Dana C. Hammell

Programmable transdermal drug delivery of nicotine using carbon nanotube membranes

Carbon nanotube (CNT) membranes were employed as the active element of a switchable transdermal drug delivery device that can facilitate more effective treatments of drug abuse and addiction. Due to the dramatically fast flow through CNT cores, high charge density, and small pore dimensions, highly efficient electrophoretic pumping through functionalized CNT membrane was achieved. These membranes were integrated with a nicotine formulation to obtain switchable transdermal nicotine delivery rates on human skin (in vitro) and are consistent with a Fickian diffusion in series model. The transdermal nicotine delivery device was able to successfully switch between high (1.3 ± 0.65 μmol/hr-cm2) and low (0.33 ± 0.22 μmol/hr-cm2) fluxes that coincide with therapeutic demand levels for nicotine cessation treatment. These highly energy efficient programmable devices with minimal skin irritation and no skin barrier disruption would open an avenue for single application long-wear patches for therapies that require variable or programmable delivery rates.

Transdermal delivery of bupropion and its active metabolite, hydroxybupropion: a prodrug strategy as an alternative approach

This investigation includes an evaluation of the percutaneous absorption of bupropion (BUP) and hydroxybupropion (BUPOH) in vitro and in vivo. In addition, a carbamate prodrug of BUPOH (But-BUPOH) was evaluated in vitro. In vitro diffusion studies were conducted in a flow-through diffusion cell system. The in vitro mean steady-state flux of BUP was significantly higher (p < 0.001) compared to BUPOH (320 +/- 16 nmol cm(-2) h(-1) vs. 27 +/- 4 nmol cm(-2) h(-1)). Additionally, a good correlation existed between in vitro and in vivo results. Mean steady-state plasma concentrations of 442 +/- 32 ng/mL and125 +/- 18 ng/mL were maintained over 48 h after topical application of BUP and BUPOH in hairless guinea pigs in vivo, respectively. Although BUP traversed human skin at rates sufficient to achieve required plasma levels, it is chemically unstable and hygroscopic, and unsuitable for transdermal formulation. On the other hand, BUPOH is stable but its transport across skin is much slower. Alternatively, the prodrug But-BUPOH was found to be stable, and also provided a 2.7-fold increase in the transdermal flux of BUPOH across human skin in vitro. Thus, But-BUPOH provides a viable option for the transdermal delivery of BUPOH.

Transdermal delivery of the synthetic cannabinoid WIN 55,212-2: In vitro/in vivo correlation

AbstractPurpose. The aim of the current investigation was to evaluate the percutaneous absorption of the synthetic cannabinoid WIN 55,212-2 in vitro and in vivo. Methods. The in vitro permeation studies of WIN 55,212-2 in human skin, hairless guinea pig skin, a polymer membrane with adhesive, and a skin/polymer membrane composite were conducted in flow-through diffusion cells. The pharmacokinetic parameters for WIN 55,212-2 were determined after intravenous administration and topical application of Hill Top Chambers and transdermal therapeutic systems (TTS) in guinea pigs. Results. The in vitro permeation studies indicated that the flux of WIN 55,212-2 through hairless guinea pig skin was 1.2 times more than that through human skin. The flux of WIN 55,212-2 through human and guinea pig skin was not significantly higher than that through the corresponding skin/polymer membrane composites. The mean guinea pig steady-state plasma concentrations after topical 6.3 cm2 chamber and 14.5 cm2 TTS patch applications were 5.0 ng/ml and 8.6 ng/ml, respectively. Conclusions. The topical drug treatments provided significant steady-state plasma drug levels for 48 h. The observed in vivo results from the Hill Top Chambers and TTS patches in the guinea pigs were in good agreement with the predicted plasma concentrations from the in vitro data.

In vivo evaluation of a transdermal codrug of 6-β-naltrexol linked to hydroxybupropion in hairless guinea pigs

