Eduardo Ximenes

Deactivation of cellulases by phenols

Pretreatment of lignocellulosic materials may result in the release of inhibitors and deactivators of cellulose enzyme hydrolysis. We report the identification of phenols with major inhibition and/or deactivation effect on enzymes used for conversion of cellulose to ethanol. The inhibition effects were measured by combining the inhibitors (phenols) with enzyme and substrate immediately at the beginning of the assay. The deactivation effects were determined by pre-incubating phenols with cellulases or β-glucosidases for specified periods of time, prior to the respective enzyme assays. Tannic, gallic, hydroxy-cinnamic, and 4-hydroxybenzoic acids, together with vanillin caused 20-80% deactivation of cellulases and/or β-glucosidases after 24h of pre-incubation while enzymes pre-incubated in buffer alone retained all of their activity. The strength of the inhibition or deactivation effect depended on the type of enzyme, the microorganism from which the enzyme was derived, and the type of phenolic compounds present. β-Glucosidase from Aspergillus niger was the most resistant to inhibition and deactivation, requiring about 5 and 10-fold higher concentrations, respectively, for the same levels of inhibition or deactivation as observed for enzymes from Trichoderma reesei. Of the phenol molecules tested, tannic acid was the single, most damaging aromatic compound that caused both deactivation and reversible loss (inhibition) of all of enzyme activities tested.

Soluble inhibitors/deactivators of cellulase enzymes from lignocellulosic biomass.

Liquid hot water, steam explosion, and dilute acid pretreatments of lignocellulose generate soluble inhibitors which hamper enzymatic hydrolysis as well as fermentation of sugars to ethanol. Toxic and inhibitory compounds will vary with pretreatment and include soluble sugars, furan derivatives (hydroxymethyl fulfural, furfural), organic acids (acetic, formic and, levulinic acid), and phenolic compounds. Their effect is seen when an increase in the concentration of pretreated biomass in a hydrolysis slurry results in decreased cellulose conversion, even though the ratio of enzyme to cellulose is kept constant. We used lignin-free cellulose, Solka Floc, combined with mixtures of soluble components released during pretreatment of wood, to prove that the decrease in the rate and extent of cellulose hydrolysis is due to a combination of enzyme inhibition and deactivation. The causative agents were extracted from wood pretreatment liquid using PEG surfactant, activated charcoal or ethyl acetate and then desorbed, recovered, and added back to a mixture of enzyme and cellulose. At enzyme loadings of either 1 or 25mg protein/g glucan, the most inhibitory components, later identified as phenolics, decreased the rate and extent of cellulose hydrolysis by half due to both inhibition and precipitation of the enzymes. Full enzyme activity occurred when the phenols were removed. Hence detoxification of pretreated woods through phenol removal is expected to reduce enzyme loadings, and therefore reduce enzyme costs, for a given level of cellulose conversion.

Disruption of Mediator rescues the stunted growth of a lignin-deficient Arabidopsis mutant

Lignin is a phenylpropanoid-derived heteropolymer important for the strength and rigidity of the plant secondary cell wall. Genetic disruption of lignin biosynthesis has been proposed as a means to improve forage and bioenergy crops, but frequently results in stunted growth and developmental abnormalities, the mechanisms of which are poorly understood. Here we show that the phenotype of a lignin-deficient Arabidopsis mutant is dependent on the transcriptional co-regulatory complex, Mediator. Disruption of the Mediator complex subunits MED5a (also known as REF4) and MED5b (also known as RFR1) rescues the stunted growth, lignin deficiency and widespread changes in gene expression seen in the phenylpropanoid pathway mutant ref8, without restoring the synthesis of guaiacyl and syringyl lignin subunits. Cell walls of rescued med5a/5b ref8 plants instead contain a novel lignin consisting almost exclusively of p-hydroxyphenyl lignin subunits, and moreover exhibit substantially facilitated polysaccharide saccharification. These results demonstrate that guaiacyl and syringyl lignin subunits are largely dispensable for normal growth and development, implicate Mediator in an active transcriptional process responsible for dwarfing and inhibition of lignin biosynthesis, and suggest that the transcription machinery and signalling pathways responding to cell wall defects may be important targets to include in efforts to reduce biomass recalcitrance.

