Caixia Wan

Enhanced solid-state anaerobic digestion of corn stover by alkaline pretreatment.

Alkaline pretreatment was applied to enhance biogas production from corn stover through solid-state anaerobic digestion. Different NaOH loadings (1%, 2.5%, 5.0% and 7.5% (w/w)) were tested for solid-state pretreatment of corn stover. Lignin degradation during pretreatment increased from 9.1% to 46.2% when NaOH concentration increased from 1.0% to 7.5%. The NaOH-pretreated corn stover was digested using effluent of liquid anaerobic digestion as inoculum and nitrogen source. NaOH loading of 1% did not cause significant improvement on biogas yield. The highest biogas yield of 372.4 L/kg VS was obtained with 5% NaOH-pretreated corn stover, which was 37.0% higher than that of the untreated corn stover. However, a higher NaOH loading of 7.5% caused faster production of volatile fatty acids during the hydrolysis and acidogenesis stages, which inhibited the methanogenesis. Simultaneous NaOH treatment and anaerobic digestion did not significantly improve the biogas production (P>0.05).

Microbial pretreatment of corn stover with Ceriporiopsis subvermispora for enzymatic hydrolysis and ethanol production.

The feasibility of concurrent wet storage and microbial pretreatment of corn stover with Ceriporiopsis subvermispora for ethanol production was investigated in this study. The effects of particle size (5-15 mm), moisture content (45-85%), pretreatment time (18-35 d), and temperature (4-37 degrees C) on lignin degradation and enzymatic hydrolysis yield were studied. The results showed that C. subvermispora selectively degraded lignin up to 31.59% with a limited cellulose loss of less than 6% during an 18-d pretreatment. When 5mm corn stover was pretreated at 28 degrees C with 75% moisture content, overall glucose yields of 57.67%, 62.21%, and 66.61% were obtained with 18-, 28-, and 35-d microbial pretreated corn stover, respectively. For the above conditions, the highest overall ethanol yield of 57.80% was obtained with 35-d-pretreated corn stover. Enzymatic hydrolysis yield was highly related to the lignin removal during microbial pretreatment.

Characterization of Crude Glycerol from Biodiesel Plants

Characterization of crude glycerol is very important to its value-added conversion. In this study, the physical and chemical properties of five biodiesel-derived crude glycerol samples were determined. Three methods, including iodometric-periodic acid method, high performance liquid chromatography (HPLC), and gas chromatography (GC), were shown to be suitable for the determination of glycerol content in crude glycerol. The compositional analysis of crude glycerol was successfully achieved by crude glycerol fractionation and characterization of the obtained fractions (aqueous and organic) using titrimetric, HPLC, and GC analyses. The aqueous fraction consisted mainly of glycerol, methanol, and water, while the organic fraction contained fatty acid methyl esters (FAMEs), free fatty acids (FFAs), and glycerides. Despite the wide variations in the proportion of their components, all raw crude glycerol samples were shown to contain glycerol, soap, methanol, FAMEs, water, glycerides, FFAs, and ash.

Production and characterization of biopolyols and polyurethane foams from crude glycerol based liquefaction of soybean straw.

The feasibility of using crude glycerol to liquefy soybean straw for the production of biopolyols and polyurethane (PU) foams was investigated in this study. Liquefaction conditions of 240 °C, >180 min, 3% sulfuric acid loading, and 10-15% biomass loading were preferred for the production of biopolyols with promising material properties. Biopolyols produced under preferential conditions showed hydroxyl numbers from 440 to 540 mg KOH/g, acid numbers below 5 mg KOH/g, and viscosities from 16 to 45 Pa.s. PU foams produced under preferential conditions showed densities from 0.033 to 0.037 g/cm3 and compressive strength from 148 to 227 kPa. These results suggest that crude glycerol can be used as an alternative solvent for the liquefaction of lignocellulosic biomass such as soybean straw for the production of biopolyols and PU foams. The produced biopolyols and PU foams showed material properties comparable to their analogs from petroleum solvent based liquefaction processes.

Effectiveness of microbial pretreatment by Ceriporiopsis subvermispora on different biomass feedstocks

Different types of feedstocks, including corn stover, wheat straw, soybean straw, switchgrass, and hardwood, were tested to evaluate the effectiveness of fungal pretreatment by Ceriporiopsis subvermispora. After 18-d pretreatment, corn stover, switchgrass, and hardwood were effectively delignified by the fungus through manganese peroxidase and laccase. Correspondingly, glucose yields during enzymatic hydrolysis reached 56.50%, 37.15%, and 24.21%, respectively, which were a 2 to 3-fold increase over those of the raw materials. A further 10-30% increase in glucose yields was observed when pretreatment time extended to 35d. In contrast, cellulose digestibility of wheat straw and soybean straw was not significantly improved by fungal pretreatment. When external carbon sources and enzyme inducers were added during fungal pretreatment of wheat straw and soybean straw, only glucose and malt extract addition improved cellulose digestibility of wheat straw. The cellulose digestibility of soybean straw was not improved.