6-Beta-naltrexol is the major active metabolite of naltrexone, NTX, a potent mu-opioid receptor antagonist used in the treatment of alcohol dependence and opioid abuse. Compared to naloxone, NTX has a longer duration of action largely attributed to 6-beta-naltrexol. This study was carried out in order to determine percutaneous absorption of a transdermal codrug of naltrexol, 6-beta-naltrexol-hydroxybupropion codrug (CB-NTXOL-BUPOH), in hairless guinea pigs as well as to evaluate the safety of 6-beta-naltrexol for development as a transdermal dosage form. This codrug may be useful in the simultaneous treatment of alcohol dependence and tobacco addiction. The carbonate codrug traversed the skin at a faster rate than 6-beta-naltrexol. 6-Beta-naltrexol equivalent steady state plasma concentrations of 6.4 ng/ml were obtained after application of the codrug as compared to 1.2 ng/ml from 6-beta-naltrexol base. The steady state plasma concentration of hydroxybupropion after codrug application was 6.9 ng/ml. Skin sensitization and irritation tested in the hairless guinea pigs using the Buehler method revealed that 6-beta-naltrexol had no skin sensitizing potential. The method was validated with a known sensitizer, p-phenylenediamine, which induced sensitization in 90% of the animals. 6-beta-Naltrexol caused only mild transient skin irritation after the initial application of the patch. During subsequent applications, erythema was slightly increased but no skin damage was observed. In conclusion, a transdermal codrug of 6-beta-naltrexol could be a viable alternative treatment for alcohol and opiate abuse.

Human skin permeation of Δ8‐tetrahydrocannabinol, cannabidiol and cannabinol

The purpose of this study was to quantify the in‐vitro human skin transdermal flux of Δ8‐tetrahydrocannabinol (Δ8‐THC), cannabidiol (CBD) and cannabinol (CBN). These cannabinoids are of interest because they are likely candidates for transdermal combination therapy. Differential thermal analysis and in‐vitro diffusion studies with human tissue were completed for the compounds. Heats of fusion, melting points and relative thermodynamic activities were determined for the crystalline compounds, CBD and CBN. Flux, permeability, tissue concentration and lag times were measured in the diffusion experiments. CBN had a lower heat of fusion and corresponding higher calculated relative thermodynamic activity than CBD. Ethanol concentrations of 30 to 33% significantly increased the transdermal flux of Δ8‐THC and CBD. Tissue concentrations of Δ8‐THC were significantly higher than for CBN. Lag times for CBD were significantly smaller than for CBN. The permeabilities of CBD and CBN were 10‐fold higher than for Δ8‐THC. Combinations of these cannabinoids with ethanol will be further studied in transdermal patch formulations in vitro and in vivo, as significant flux levels of all the drugs were obtained. CBD, the most polar of the three drugs, and other more polar cannabinoids will also be the focus of future drug design studies for improved transdermal delivery rates.

Transdermal delivery of cannabidiol attenuates binge alcohol-induced neurodegeneration in a rodent model of an alcohol use disorder

Excessive alcohol consumption, characteristic of alcohol use disorders, results in neurodegeneration and behavioral and cognitive impairments that are hypothesized to contribute to the chronic and relapsing nature of alcoholism. Therefore, the current study aimed to advance the preclinical development of transdermal delivery of cannabidiol (CBD) for the treatment of alcohol-induced neurodegeneration. In Experiment 1, 1.0%, 2.5% and 5.0% CBD gels were evaluated for neuroprotection. The 5.0% CBD gel resulted in a 48.8% reduction in neurodegeneration in the entorhinal cortex assessed by Fluoro-Jade B (FJB), which trended to statistical significance (p=0.069). Treatment with the 5.0% CBD gel resulted in day 3 CBD plasma concentrations of ~100.0 ng/mL so this level was used as a target concentration for development of an optimized gel formulation. Experiment 2 tested a next generation 2.5% CBD gel formulation, which was compared to CBD administration by intraperitoneal injection (IP; 40.0 mg/kg/day). This experiment found similar magnitudes of neuroprotection following both routes of administration; transdermal CBD decreased FJB+ cells in the entorhinal cortex by 56.1% (p<0.05), while IP CBD resulted in a 50.6% (p<0.05) reduction in FJB+ cells. These results demonstrate the feasibility of using CBD transdermal delivery systems for the treatment of alcohol-induced neurodegeneration.

Cannabidiol bioavailability after nasal and transdermal application: effect of permeation enhancers

Context: The nonpsychoactive cannabinoid, cannabidiol (CBD), has great potential for the treatment of chronic and ‘breakthrough’ pain that may occur in certain conditions like cancer. To fulfill this goal, suitable noninvasive drug delivery systems need to be developed for CBD. Chronic pain relief can be best achieved through the transdermal route, whereas ‘breakthrough’ pain can be best alleviated with intranasal (IN) delivery. Combining IN and transdermal delivery for CBD may serve to provide patient needs-driven treatment in the form of a nonaddictive nonopioid therapy. Objective: Herein we have evaluated the IN and transdermal delivery of CBD with and without permeation enhancers. Materials and Methods: In vivo studies in rats and guinea pigs were carried out to assess nasal and transdermal permeation, respectively. Results: CBD was absorbed intranasally within 10 minutes with a bioavailability of 34–46%, except with 100% polyethylene glycol formulation in rats. Bioavailability did not improve with enhancers. The steady-state plasma concentration of CBD in guinea pigs after transdermal gel application was 6.3 ± 2.1 ng/mL, which was attained at 15.5 ± 11.7 hours. The achievement of a significant steady-state plasma concentration indicates that CBD is useful for chronic pain treatment through this route of administration. The steady-state concentration increased by 3.7-fold in the presence of enhancer. A good in vitro and in vivo correlation existed for transdermal studies. Conclusion: The results of this study indicated that CBD could be successfully delivered through the IN and transdermal routes.