Lignin monomer composition affects Arabidopsis cell-wall degradability after liquid hot water pretreatment

BackgroundLignin is embedded in the plant cell wall matrix, and impedes the enzymatic saccharification of lignocellulosic feedstocks. To investigate whether enzymatic digestibility of cell wall materials can be improved by altering the relative abundance of the two major lignin monomers, guaiacyl (G) and syringyl (S) subunits, we compared the degradability of cell wall material from wild-type Arabidopsis thaliana with a mutant line and a genetically modified line, the lignins of which are enriched in G and S subunits, respectively.ResultsArabidopsis tissue containing G- and S-rich lignins had the same saccharification performance as the wild type when subjected to enzyme hydrolysis without pretreatment. After a 24-hour incubation period, less than 30% of the total glucan was hydrolyzed. By contrast, when liquid hot water (LHW) pretreatment was included before enzyme hydrolysis, the S-lignin-rich tissue gave a much higher glucose yield than either the wild-type or G-lignin-rich tissue. Applying a hot-water washing step after the pretreatment did not lead to a further increase in final glucose yield, but the initial hydrolytic rate was doubled.ConclusionsOur analyses using the model plant A. thaliana revealed that lignin composition affects the enzymatic digestibility of LHW pretreated plant material. Pretreatment is more effective in enhancing the saccharification of A. thaliana cell walls that contain S-rich lignin. Increasing lignin S monomer content through genetic engineering may be a promising approach to increase the efficiency and reduce the cost of biomass to biofuel conversion.

Effect of liquid hot water pretreatment severity on properties of hardwood lignin and enzymatic hydrolysis of cellulose.

Lignin, one of the major components of lignocellulosic biomass, plays an inhibitory role on the enzymatic hydrolysis of cellulose. This work examines the role of lignin in pretreated hardwood, where extents of cellulose hydrolysis decrease, rather than increase with increasing severity of liquid hot water pretreatment. Hardwood pretreated with liquid hot water at severities ranging from log Ro = 8.25 to 12.51 resulted in 80–90% recovery of the initial lignin in the residual solids. The ratio of acid insoluble lignin (AIL) to acid soluble lignin (ASL) increased and the formation of spherical lignin droplets on the cell wall surface was observed as previously reported in the literature. When lignins were isolated from hardwoods pretreated at increasing severities and characterized based on glass transition temperature (Tg), the Tg of isolated lignins was found to increase from 171 to 180°C as the severity increased from log Ro = 10.44 to 12.51. The increase in Tg suggested that the condensation reactions of lignin molecules occurred during pretreatment and altered the lignin structure. The contribution of the changes in lignin properties to enzymatic hydrolysis were examined by carrying out Avicel hydrolysis in the presence of isolated lignins. Lignins derived from more severely pretreated hardwoods had higher Tg values and showed more pronounced inhibition of enzymatic hydrolysis. Biotechnol. Bioeng. 2015;112: 252–262.

Adsorption of enzyme onto lignins of liquid hot water pretreated hardwoods

The adsorption of cellulase enzymes onto lignin is shown to be non‐productive and therefore reduces enzymatic hydrolysis of liquid hot water pretreated cellulose. Among the enzyme components of Trichoderma reesei cellulase cocktail, β‐glucosidase showed the strongest adsorption onto lignin. Only 2–18% of the initial β‐glucosidase activity remained in the supernatant while 50–60% of cellobiohydrolase and endoglucanase activities were recovered after incubation with lignin. By increasing the pH to 5.5 and adding NaCl to a 200 mM, the free enzymes in the supernatant were increased but hydrolysis was not enhanced since optimal pH for enzymatic hydrolysis is at 4.8. Electrostatic interactions contributed to enzyme adsorption and their effect was most pronounced for T. reesei β‐glucosidase which had high molecular weights (78–94 kDa) and high isoelectric points (pI 5.7–6.4). Since the enzyme components which are required to synergistically hydrolyze cellulose have different profiles (molecular weight, hydrophobicity and pI), they exhibit different adsorption behaviors with lignin, and thereby change the ratio of enzyme activities needed for synergism during cellulose hydrolysis. β‐glucosidase from Aspergillus niger exhibits less adsorption than β‐glucosidase from T. reesei. Supplemental addition of A. niger β‐glucosidase to the enzyme mixture increases hydrolysis of pretreated hardwood by a factor of two. The analysis presented in this paper shows that lignins with higher guaiacyl content adsorb more cellulase enzymes, particularly β‐glucosidase, and that adsorption of β‐glucosidase onto lignin indirectly suppresses enzymatic hydrolysis of cellulose in pretreated hardwoods due to decreased hydrolysis of cellobiose which in turn accumulates and inhibits CBH. Biotechnol. Bioeng. 2015;112: 447–456.

Tissue‐specific biomass recalcitrance in corn stover pretreated with liquid hot‐water: Enzymatic hydrolysis (part 1)

Lignin content, composition, distribution as well as cell wall thickness, structures, and type of tissue have a measurable effect on enzymatic hydrolysis of cellulose in lignocellulosic feedstocks. The first part of our work combined compositional analysis, pretreatment and enzyme hydrolysis for fractionated pith, rind, and leaf tissues from a hybrid stay‐green corn, in order to identify the role of structural characteristics on enzyme hydrolysis of cell walls. The extent of enzyme hydrolysis follows the sequence rind < leaves < pith with 90% conversion of cellulose to glucose in 24 h in the best cases. Physical fractionation of corn stalks or other C4 grasses into soft and hard tissue types could reduce cost of cellulose conversion by enabling reduced enzyme loadings to hydrolyze soft tissue, and directing the hard tissue to other uses such as thermal processing, combustion, or recycle to the land from which the corn was harvested. Biotechnol. Bioeng. 2012; 109:390–397.

