Difang Zhang

Effects of aeration rate on maturity and gaseous emissions during sewage sludge composting.

This study investigated effects of aeration rate (AR) on maturity and gaseous emissions during sewage sludge composting, sewage sludge and corn stalks as the bulking agent were co-composted at different ARs (0.1, 0.2, 0.3L·kg(-1) dry matter (DM)·min(-1)). The thermophilic phase for the low and moderate AR treatments was able meet sanitation requirements, but too short to meet sanitation requirements in the high AR treatment. The high AR treatment was significantly different from the other treatments, and had the lowest electrical conductivity and highest E4/E6(absorbance ratio of wavelength 465 and 665nm). The AR influences the nitrogen variations; high AR compost had the highest NH4(+)-N content and lowest NOx(-)-N content. The AR was the main factor influencing compost stability, but the AR had little impact on pH and the germination index. The moderate AR treatment had the highest NH3 emissions during composting, while the low AR treatment had the highest CH4 and N2O emissions. Based on our comprehensive investigation, the recommended AR for sludge composting is 0.2L·kg(-1) DM·min(-1).

Influence of aeration on volatile sulfur compounds (VSCs) and NH3 emissions during aerobic composting of kitchen waste

This study investigates the influence of aeration on volatile sulfur compounds (VSCs) and ammonia (NH3) emissions during kitchen waste composting. Aerobic composting of kitchen waste and cornstalks was conducted at a ratio of 85:15 (wet weight basis) in 60L reactors for 30days. The gas emissions were analyzed with force aeration at rates of 0.1 (A1), 0.2 (A2) and 0.3 (A3) L (kgDMmin)-1, respectively. Results showed that VSCs emission at the low aeration rate (A1) was more significant than that at other two rates (i.e., A2 and A3 treatment), where no considerable emission difference was observed. On the other hand, NH3 emission reduced as the aeration rate decreased. It is noteworthy that the aeration rate did not significantly affect the compost quality. These results suggest that the aeration rate of 0.2L (kgDMmin)-1 may be applied to control VSCs and NH3 emissions during kitchen waste composting.

Use of additive and pretreatment to control odors in municipal kitchen waste during aerobic composting

The effects of adding a bulking agent and chemically pretreating municipal kitchen waste before aerobic composting were studied using a laboratory-scale system. The system used 20-L reactors and each test lasted 28days. The objective was to decrease NH3 and H2S emissions during composting. The bulking agent, dry cornstalks, was mixed with the kitchen waste to give a mixture containing 15% (wet weight) bulking agent. A combined treatment was also conducted, in which kitchen waste mixed with the bulking agent was pretreated with ferric chloride (FeCl3). Less leachate was produced by the composted kitchen waste mixed with bulking agent than by the kitchen waste alone, when the materials had reached the required maturity. The presence of cornstalks also caused less H2S to be emitted, but had little impact on the amount of NH3 emitted. The FeCl3 was found to act as an effective chemical flocculant, and its presence significantly decreased the amounts of NH3 and H2S emitted. Kitchen waste mixed with cornstalks and treated with FeCl3 emitted 42% less NH3 and 76% less H2S during composting than did pure kitchen waste.

Control of dimethyl sulfide and dimethyl disulfide odors during pig manure composting using nitrogen amendment

Effects of nitrogen electron acceptors on dimethyl sulfide (Me2S) and dimethyl disulfide (Me2SS) odor emission during composting was investigated. The chemicals and doses used included sodium nitrate (NO3- at 10mM, 20mM and 40mM), sodium nitrite (NO2- at 10mM, 20mM and 40mM) and sodium nitrite (10mM, 20mM and 40mM) with hexaammonium heptamolybdate tetrahydrate (HHT). The results showed that the addition of these chemicals restricted the emission of Me2S and Me2SS. The emission reduction effect of NO2- was greater than NO3- at the same dosage. A greater reduction was observed when HHT was also added. With 2mM HHT+40mM NO2- addition, the emission of Me2S and Me2SS was reduced by 92.3% and 82.3%, respectively. Comparison of compost maturity indices for treated and untreated composts indicated that none of the additives adversely affected compost quality. These results indicate that nitrogen chemical addition may provide an efficient method to control sulfur odors during composting.

Solid state anaerobic co-digestion of tomato residues with dairy manure and corn stover for biogas production

Solid-state anaerobic co-digestion of tomato residues with dairy manure and corn stover was conducted at 20% total solids under 35°C for 45days. Results showed digestion of mixed tomato residues with dairy manure and corn stover improved methane yields. The highest VS reduction (46.2%) and methane yield (415.4L/kg VSfeed) were achieved with the ternary mixtures of 33% corn stover, 54% dairy manure, and 13% tomato residues, lead to a 0.5-10.2-fold higher than that of individual feedstocks. Inhibition of volatile fatty acids (VFAs) to biogas production occurred when more than 40% tomato residues were added. The results indicated that ternary mixtures diluted the inhibitors that would otherwise cause inhibition in the digestion of tomato residues as a mono-feedstock.

