Jong-Suep Baek

Practical preparation procedures for docetaxel-loaded nanoparticles using polylactic acid-co-glycolic acid

Background Nanoparticles fabricated from the biodegradable and biocompatible polymer, polylactic-co-glycolic acid (PLGA), are the most intensively investigated polymers for drug delivery systems. The objective of this study was to explore fully the development of a PLGA nanoparticle drug delivery system for alternative preparation of a commercial formulation. In our nanoparticle fabrication, our purpose was to compare various preparation parameters. Methods Docetaxel-loaded PLGA nanoparticles were prepared by a single emulsion technique and solvent evaporation. The nanoparticles were characterized by various techniques, including scanning electron microscopy for surface morphology, dynamic light scattering for size and zeta potential, x-ray photoelectron spectroscopy for surface chemistry, and high-performance liquid chromatography for in vitro drug release kinetics. To obtain a smaller particle, 0.2% polyvinyl alcohol, 0.03% D-α-tocopheryl polyethylene glycol 1000 succinate (TPGS), 2% Poloxamer 188, a five-minute sonication time, 130 W sonication power, evaporation with magnetic stirring, and centrifugation at 8000 rpm were selected. To increase encapsulation efficiency in the nanoparticles, certain factors were varied, ie, 2–5 minutes of sonication time, 70–130 W sonication power, and 5–25 mg drug loading. Results A five-minute sonication time, 130 W sonication power, and a 10 mg drug loading amount were selected. Under these conditions, the nanoparticles reached over 90% encapsulation efficiency. Release kinetics showed that 20.83%, 40.07%, and 51.5% of the docetaxel was released in 28 days from nanoparticles containing Poloxamer 188, TPGS, or polyvinyl alcohol, respectively. TPGS and Poloxamer 188 had slower release kinetics than polyvinyl alcohol. It was predicted that there was residual drug remaining on the surface from x-ray photoelectron spectroscopy. Conclusion Our research shows that the choice of surfactant is important for controlled release of docetaxel.

Controlled release and reversal of multidrug resistance by co-encapsulation of paclitaxel and verapamil in solid lipid nanoparticles.

Paclitaxel (PTX) has been used in the treatment of wide range of cancers but its entry into cancer cell is restricted by p-glycoprotein (p-gp). Also, it was reported that verapamil (VP) could inhibit p-gp efflux. Hence, three kinds of solid lipid nanoparticles (SLN) such as PVS (PTX and VP co-loaded SLN), PSV (PTX loaded SLN, later added VP) and PVSV (PTX and VP co-loaded SLN, later added VP) were prepared to overcome MDR by combination of PTX and VP. PVS was the SLN loaded with both PTX and VP at the same time. PSV was the SLN loaded with PTX and then modified with VP - complexed hydroxypropyl-β-cylcodextrin (HPCD). Finally, PVSV was the SLN loaded with PTX and half of VP at the same time subsequently, modified with half of VP - complexed HPCD. The physicochemical characterizations of PVS, PSV or PVSV such as particle size, zeta potential, encapsulation efficiency or in vitro PTX release were examined. PVSV showed that release of VP was higher than PTX solution in first 15h and sustained release of both VP and PTX. PVSV showed significantly higher cytotoxicity and cellular uptake than that of the PTX solution in MCF-7/ADR resistant cells. Furthermore, PVSV significantly down regulated the expression of p-gp than the PTX solution in MCF-7/ADR resistant cells. Based on these findings, this study indicated that the PVSV exhibited great potential for breast cancer therapy.

In vitro characterization of the invasiveness of polymer microneedle against skin

The micro-sized needles could pierce the skin to deliver drugs effectively in a minimally invasive and painless manner. However, there are only a few reports that identify the invasiveness and painlessness of microneedle (MN), and in vitro characterization studies were conducted to examine the invasiveness of MN in experimental animals and healthy volunteers. First, a fluorescent molecule was applied to show the skin holes according to the application time of MN and then the whitening effect in UV-exposed hairless rats was observed using reflectance spectroscopy according to the application time of MN. The extent of skin irritation by the application time of MN in healthy volunteers was determined from the value of skin redness. Regardless of MN application time, skin redness occurred and then disappeared 30 min after removal of MN; this phenomenon was insignificant with the application time of MN. Thus, if the MN was applied, a skin hole appeared, skin redness was observed and then the skin redness disappeared 30 min after removal of MN. Taken together, polymer MN might be a suitable tool for safe transdermal drug delivery of small molecules.

2-Hydroxypropyl-β-cyclodextrin-modified SLN of paclitaxel for overcoming p-glycoprotein function in multidrug-resistant breast cancer cells.

Objectives  This study aimed to evaluate the potential of solid lipid nanoparticles (SLNs) of paclitaxel (PTX) modified with a 2‐hydroxypropyl‐β‐cyclodextrin system to enhance cellular accumulation of PTX into p‐glycoprotein (p‐gp)‐expressing cells.

