Iwona Konopka

Drying Characteristics of Barley Grain Dried in a Spouted-Bed and Combined IR-Convection Dryers

A study was performed to determine the drying characteristics and quality of barley grain dried in a laboratory scale spouted-bed dryer at 30, 35, 40, and 45°C and an inlet air velocity of 23 m/s−1, and in an IR-convection dryer under an infrared radiation intensity of 0.048, 0.061, 0.073, and 0.107 W cm−2 at an air velocity of 0.5 m/s−1. The results show that the first, relatively short, phase of a sharp decrease in the drying rate was followed by the phase of a slow decrease. The time of barley drying depended on temperature of inlet air in a spouted-bed dryer and on radiation intensities in an IR-convection dryer. Barley drying at 45°C in a spouted-bed dryer was accompanied by the lowest total energy consumption. The average specific energy consumption was lower and the average efficiency of drying was higher for drying in a spouted-bed dryer. The effective diffusivities were in the range 2.20–4.52 × 10−11 m2 s−1 and 3.04–4.79 × 10−11 m2/s−1 for barley dried in a spouted-bed and in an IR-convection dryer, respectively. There were no significant differences in kernel germination energy and capacity between the two drying methods tested.

Comparison of the phenolic compounds, carotenoids and tocochromanols content in wheat grain under organic and mineral fertilization regimes.

A field study was performed to evaluate the effect of mineral (NPK) and organic-based fertilizers such as compost (C), manure (FYM) and meat and bone meal (MBM) on the appearance (dimensions and color) of spring wheat kernels and on the total content in grain of main its phytochemicals (polyphenols, carotenoids and tocochromanols) and phenolic acids composition. Total phenolic compounds were determined using the Folin-Ciocalteu assay after alkaline hydrolysis of grain and carotenoids were analyzed spectrophotometrically. Composition of tocochromanols and phenolic acids was determined using RP-HPLC techniques. Only insignificant differences in the appearance of kernels and small changes in the content and composition of grain phytochemicals were noted between the studied fertilization systems. Among the analyzed phytochemicals the greatest variation was observed in the group of polyphenol compounds, with a stated increase of their total content of 6.7 and 11.2% in grain fertilized with MBM and compost, respectively. Simultaneously the grain from organic fertilization contained significantly less phenolic acids, and the decrease in their content ranged from 10.0% for FYM to 24.8% for MBM+EM-1. Organically and conventionally fertilized grain had similar amounts of tocochromanols and carotenoids. Comparison of MBM and MBM+EM-1 variants showed that application of effective microorganisms decreased carotenoids and tocochromanols content by 8.5 and 9.7%, respectively.

Release of free ferulic acid and changes in antioxidant properties during the wheat and rye bread making process

Changes in the free ferulic acid (FFA) contents and antioxidant properties during bread making processes were determined. Experimental breads were produced from whole meal and white wheat and rye flours, and fermented using either baker’s yeast or sourdough starter. Sourdough fermented bread contained the highest content of FFA. Release of occurred mainly during dough fermentation. A further increase in the ferulic acid content in the bread crumb and a decrease in the crust was observed. Total antioxidant properties of sourdough bread, defined as the sum of lipophilic and hydrophilic compound activities, were significantly (p<0.05) higher than for yeast bread. Sourdough bread contained more methanol soluble phenolic compounds, proteins, tocochromanols, and oxidized products of fatty acids than yeast bread. The equilibrium between the anti- and pro-oxidative compound contents resulted in similar antioxidant properties for bread using both types of fermentation, and to results observed for the flour used for baking.

Optimization of Pumpkin Oil Recovery by Using Aqueous Enzymatic Extraction and Comparison of the Quality of the Obtained Oil with the Quality of Cold-Pressed Oil

The study was carried out to optimize pumpkin oil recovery in the process of aqueous extraction preceded by enzymatic maceration of seeds, as well as to compare the quality of the obtained oil to the quality of cold-pressed pumpkin seed oil. Hydrated pulp of hulless pumpkin seeds was macerated using a 2% (by mass) cocktail of commercial pectinolytic, cellulolytic and proteolytic preparations (Rohapect® UF, Rohament® CL and Colorase® 7089). The optimization procedure utilized response surface methodology based on Box- -Behnken plan of experiment. The optimized variables of enzymatic pretreatment were pH, temperature and maceration time. The results showed that the pH value, temperature and maceration time of 4.7, 54 °C and 15.4 h, respectively, were conducive to maximize the oil yield up to 72.64%. Among these variables, the impact of pH was crucial (above 73% of determined variation) for oil recovery results. The oil obtained by aqueous enzymatic extraction was richer in sterols, squalene and tocopherols, and only slightly less abundant in carotenoids than the cold-pressed one. However, it had a lower oxidative stability, with induction period shortened by approx. 30% in relation to the cold-pressed oil.

Sensory, Physico-Chemical and Water Sorption Properties of Corn Extrudates Enriched with Spirulina

This study compares the quality of extrudates made from corn grits with the addition of up to 8% of spirulina powder. The sensory properties (shape, color, aroma, taste and crispness), chemicals (content of water, protein, fat, ash, fiber, carbohydrates, carotenoids, chlorophyll and phycocyanin) and physical properties (color, water absorption index, expansion indices, texture and water sorption properties) were determined. It has been found that spirulina-enriched extrudates had slightly lower sensory scores, but the addition of spirulina improved their nutritional value. The contents of protein, ash, fiber and β-carotene increased in extrudates with 8% of spirulina by 34, 36, 140 and 1,260%, respectively. The increasing addition of spirulina caused a decrease in extrudates lightness, an increase in their greenness and yellowness accompanied by a decrease of expansion indices and an increase of softness. Only small differences were found in water sorption properties, suggesting a similar behavior of spirulina-enriched extrudates during storage.

