Estefanía Noriega

Impact of food model (micro)structure on the microbial inactivation efficacy of cold atmospheric plasma

The large potential of cold atmospheric plasma (CAP) for food decontamination has recently been recognized. Room-temperature gas plasmas can decontaminate foods without causing undesired changes. This innovative technology is a promising alternative for treating fresh produce. However, more fundamental studies are needed before its application in the food industry. The impact of the food structure on CAP decontamination efficacy of Salmonella Typhimurium and Listeria monocytogenes was studied. Cells were grown planktonically or as surface colonies in/on model systems. Both microorganisms were grown in lab culture media in petri dishes at 20°C until cells reached the stationary phase. Before CAP treatment, cells were deposited in a liquid carrier, on a solid(like) surface or on a filter. A dielectric barrier discharge reactor generated helium-oxygen plasma, which was used to treat samples up to 10min. Although L. monocytogenes is more resistant to CAP treatment, similar trends in inactivation behavior as for S. Typhimurium are observed, with log reductions in the range [1.0-2.9] for S. Typhimurium and [0.2-2.2] for L. monocytogenes. For both microorganisms, cells grown planktonically are easily inactivated, as compared to surface colonies. More stressing growth conditions, due to cell immobilization, result in more resistant cells during CAP treatment. The main difference between the inactivation support systems is the absence or presence of a shoulder phase. For experiments in the liquid carrier, which exhibit a long shoulder, the plasma components need to diffuse and penetrate through the medium. This explains the higher efficacies of CAP treatment on cells deposited on a solid(like) surface or on a filter. This research demonstrates that the food structure influences the cell inactivation behavior and efficacy of CAP, and indicates that food intrinsic factors need to be accounted when designing plasma treatment.

Effect of cell immobilization on heat-induced sublethal injury of Escherichia coli, Salmonella Typhimurium and Listeria innocua

The occurrence of sublethally injured cells in foods poses major public health concerns and is an essential aspect when assessing the microbial response to food preservation strategies, yet there is limited research dealing with its specific implications for mild heating. All available studies so far have been performed in broths colonized by planktonic cells, although their susceptibility to lethal agents has often been reported to be markedly different to the stress tolerance of cell colonies developed in solid foods. In this work, the effect of planktonic and colony growth, as well as the influence of colony density on sublethal injury induced by mild heating of Escherichia coli, Salmonella Typhimurium and Listeria innocua were assessed in food model systems. Detection of injured survivors relied on their inability to form visible colonies on salt-based selective media, which do not affect the growth of healthy cells. Sublethal injury (SI) increased rapidly with shorter exposure times and afterwards, decreased progressively, suggesting a mechanism of cumulative damage triggering lethal instead of SI. Cell arrangement affected the degree of SI, higher values being generally found for gelified systems, although the effect of colony density depended on the target microorganism. This information is essential for optimizing the design of food safety assurance systems.

Effect of cell immobilization on the growth dynamics of Salmonella Typhimurium and Escherichia coli at suboptimal temperatures

Predictive microbiology has recently acknowledged the impact of the solid(like) food structure on microbial behavior. The presence of this solid(like) structure causes microorganisms to grow as colonies and no longer planktonically as in liquid. In this paper, the growth dynamics of Salmonella Typhimurium and Escherichia coli were studied as a function of temperature, considering different growth morphologies, i.e., (i) planktonic cells, (ii) immersed colonies and (iii) surface colonies. For all three growth morphologies, both microorganisms were grown in petri dishes. While E. coli was grown under optimal pH and water activity (aw), for S. Typhimurium pH and aw were adapted to 5.5 and 0.990. In order to mimic a solid(like) environment, 5% (w/v) gelatin was added. All petri dishes were incubated under static conditions at temperatures in the range [8.0°C-22.0°C]. Cell density was determined via viable plate counting. This work demonstrates that the growth morphology (planktonic vs. colony) has a negligible effect on the growth dynamics as a function of temperature. The observation of almost equal growth rates for planktonic cultures and colonies is in contrast to literature where, mostly, a difference is observed, i.e., μplanktonic cells≥μimmersed colonies≥μsurface colonies. This difference might be due to shaking of the liquid culture in these studies, which results in a nutrient and oxygen rich environment, in contrast to the diffusion-limited gel system. Experiments also indicate that lag phases for solid(like) systems are similar to those for the planktonic cultures, as can be found in literature for similar growth conditions. Considering the maximum cell density, no clear trend was deducted for either of the microorganisms. This study indicates that the growth parameters in the suboptimal temperature range do not depend on the growth morphology. For the considered experimental conditions, models previously developed for liquid environments can be used for solid(like) systems.

