Cecilia Sunnevång

Census Study of Real-Life Near-Side Crashes with Modern Side Airbag-Equipped Vehicles in the United States

Objective: This study aimed to investigate the crash characteristics, injury distribution, and injury mechanisms for Maximum Abbreviated Injury Score (MAIS) 2+ injured belted, near-side occupants in airbag-equipped modern vehicles. Furthermore, differences in injury distribution for senior occupants compared to non-senior occupants was investigated, as well as whether the near-side occupant injury risk to the head and thorax increases or decreases with a neighboring occupant. Method: National Automotive Sampling Systems Crashworthiness Data System (NASS-CDS) data from 2000 to 2012 were searched for all side impacts (GAD L&R, all principal direction of force) for belted occupants in modern vehicles (model year > 1999). Rollovers were excluded, and only front seat occupants over the age of 10 were included. Twelve thousand three hundred fifty-four MAIS 2+ injured occupants seated adjacent to the intruding structure (near-side) and protected by at least one deployed side airbag were studied. To evaluate the injury risk influenced by the neighboring occupant, odds ratio with an induced exposure approach was used. Result: The most typical crash occurred either at an intersection or in a left turn where the striking vehicle impacted the target vehicle at a 60 to 70° angle, resulting in a moderate change of velocity (delta-V) and intrusion at the B-pillar. The head, thorax, and pelvis were the most frequent body regions with rib fracture the most frequent specific injury. A majority of the head injuries included brain injuries without skull fracture, and non-senior rather than senior occupants had a higher frequency of head injuries on the whole. In approximately 50% of the cases there was a neighboring occupant influencing injury outcome. Conclusion: Compared to non-senior occupants, the senior occupants sustained a considerably higher rate of thoracic and pelvis injuries, which should be addressed by improved thorax side airbag protection. The influence on near-side occupant injury risk by the neighboring occupant should also be further evaluated. Furthermore, side airbag performance and injury assessments in intersection crashes, especially those involving senior occupants in lower severities, should be further investigated and side impact dummy biofidelity and injury criteria must be determined for these crash scenarios.

A Comparison of the Performance of Two Advanced Restraint Systems in Frontal Impacts

Objective: The goal of the study is to compare the kinematics and dynamics of the THOR dummy in a frontal impact under the action of 2 state-of-the-art restraint systems. Methods: Ten frontal sled tests were performed with THOR at 2 different impact speeds (35 and 9 km/h). Two advanced restraint systems were used: a pretensioned force-limiting belt (PT+FL) and a pretensioned belt incorporating an inflatable portion (PT+BB). Dummy measurements included upper and lower neck reactions, multipoint thoracic deflection, and rib deformation. Data were acquired at 10,000 Hz. Three-dimensional motion of relevant dummy landmarks was tracked at 1,000 Hz. Results are reported in a local coordinate system moving with the test buck. Results: Average forward displacement of the head was greater when the PT+FL belt was used (35 km/h: 376.3 ± 16.1 mm [PT+BB] vs. 393.6 ± 26.1 mm [PT+FL]; 9 km/h: 82.1 ± 26.0 mm [PT+BB] vs. 98.8 ± 0.2 mm [PT+FL]). The forward displacement of T1 was greater for the PT+FL belt at 35 km/h but smaller at 9 km/h. The forward motion of the pelvis was greater when the PT+BB was used, exhibiting a difference of 82 mm in the 9 km/h tests and 95.5 mm in the 35 km/h test. At 35 km/h, upper shoulder belt forces were similar (PT+FL: 4,756.8 ± 116.6 N; PT+BB: 4,957.7 ± 116.4 N). At 9 km/h, the PT+BB belt force was significantly greater than the PT+FL one. Lower neck flexion moments were higher for the PT+BB at 35 km/h but lower at 9 km/h (PT+FL: 34.2 ± 3.5 Nm; PT+BB: 26.8 ± 2.1 Nm). Maximum chest deflection occurred at the chest upper left region for both belts and regardless of the speed. Conclusion: The comparison of the performance of different restraints requires assessing occupant kinematics and dynamics from a global point of view. Even if the force acting on the chest is similar, kinematics can be substantially different. The 2 advanced belts compared here showed that while the PT+BB significantly reduced peak and resultant chest deflection, the resulting kinematics indicated an increased forward motion of the pelvis and a reduced rotation of the occupants torso. Further research is needed to understand how these effects can influence the protection of real occupants in more realistic vehicle environments.