Effects of mix ratio, moisture content and aeration rate on sulfur odor emissions during pig manure composting

Sulfur compounds in swine manure can cause odor emissions during composting if conditions are not conducive to their rapid oxidation and degradation. In this study, the effects of controllable composting process variables on sulfur odor emissions were investigated. These included pig manure to corn stalk mix ratio (0.7:1, 1.5:1 and 2.2:1dw basis), initial moisture content (60%, 65%, 70% and 75%) and aeration rate (1.0, 2.0, 3.0 and 4.0m(3)m(-3)h(-1)). The compounds measured were carbonyl sulfide, carbon disulfide, hydrogen sulfide, methyl mercaptan, ethyl mercaptan, diethyl sulfide, dimethyl sulfide (Me2S) and dimethyl disulfide (Me2SS). The results showed that total sulfur losses ranged from 3.9% to 18.3% after 26days of composting. Me2S and Me2SS were the primary (>59.61%) sulfur compounds released during this period. After turning, emission rates of both Me2S and Me2SS increased. Emissions of the other six sulfur compounds were low and inconsistent during composting. Within the compost, feedstock mix ratio significantly influenced the concentration of Me2SS, while aeration rate significantly affected Me2S concentration (p<0.05). Moisture content did not have a significant effect on the concentrations of either of these two compounds. Concentrations of sulfur odor compounds were the lowest at the highest aeration rate. Therefore, high aeration rates during the thermophilic phase, especially after turning, are recommended to minimize sulfur odors produced during swine manure composting.

Seed germination test for toxicity evaluation of compost: Its roles, problems and prospects

Compost is commonly used for the growth of plants and the remediation of environmental pollution. It is important to evaluate the quality of compost and seed germination test is a powerful tool to examine the toxicity of compost, which is the most important aspect of the quality. Now the test is widely adopted, but the main problem is that the test results vary with different methods and seed species, which limits the development and application of it. The standardization of methods and the modelization of seeds can contribute to solving the problem. Additionally, according to the probabilistic theory of seed germination, the error caused by the analysis and judgment methods of the test results can be reduced. Here, we reviewed the roles, problems and prospects of the seed germination test in the studies of compost.

Effects of adding bulking agents on biostabilization and drying of municipal solid waste

The influence of adding a bulking agent on the bio-stabilization and drying of municipal solid waste (MSW) was investigated. Three treatments were considered: the addition of either cornstalks or wood peat to MSW as a bulking agent before bio-drying and a control treatment that contained no bulking agent. Addition of bulking agents to MSW produced less leachate, higher moisture-removal rates, and consumed less volatile solids. Bulking with cornstalks achieved the highest water-removal rate (0.58-0.65kgkg-1). The extent of organic degradation was related to temperature integration during bio-drying. Lipids and cellulose were the main components of organic losses in all treatments and adding a bulking agent changed the sequence and extent of degradation of biochemical components. The bio-drying index values were 1.75, 3.18, and 2.64 for MSW alone, MSW with cornstalks, and MSW with wood peat, respectively. Evaporation heat was the main component of heat consumption, accounting for 58.1-60.7% of the total energy consumption.

Performance of co-composting sewage sludge and organic fraction of municipal solid waste at different proportions

In this study, the co-composting performance of sewage sludge (SS) and organic fraction of municipal solid waste (OFMSW) at different proportions was investigated. Cornstalk was added at 15% (of total wet weight) to improve the co-composting process. Results show that higher SS proportion could rapidly initialize the co-composting process; while increasing OFMSW percentage enhanced organic content for biodegradation, thus prolonging the thermophilic period and increasing the humification degree during co-composting. However, excessive OFMSW required longer co-composting period to ensure a desirable compost maturity and quality. Over 15days of rapid co-composting, adding 55-85% OFMSW aggravated compost quality by increasing the compost salinity (3.5-4.6mScm-1) and plant toxicity (indicated by the low germination index of 54.1-77.3%). Moreover, different proportions of SS and OFMSW varied gaseous emissions during co-composting. Our results suggested that OFMSW should be less than 55% for rapid co-composting with SS and cornstalk.

Effects of woody peat and superphosphate on compost maturity and gaseous emissions during pig manure composting

This study investigated the effect of calcium superphosphate on compost maturity and gaseous emissions during pig manure composting with woody peat as the bulking agent. Two treatments were conducted with or without the addition of calcium superphosphate (10% dry weight of the composting mass), which were denoted as the control and superphosphate-amended treatment, respectively. Results show that the composting temperature of both treatments was higher than 50°C for more than 5days, which is typically required for pathogen destruction during manure composting. Compared to the control treatment, the superphosphate-amended treatment increased the emission of nitrogen oxide, but reduced the emission of methane, ammonia and hydrogen sulfide by approximately 35.5%, 37.9% and 65.5%, respectively. As a result, the total greenhouse gas (GHG) emission during manure composting was reduced by nearly 34.7% with the addition of calcium superphosphate. The addition of calcium superphosphate increased the content of humic acid (indicated by E4/E6 ratio). Nevertheless, the superphosphate-amended treatment postponed the biological degradation of organic matter and produced the mature compost with a higher electrical conductivity in comparison with the control treatment.