Effect of Microstructure on Population Growth Parameters of Escherichia coli in Gelatin-Dextran Systems

ABSTRACT Current literature acknowledges the effect of food structure on bacterial dynamics. Most studies introduce this “structure” factor using a single gelling agent, resulting in a homogeneous environment, whereas in practice most food products are heterogeneous. Therefore, this study focuses on heterogeneous protein-polysaccharide mixtures, based on gelatin and dextran. These mixtures show phase separation, leading to a range of heterogeneous microstructures by adjusting relative concentrations of both gelling agents. Based on confocal microscope observations, the growth of Escherichia coli in gelatin-dextran systems was observed to occur in the dextran phase. To find a relation between microscopic and population behavior, growth experiments were performed in binary and singular gelatin-dextran systems and culture broth at 23.5°C, with or without adding 2.9% (wt/vol) NaCl. The Baranyi and Roberts growth model was fitted to the experimental data and parameter estimates were statistically compared. For salted binary mixtures, a decrease in the population maximum cell density was observed with increasing gelatin concentration. In this series, for one type of microstructure, i.e., a gelatin matrix phase with a disperse dextran phase, the maximum cell density decreased with decreasing percentage of dextran phase. However, this relation no longer held when other types of microstructure were observed. Compared to singular systems, adding a second gelling agent in the presence of NaCl had an effect on population lag phases and maximum cell densities. For unsalted media, the growth parameters of singular and binary mixtures were comparable. Introducing this information into mathematical models leads to more reliable growth predictions and enhanced food safety.

Influence of food intrinsic complexity on Listeria monocytogenes growth in/on vacuum-packed model systems at suboptimal temperatures.

Food intrinsic factors e.g., food (micro)structure, compositional and physicochemical aspects, which are mutually dependent, influence microbial growth. While the effect of composition and physicochemical properties on microbial growth has been thoroughly assessed and characterised, the role of food (micro)structure still remains unravelled. Most studies on food (micro)structure focus on comparing planktonic growth in liquid (microbiological) media with colonial growth in/on solid-like systems or on real food surfaces. However, foods are not only liquids or solids; they can also be emulsions or gelled emulsions and have complex compositions. In this study, Listeria monocytogenes growth was studied on the whole spectrum of (micro)structure, in terms of food (model) systems. The model systems varied not only in (micro)structure, which was the target of the study, but also in compositional and physicochemical characteristics, which was an inevitable consequence of the (micro)structural variability. The compositional and physicochemical differences were mainly due to the presence or absence of fat and gelling agents. The targeted (micro)structures were: i) liquids, ii) aqueous gels, iii) emulsions and iv) gelled emulsions. Furthermore, the microbial dynamics were studied and compared in/on all these model systems, as well as on a compositionally predefined canned meat, developed in order to have equal compositional level to the gelled emulsion model system and represent a real food system. Frankfurter sausages were the targeted real foods, selected as a case study, to which the canned meat had similar compositional characteristics. All systems were vacuum packed and incubated at 4, 8 and 12°C. The most appropriate protocol for the preparation of the model systems was developed. The pH, water activity and resistance to penetration of the model systems were characterised. Results indicated that low temperature contributes to growth variations among the model systems. Additionally, the firmer the solid system, the faster L. monocytogenes grew on it. Finally, it was found that L. monocytogenes grows faster on canned meat and real Frankfurters, as found in a previous study, followed by liquids, aqueous gels, emulsions and gelled emulsions. This observation indicates that all model systems, developed in this study, underestimated L. monocytogenes growth. Despite some limitations, model systems are overall advantageous and therefore, their validation is always recommended prior to further use.

Role of growth morphology in the formulation of NaCl-based selective media for injury detection of Escherichia coli, Salmonella Typhimurium and Listeria innocua

Sublethal injury (SI) poses major public health concerns since injured cells are responsible for serious limitations in food diagnostics and are susceptible to recovery, often developing adaptive stress responses. Detection of SI is based on the difference in plate counts between non-selective media, which represent the total cell population, and selective media, to which injured cells become sensitive. Selective media for detection of sublethal membrane damage are often based on NaCl supplement, although there is a lack of consensus in the literature about appropriate levels. Planktonic cells are generally used to investigate SI mechanisms, although they often exhibit different stress tolerance than cell colonies in/on solid food (model) systems. In this work, the effect of growth morphology, colony size and concentration of the gelling agent in the growth media, on the maximum non-inhibitory NaCl concentration in the plating medium was assessed for Escherichia coli, Salmonella Typhimurium and Listeria innocua. Stationary phase cultures of planktonic cells and large and small colonies grown in either 1.5% (w/v) xanthan gum-based system or 2.5% (w/v) xanthan gum-based system exhibited significantly different viable counts and osmotolerance. The effect of cell arrangement and xanthan gum percentage in the growth media depended on the microorganism under investigation. Additionally, differences in the maximum non-inhibitory concentration were evident, with 5.0% (w/v) NaCl for the Gram-negative bacteria and 6.5% (w/v), for L. innocua. Different extent of colony shrinkage and morphological damage was observed as NaCl concentration in the plating medium increased. This information will contribute to define NaCl-based selective media for accurate SI detection under realistic scenarios.