Evaluation of Near-Side Oblique Frontal Impacts Using THOR With SD3 Shoulder

Objective: Within the EC Seventh Framework project THORAX, the Mod-Kit THOR was upgraded with a new thorax and shoulder. The aim of this study was to investigate whether the THOR ATD met a set of prerequisites to a greater extent than Hybrid III and by that measure whether the dummy could serve as a potential tool for future evaluation of serious head and chest injuries in near-side oblique frontal impacts. Method: A small-overlap/oblique sled system was used to reflect occupant forces observed in oblique frontal crashes. The head and thoracic response from THOR was evaluated for 3 combinations: belt only with no deformation of the drivers side door (configuration A), belt only in combination with a predeformed door (configuration B), and prepretensioning belt and driver airbag (PPT+DAB) in combination with a predeformed door (configuration C). To evaluate head injury risk, the head injury criterion (HIC) and brain injury criteria (BrIC) were used. For evaluation of the thoracic injury risk, 3 injury criteria proposed by the THORAX project were evaluated: Dmax, DcTHOR, and strain (dummy rib fractures). Results: Unlike Hybrid III, the THOR with SD3 shoulder interacted with the side structure in a near-side oblique frontal impact. HIC values for the 3 test configurations corresponded to a 90% (A) and 100% (B and C) risk of Abbreviated Injury Scale (AIS) 2+ head injury, and BrIC values resulted in a 100% risk of AIS 2+ head injury in configurations A and B. In C the risk was reduced to 75%. The AIS 2+ thoracic injury risks based on Dmax were similar (14–18%) for all tests. Based on DcTHOR, AIS 2+ injury risk increased from 29 to 53% as the predeformed door side was introduced (A to B), and the risk increased, to 64%, as a PPT+DAB was added (C). Considering the AIS 2+ injury risk based on strain, tests in A resulted in an average of 3 dummy rib fractures (17%). Introducing the predeformed door (B) increased the average of dummy fractures to 5 (39%), but in C the average number of dummy rib fractures decreased to 4 (28%). Conclusions: THOR with an SD3 shoulder should be the preferred ATD rather than the Hybrid III for evaluating head and thorax injuries in oblique frontal impacts. Thoracic interaction with the predeformed door was not well captured by the 3D IR-Traccs; hence, use of deflection as an injury predictor in oblique loading is insufficient for evaluating injury risk in this load case. However, injury risk evaluation may be performed using the strain measurements, which characterize loading from seat belt and airbag as well as the lateral contribution of the structural impact in the loading condition used in this study.

Assessment of an innovative seat belt with independent control of the shoulder and lap portions using THOR tests, the THUMS model, and PMHS tests

ABSTRACT Objectives: The objective of this study was to determine the potential chest injury benefits and influence on occupant kinematics of a belt system with independent control of the shoulder and lap portions. Methods: This article investigates the kinematics and dynamics of human surrogates in 35 km/h impacts with 2 different restraints: a pretensioning (PT), force-limiting (FL) seat belt, a reference belt system, and a concept design with a split buckle consisting (SB) of 2 separate shoulder and lap belt bands. The study combines mathematical simulations with the THOR dummy and THUMS human body model, and mechanical tests with the THOR dummy and 2 postmortem human surrogate (PMHS) tests of similar age (39 and 42 years) and anthropometry (62 kg, 181 cm vs. 60 kg, 171.5 cm). The test setup consisted of a rigid metallic frame representing a standard seating position of a right front passenger. The THOR dummy model predictions were compared to the mechanical THOR dummy test results. The THUMS-predicted number of fractured ribs were compared to the number of fractured ribs in the PMHS. Results: THOR sled tests showed that the SB seat belt system decreased chest deflection significantly without increasing the forward displacement of the head. The THOR model and the THOR physical dummy predicted a 13- and 7-mm reduction in peak chest deflection, respectively. Peak diagonal belt force in the mechanical test with the reference belt was 5,582 N and the predicted force was 4,770 N. The THOR model also predicted lower belt forces with the SB system than observed in the tests (5,606 vs. 6,085 N). THUMS predicted somewhat increased head displacement for the SB system compared to the reference system. Peak diagonal force with the reference belt was 4,000 N and for the SB system it was 5,200 N. The PMHS test with the SB belt resulted in improved kinematics and a smaller number of rib fractures (2 vs. 5 fractures) compared to the reference belt. Conclusion: Concepts for a belt system that can reduce the load on the chest of the occupant in a crash and thereby reduce the number of injured occupants, in particular the elderly, was proposed.

Assessment of Bilateral Thoracic Loading on the Near-Side Occupant Due to Occupant-to-Occupant Interaction in Vehicle Crash Tests

Objective: This study aims, by means of the WorldSID 50th percentile male, to evaluate thoracic loading and injury risk to the near-side occupant due to occupant-to-occupant interaction in combination with loading from an intruding structure. Method: Nine vehicle crash tests were performed with a 50th percentile WorldSID male dummy in the near-side (adjacent to the intruding structure) seat and a THOR or ES2 dummy in the far-side (opposite the intruding structure) seat. The near-side seated WorldSID was equipped with 6 + 6 IR-Traccs (LH and RH) in the thorax/abdomen enabling measurement of bilateral deflection. To differentiate deflection caused by the intrusion, and the deflection caused by the neighboring occupant, time history curves were analyzed. The crash tests were performed with different modern vehicles, equipped with thorax side airbags and inflatable curtains, ranging from a compact car to a large sedan, and in different loading conditions such as car-to-car, barrier, and pole tests. Lateral delta V based on vehicle tunnel acceleration and maximum residual intrusion at occupant position were used as a measurement of crash severity to compare injury measurements. Result: In the 9 vehicle crash tests, thoracic loading, induced by the intruding structure as well as from the far-side occupant, varied due to the size and structural performance of the car as well as the severity of the crash. Peak deflection on the thoracic outboard side occurred during the first 50 ms of the event. Between 70 to 150 ms loading induced by the neighboring occupant occurred and resulted in an inboard-side peak deflection and viscous criterion. In the tests where the target vehicle lateral delta V was below 30 km/h and intrusion less than 200 mm, deflections were low on both the outboard (20–40 mm) and inboard side (10–15 mm). At higher crash severities, delta V 35 km/h and above as well as intrusions larger than 350 mm, the inboard deflections (caused by interaction to the far-side occupant) were of the same magnitude or even higher (30–70 mm) than the outboard deflections (30–50 mm). Conclusion: A WorldSID 50th percentile male equipped with bilateral IR-Traccs can detect loading to the thorax from a neighboring occupant making injury risk assessment feasible for this type of loading. At crash severities resulting in a delta V above 35 km/h and intrusions larger than 350 mm, both the inboard deflection and VC resulted in high risks of Abbreviated Injury Scale (AIS) 3+ injury, especially for a senior occupant.