HUMAN SKIN PERMEATION OF 3-O-ALKYL CARBAMATE PRODRUGS OF NALTREXONE

N-Monoalkyl and N,N-dialkyl carbamate prodrugs of naltrexone (NTX), an opioid antagonist, were synthesized and their in vitro permeation across human skin was determined. Relevant physicochemical properties were also determined. Most prodrugs exhibited lower melting points, lower aqueous solubilities, and higher oil solubilities than NTX. The flux values from N-monoalkyl carbamate prodrugs were significantly higher than those from NTX and N,N-dialkyl carbamates. The melting points of N-monoalkyl carbamate prodrugs were quite low compared to the N,N-dialkyl carbamate prodrugs and NTX. Heats of fusion for the N,N-dialkyl carbamate prodrugs were higher than that for NTX. N-Monoalkyl carbamate prodrugs had higher stratum corneum/vehicle partition coefficients than their N,N-dialkyl counterparts. Higher percent prodrug bioconversion to NTX in skin appeared to be related to increased skin flux. N,N-Dialkyl carbamate prodrugs were more stable in buffer and in plasma than N-monoalkyl carbamate prodrugs. In conclusion, N-monoalkyl carbamate prodrugs of NTX improved the systemic delivery of NTX across human skin in vitro. N,N-Dialkyl substitution in the prodrug moiety decreased skin permeation and plasma hydrolysis to the parent drug. The cross-sectional area of the carbamate head group was the major determinant of flux of the N-monoalkyl and N,N-dialkyl carbamate prodrugs of NTX.

Development of a codrug approach for sustained drug delivery across microneedle-treated skin

Microneedle (MN) enhanced transdermal drug delivery enables the transport of a host of molecules that cannot be delivered across the skin by passive diffusion alone. However, the skin being a self-regenerating organ heals itself and thus prevents delivery of molecules through micropores for a 7-day time period, the ideal transdermal delivery goal. Hence, it is necessary to employ a second drug molecule, a cyclooxygenase inhibitor to enhance pore lifetime by decreasing local subclinical inflammatory response following MN treatment. A codrug approach using a 3-O-ester codrug of the model drug naltrexone (NTX) with diclofenac (DIC), a cyclooxygenase inhibitor, was tested in vitro as well as in vivo to look at stability, bioconversion and permeation. The results indicated that the approach could be useful for transdermal drug delivery of NTX from a single patch for a week, but stability and solubility optimization will be required for the codrug before it can deliver significant levels of NTX into the plasma. The skin concentration of DIC was high enough to keep the pores open in vivo in a hairless guinea pig model as demonstrated by day seven pore visualization studies.

Near-Infrared Spectrometry for the Quantification of Dermal Absorption of Econazole Nitrate and 4-Cyanophenol

PurposeThe purpose of this study was to demonstrate the utility of near-infrared (NIR) spectroscopy for the in vitro quantification of econazole nitrate (EN) and 4-cyanophenol (4-CP) in hairless guinea pig skin.MethodsNIR spectra were collected from each of the following: EN and 4-CP powders, EN and 4-CP in solution, and skin samples following topical exposure to either 4-CP in water or EN in propylene glycol and topical creams. To predict drug concentration from NIR spectra, principal component regression (PCR), interval PCR, and uninformative variable elimination PCR were each used with a leave-one-out cross-validation, and results were compared. NIR results were validated against known skin concentrations measured by high-pressure liquid chromatography (HPLC) analysis of solvent extracts.ResultsNIR results matched the HPLC results for the quantification of 4-CP and EN in skin exposed to saturated solutions and topical creams with an r2 > 0.90, a standard error of estimation <7.0%, and a standard error of performance <8.0%.ConclusionThis experiment demonstrated that NIR closely parallels results obtained from tissue extraction and HPLC analysis, proving its potential utility for the rapid and noninvasive determination of topical bioavailability/bioequivalence of EN and quantification of the model chemical 4-CP. Investigation of drugs in human skin is now justified.