The effect of medium structure complexity on the growth of Saccharomyces cerevisiae in gelatin–dextran systems

As most food systems are (semi-)solid, the effect of food structure on bacterial growth has been widely acknowledged. However, studies on the growth dynamics of yeasts have neglected the effect of food structure. In this paper, the growth dynamics of the spoilage yeast Saccharomyces cerevisiae was investigated at 23.5 °C in broth, singular, homogeneous biopolymer systems and binary biopolymer systems with a heterogeneous microstructure. The biopolymers gelatin and dextran were used to introduce the different levels of structure. The metabolizing ability of gelatin and dextran by S. cerevisiae was examined. To study microbial behavior in the binary systems at the micro level, mixtures were imaged with confocal laser scanning microscopy (CLSM). Growth dynamics and microscopic images of S. cerevisiae were compared with those obtained for Escherichia coli in the same model system (Boons et al., 2014). Different phase-separated, heterogeneous microstructures were obtained by changing the amount of added gelatin and dextran. Regardless of the microstructure, S. cerevisiae was preferentially located in the dextran phase. Metabolizing ability-tests indicated that gelatin could be consumed by S. cerevisiae but in the presence of glucose, no change in gelatin concentration was observed. No indication of dextran metabolizing ability was observed. When supplementing broth with gelatin or dextran alone, an enhanced growth rate and maximum cell density were observed. This enhancement was further increased by adding a second biopolymer, introducing a heterogeneous microstructure and hence increasing the medium structure complexity. The results obtained indicate that food structure complexity plays a significant role in the growth dynamics of S. cerevisiae, an important food spoiler.

Optimal experimental design for discriminating between microbial growth models as function of suboptimal temperature: From in silico to in vivo

Temperature is an important food preservation factor, affecting microbial growth. Secondary predictive models can be used for describing the impact of this factor on microbial growth. In other words, the microbial behavior can be described in a dynamic environment with the use of a primary and secondary model. Two models for describing the effect of temperature on the microbial growth rate are the cardinal temperature model with inflection (CTMI) (Rosso et al., 1993) and its adapted version (aCTMI) (Le Marc et al., 2002). Although Escherichia coli is commonly modeled using CTMI, there are indications that aCTMI may be more appropriate (Van Derlinden and Van Impe, 2012a). For clarifying this, the method of Optimal experiment design for model discrimination (OED/MD) will be used in this work (Donckels et al., 2009; Schwaab et al., 2008). Results from an in silico study point out the required direction. Whereas the results of the in vivo study give a more realistic answer to the research question. Finally, discrimination unravelled the appropriate model for the needed use.

Stevia-based sweeteners as a promising alternative to table sugar: The effect on Listeria monocytogenes and Salmonella Typhimurium growth dynamics

Sugar is commonly substituted with stevia-based products in food industry and in our daily-life. This substitution results in a change in food product characteristic formula and properties that may affect the growth dynamics of food pathogenic and spoilage bacteria. This work studies the effect of table sugar (TS), laboratory sucrose (LS), commercial stevia (St) and steviol glycosides (SG) on the growth dynamics of Salmonella Typhimurium and Listeria monocytogenes. Experiments were carried out in general and minimal culture media at 3 equivalent concentration levels in terms of sweetness intensity (TS and LS at 3, 9 and 15% (w/v); St at 0.3, 0.9 and 1.5% (w/v); and SG at 0.01, 0.03 and 0.05% (w/v)). Incubation temperatures were: 4, 8 and 20°C for general media, and for minimal media 20°C. To decipher the role of these sweeteners, their concentration evolution in minimal media was determined via HPLC analysis. The results revealed slow maximum specific growth rates (μmax) of S. Typhimurium in general media with increasing concentrations of TS and LS at 20°C; and reduced maximum cell population (Nmax) at 8°C. The growth of L. monocytogenes in general culture media remains invariable independently of the sweetener added, except at 4°C. At this critical temperature, the presence of TS, LS and St seems to facilitate the growth of L. monocytogenes, presenting higher μmax values in comparison to SG and the control. Varying bacterial response to changes in media formulation suggests that further research is required, focusing on revealing the microbial dynamics in structured media, as well as in real food products.