Variations in grain lipophilic phytochemicals, proteins and resistance to Fusarium spp. growth during grain storage as affected by biological plant protection with Aureobasidium pullulans (de Bary)

Modern agriculture relies on an integrated approach, where chemical treatment is reduced to a minimum and replaced by biological control that involves the use of active microorganisms. The effect of the antagonistic yeast-like fungus Aureobasidium pullulans on proteins and bioactive compounds (alkylresorcinols, sterols, tocols and carotenoids) in winter wheat grain and on the colonization of wheat kernels by fungal microbiota, mainly Fusarium spp. pathogens, was investigated. Biological treatment contributed to a slight increase contents of tocols, alkylresorcinols and sterols in grain. At the same time, the variation of wheat grain proteins was low and not significant. Application of A. pullulans enhanced the natural yeast colonization after six months of grain storage and inhibited growth of F. culmorum pathogens penetrating wheat kernel. This study demonstrated that an integrated approach of wheat grain protection with the use of the yeast-like fungus A. pullulans reduced kernel colonization by Fusarium spp. pathogens and increased the content of nutritionally beneficial phytochemicals in wheat grain without a loss of gluten proteins responsible for baking value.

Differences of Some Chemicals and Physical Properties of Winter Wheat Grain of Mealy and Vitreous Appearance

Many wheat species and cultivars, independent of genetic markers of hardness, can produce grain with a vitreous, mealy or mixed appearance. This study analyzed selected chemical and physical differences between kernels with a vitreous and mealy appearance, hand-picked from grain of four winter wheat cultivars cultivated in Poland. Separated fractions were examined for protein content and composition, friabilin presence, carotenoids and total phenolic compounds content, specific kernel density, hardness, as well as kernel surface color. It was found that the ratio of vitreous kernels in the cultivars ranged from 39.18% to 76.28%. Vitreous kernels were darker, slightly heavier and harder than mealy kernels. Additionally, these kernels were more abundant in proteins (an average increase of 2.13%, with variation among cultivars from 0.71% to 2.89%). This type of kernels was also richer in phenolic compounds (on average by 4.02%) and less abundant in carotenoids (on average by 4.53%). Mealy (softer) kernels fractured to a finer flour.

The effects of various plant protection methods on the development of Zymoseptoria tritici and Cephalosporium gramineum, grain yield and protein profile

ABSTRACT Septoria leaf blotch progresses rapidly, leading to the development of Zymoseptoria titici forms resistant to fungicides. Cephalosporium stripe is caused by Cephalosporium gramineum. The aim of this study was to evaluate the effectiveness of selected pesticides in limiting the symptoms of both diseases on winter wheat leaves, and to determine their influence on grain yield and the content and composition of protein fractions in wheat kernels. Propiconazoles were most effective in inhibiting the development of Septoria leaf blotch (symptoms were reduced from 54.7% to 78.6%). Strobilurins were less effective due to the presence of isolates with the G143A mutation. Symptoms of Cephalosporium stripe were rarely observed, and protective treatments did not reduce their severity. The highest content of grain protein (14.81%) was found in plants most intensely protected with the fungicides containing fenpropimorph, pyraclostrobin and epoxiconazole. The principal component analysis revealed that the plant protection method influenced the grain protein profile. The accumulation of HMW glutenins and α/β gliadins was mutually interrelated and higher in high-input treatments; control grain was characterized by close relationships between ω-gliadins, LMW glutenins, albumins and globulins, whereas low-input treatments influenced mostly γ-gliadins.

Variation in oil quality and content of low molecular lipophilic compounds in chia seed oils

ABSTRACT This study was conducted to characterize the lipid fraction of 15 chia seed samples originating from five countries (Argentina, Paraguay, Uganda, Bolivia, and Peru). On average, chia seeds contained 34.5 g oil per 100 g dry-solids, in which the average contents of sterols, tocopherols, squalene, carotenoids, and phenolic compounds were 7,061, 600, 17.7, 2.2, and 9.7 mg/kg of oil, respectively. Alpha-linolenic acid share varied from 54.35% to 60.48%, and was accompanied by declining shares of linoleic, palmitic, oleic, and stearic acid, respectively. Principal component analysis showed that chia oil induction time was positively correlated with tocopherols and phenols, while negatively with quality indices and squalene content.

Comparison of the effect of sinapic and ferulic acids derivatives (4-vinylsyringol vs. 4-vinylguaiacol) as antioxidants of rapeseed, flaxseed, and extra virgin olive oils

The aim of the work is to compare the antioxidant activity of 4-vinylguaiacol (4-VQ) and 4-vinylsyringol (4-VS) added to stabilize three (flaxseed, olive and rapeseed) commercial oils. The phenolics were added at concentration of 20, 40 and 80mg per 100g of oil. The oils were oxidized in a Rancimat test at 110°C. The linear dependences between the concentrations of each of these compounds and the induction period (IP) were found. Generally, 4-VQ was more effective, since the determined IP increase after its addition was from 5 to 25-fold higher than for the same addition of 4-VS. The highest increase was noted for flaxseed oil, for which 80mg 4-VQ addition per 100g of oil resulted in 50% IP increase. The highest absolute values of IP were reached by extra virgin olive oil, naturally abundant in phenolic compounds and with the lowest fatty acids oxidation index.