Liquid hot water and alkaline pretreatment of soybean straw for improving cellulose digestibility

Soybean straw was pretreated with either liquid hot water (LHW) (170-210°C for 3-10 min) or alkaline soaking (4-40 g NaOH/100g dry straw) at room temperature to evaluate the effects on cellulose digestibility. Nearly 100% cellulose was recovered in pretreated solids for both pretreatment methods. For LHW pretreatment, xylan dissolution from the raw material increased with pretreatment temperature and time. Cellulose digestibility was correlated with xylan dissolution. A maximal glucose yield of 70.76%, corresponding to 80% xylan removal, was obtained with soybean straw pretreated at 210°C for 10 min. NaOH soaking at ambient conditions removed xylan up to 46.37% and the subsequent glucose yield of pretreated solids reached up to 64.55%. Our results indicated LHW pretreatment was more effective than NaOH soaking for improving cellulose digestibility of soybean straw.

Lactic acid production from corn stover using mixed cultures of Lactobacillus rhamnosus and Lactobacillus brevis

Mixed cultures of Lactobacillus rhamnosus and Lactobacillus brevis was studied for improving utilization of both cellulose- and hemicellulose-derived sugars from corn stover for lactic acid production. During simultaneous saccharification and fermentation (SSF) of NaOH-treated corn stover by the mixed cultures, a lactic acid yield of 0.70 g/g was obtained, which was about 18.6% and 29.6% higher than that by single cultures of L. rhamnosus and L. brevis, respectively. Our results indicated that lactic acid yield from NaOH-pretreated corn stover by mixed cultures of L. rhamnosus and L. brevis was comparable to that from pure sugar mixtures (0.73 g/g of glucose/xylose mixture at 3:1 w/w).

Effect of hot water extraction and liquid hot water pretreatment on the fungal degradation of biomass feedstocks

Exhaustive hot water extraction (HWE) and liquid hot water (LHW) pretreatment were evaluated for their effects on degradation of biomass feedstocks (i.e., corn stover, wheat straw, and soybean straw) by Ceriporiopsis subvermispora. HWE (85 °C for 10 min) partially removed water soluble extractives and subsequently improved fungal degradation on wheat straw while it had little or no effect on the fungal degradation of corn stover and soybean straw. In contrast, LHW pretreatment at 170 °C for 3 min improved the fungal degradation of soybean straw; thus, lignin removal of 36.70% and glucose yield of 64.25% were obtained from the combined LHW and fungal pretreatment. However, corn stover, which was effectively degraded by fungal pretreatment alone, was less affected by this combined pretreatment. Our results indicated that a HWE or LHW pretreatment conducted under mild conditions worked synergistically with fungal degradation for some recalcitrant feedstocks.

Comparison of alkaline- and fungi-assisted wet-storage of corn stover

Storage of lignocellulosic biomass is critical for a year-round supply of feedstock for a biorefinery. Compared with dry storage, wet storage is a promising alternative technology, providing several advantages including reduced dry matter loss and fire risk and improved feedstock digestibility after storage. This study investigated the concurrent pretreatment and wet-storage of corn stover with the assistance of NaOH or a lignin-degrading fungus, Ceriporiopsis subvermispora, during a 90-d period. Compared with ensilage, adding NaOH or inoculation with C. subvermispora significantly enhanced the enzymatic degradability of corn stover by 2-3-fold after 90-d wet storage. Lignin and xylan removal during NaOH pretreatment and wet-storage were influenced by NaOH loading and moisture. NaOH pretreatment retarded the production of organic acids during storage and the acetate release correlated with lignin and xylan removal. Further study is needed to reduce cellulose degradation during the late stage of fungal treatment.

The NAC transcription factor OsSWN1 regulates secondary cell wall development in Oryza sativa

Rice, as a major crop in the world, produces huge agronomic biomass residues besides food, which consist of cellulose, hemicelluloses and lignin. Many master regulators of secondary wall synthesis were identified in the model plant Arabidopsis. In this study, we investigated the function of a NAC (NAM, ATAF, and CUC2) transcription factor related to secondary cell wall biosynthesis, which is highly expressed in rice sclerenchyma tissue and is named OsSWN1. Our results showed that engineering of OsSWN1 could exhibit multiple features regulated to agronomic traits and bioenergy research. Over-expression of OsSWN1 caused an erect-leaf and enclosed-flower phenotype. Secondary cell wall-related genes were actively expressed in transgenic plants with obvious ectopic lignin deposition in the leaf collar, while increased lignin content and decreased the sugar yield correspondingly. In addition, down-regulation of OsSWN1 expression levels decreased lignin content and increased the sugar yield in transgenic plants. Bioinformatics analysis revealed that OsSWN1-like genes are highly conserved in switchgrass and sorghum, suggesting a possibility of manipulating the expression level of the OsSWN1 orthologs in the bioenergy crops for biofuel production.