Noncatalytic Docking Domains of Cellulosomes of Anaerobic Fungi

A method is presented for the specific isolation of genes encoding cellulosome components from anaerobic fungi. The catalytic components of the cellulosome of anaerobic fungi typically contain, besides the catalytic domain, mostly two copies of a 40-amino-acid cysteine-rich, noncatalytic docking domain (NCDD) interspaced by short linkers. Degenerate primers were designed to anneal to the highly conserved region within the NCDDs of the monocentric fungus Piromyces sp. strain E2 and the polycentric fungus Orpinomyces sp. strain PC-2. Through PCR using cDNA from Orpinomyces sp. and genomic DNA from Piromyces sp. as templates, respectively, 9 and 19 PCR products were isolated encoding novel NCDD linker sequences. Screening of an Orpinomyces sp. cDNA library with four of these PCR products resulted in the isolation of new genes encoding cellulosome components. An alignment of the partial NCDD sequence information obtained and an alignment of database-accessible NCDD sequences, focusing on the number and position of cysteine residues, indicated the presence of three structural subfamilies within fungal NCDDs. Furthermore, evidence is presented that the NCDDs in CelC from the polycentric fungus Orpinomyces sp. strain PC-2 specifically recognize four proteins in a cellulosome preparation, indicating the presence of multiple scaffoldins.

Manipulation of Guaiacyl and Syringyl Monomer Biosynthesis in an Arabidopsis Cinnamyl Alcohol Dehydrogenase Mutant Results in Atypical Lignin Biosynthesis and Modified Cell Wall Structure

The phenotypes of Arabidopsis plants with altered aldehyde contents and guaiacyl-to-syringyl ratios provide insights into the effects of lignin composition on plant growth and cell wall degradability. Modifying lignin composition and structure is a key strategy to increase plant cell wall digestibility for biofuel production. Disruption of the genes encoding both cinnamyl alcohol dehydrogenases (CADs), including CADC and CADD, in Arabidopsis thaliana results in the atypical incorporation of hydroxycinnamaldehydes into lignin. Another strategy to change lignin composition is downregulation or overexpression of ferulate 5-hydroxylase (F5H), which results in lignins enriched in guaiacyl or syringyl units, respectively. Here, we combined these approaches to generate plants enriched in coniferaldehyde-derived lignin units or lignins derived primarily from sinapaldehyde. The cadc cadd and ferulic acid hydroxylase1 (fah1) cadc cadd plants are similar in growth to wild-type plants even though their lignin compositions are drastically altered. In contrast, disruption of CAD in the F5H-overexpressing background results in dwarfism. The dwarfed phenotype observed in these plants does not appear to be related to collapsed xylem, a hallmark of many other lignin-deficient dwarf mutants. cadc cadd, fah1 cadc cadd, and cadd F5H-overexpressing plants have increased enzyme-catalyzed cell wall digestibility. Given that these CAD-deficient plants have similar total lignin contents and only differ in the amounts of hydroxycinnamaldehyde monomer incorporation, these results suggest that hydroxycinnamaldehyde content is a more important determinant of digestibility than lignin content.

Tissue‐specific biomass recalcitrance in corn stover pretreated with liquid hot‐water: SEM imaging (part 2)

In the first part of our work, we combined compositional analysis, pretreatment and enzyme hydrolysis for fractionated pith, rind, and leaf tissues from a hybrid stay‐green corn, in order to identify the role of structural characteristics on enzyme hydrolysis of cell walls. Hydrolysis experiments coupled with chemical analysis of the different fractions of corn stover showed significant differences in cell wall structure before and after liquid hot water pretreatment. The extent of enzyme hydrolysis followed the sequence rind < leaves < pith with 90% conversion of cellulose to glucose in 24 h in the best cases. Since similar lignin contents remained after liquid hot water pretreatment of leaves, rind, and pith, our results indicated that the amount of lignin alone is not sufficient to explain the different enzymatic hydrolysis characteristics of the fractions. While the role of structural characteristics on enzyme hydrolysis of cell walls is measured as described in part I, the SEM images presented in this part II of our work show that sugar yields from enzymatic hydrolysis of corn fractions correlate with changes in plant cell wall structure both before and after liquid hot water pretreatment. Biotechnol. Bioeng. 2012; 109:398–404.