and an A/X ratio of 0.31. Ball milling further drastically reduced the intrinsic viscosity of PSH extracts and their water-holding capacity. Prolonged treatment brought almost all AX (98%) in solution and yielded WE-AX fragments with an even higher A/X ratio (0.42) and a lower peak MM (11 kDa). While impact and jet milling of PSH equally led to significant reductions in particle size, these technologies only marginally affected the water extractability of PSH AX. This implies that ball milling affects PSH particles and their constituent molecules differently than impact and jet milling.

Wheat bran AX properties and choice of xylanase affect enzymic production of wheat bran-derived arabinoxylan-oligosaccharides.

ABSTRACTWheat bran-derived arabinoxylan-oligosaccharides (AXOS) recently have been shown to potentially exert prebiotic effects. In this study, 15 bran samples obtained by milling different wheat cultivars were treated with xylanases from Hypocrea jecorina (XHJ), Aspergillus aculeatus (XAA), and Pseudoalteromonas haloplanktis (XPH) to assess the effect of bran source and xylanase properties on the AXOS yield and structure. The total arabinoxylan (AX) extraction yield was higher with XHJ (8.2–10.7%) and XAA (8.2–10.8%) than with XPH (6.9–9.5%). Irrespective of the enzyme, a significant negative correlation was observed between extraction yield and arabinose to xylose (A/X) ratio of bran AX (r = –0.7), but not between yield and bran AX level. The A/X ratio of the extracted material was 0.27–0.34 for all bran samples and all enzymes, which combined with yield data and microscopic analysis, indicated primary hydrolysis of aleurone and nucellar epidermis AX. The average degree of polymerization (avDP) of the e...