Solid lipid nanoparticles of paclitaxel strengthened by hydroxypropyl-β-cyclodextrin as an oral delivery system

The objective of this study was to evaluate the potential of surface-modified paclitaxel (PTX)-incorporated solid lipid nanoparticles with hydroxypropyl-β-cyclodextrin (smPSH). The smPSH released 89.70 ± 3.99% of its entrapped PTX within 24 h when placed in dissolution medium containing sodium lauryl sulfate. The cellular uptake of PTX from smPSH in Caco-2 cells was 5.3-fold increased compared to a PTX solution based on a Taxol formulation. Moreover, smPSH showed an increased cytotoxicity compared to PTX solution. In addition, AUC (5.43 µg•h/ml) and Cmax (1.44 µg/ml) of smPSH were higher than those (1.81 µg•h/ml and 0.73 µg/ml) of PTX solution. The drug concentration of smPSH (11.12 ± 4.45 ng/mg of lymph tissue) in lymph nodes was higher than that of the PTX solution (0.89 ± 0.75 ng/mg of lymph tissue), suggesting that more PTX was transported to the lymphatic vessels in the form of smPSH. In conclusion, smPSH have a potential as an alternative delivery system for oral administration of PTX.

Enhanced transdermal drug delivery of zaltoprofen using a novel formulation.

Zaltoprofen is a non-steroidal anti-inflammatory drug (NSAID) belonging to the propionic acid class. It has strong inhibitory effects on acute and chronic inflammation. Although zaltoprofen is well tolerated orally compared to other NSAIDs, it has to be administered in three to four doses per day and was associated with ulcerogenicity, bellyache and indigestion. This makes administration of zaltoprofen unsuitable for patients with gastric ulcer and is also associated with drug interactions. Therefore, it is important to develop an alternative dosage form which is easier to administer and avoids first-pass metabolism. The transdermal route meets all the above advantages. In this study, zaltoprofen gels were prepared using carbomer with mixture solution of polyethylene glycol (PEG) 400, Tween 80 and (2-hydroxypropyl)-β-cyclodextrin (HPCD) (called as T2), subsequently oleic acid as a penetration enhancer was added. Zaltoprofen gel containing T2 and oleic acid could promote the percutaneous absorption of zaltoprofen and increase AUC by 183% compared to zaltoprofen gel without T2 and oleic acid. Also, there was a finding zaltoprofen gel containing T2 and oleic acid did not cause dermal irritations in an experimental animal.

Surface modification of solid lipid nanoparticles for oral delivery of curcumin: Improvement of bioavailability through enhanced cellular uptake, and lymphatic uptake

Graphical abstract Figure. No caption available. ABSTRACT Curcumin has been reported to exhibit potent anticancer effects. However, poor solubility, bioavailability and stability of curcumin limit its in vivo efficacy for the cancer treatment. Solid lipid nanoparticles (SLN) are a promising delivery system for the enhancement of bioavailability of hydrophobic drugs. However, burst release of drug from SLN in acidic environment limits its usage as oral delivery system. Hence, we prepared N‐carboxymethyl chitosan (NCC) coated curcumin‐loaded SLN (NCC‐SLN) to inhibit the rapid release of curcumin in acidic environment and enhance the bioavailability. The NCC‐SLN exhibited suppressed burst release in simulated gastric fluid while sustained release was observed in simulated intestinal fluid. Furthermore, NCC‐SLN exhibited increased cytotoxicity and cellular uptake on MCF‐7 cells. The lymphatic uptake and oral bioavailability of NCC‐SLN were found to be 6.3‐fold and 9.5‐fold higher than that of curcumin solution, respectively. These results suggest that NCC‐SLN could be an efficient oral delivery system for curcumin.

Tadalafil-loaded nanostructured lipid carriers using permeation enhancers

Tadalafil is a phosphodiesterase-5 inhibitor indicated for the treatment of erectile dysfunction. In this study, we prepared and evaluated transdermal nanostructured lipid carriers (NLC) to improve the skin permeability of tadalafil. Tadalafil-loaded NLC dispersions were prepared using glyceryl monostearate as a solid lipid, oleic acid as a liquid lipid, and Tween 80 as a surfactant. We characterized the dispersions according to particle size, polydispersity index, zeta potential, encapsulation efficiency, and transmission electron microscopy. In vitro skin permeation studies were carried out using Franz diffusion cells, and cytotoxicity was examined using HaCaT keratinocyte cell lines. Tadalafil skin permeability increased for all tadalafil-loaded NLC formulations. The tadalafil-loaded NLC dispersion with ethanol and limonene as skin permeation enhancers exhibited the highest flux (∼4.8-fold) compared to that observed with tadalafil solution alone. Furthermore, a tadalafil-loaded NLC gel with selected permeation enhancers showed tolerance against toxicity in HaCaT cells. These results suggest that the NLC formulations with ethanol and limonene as skin permeation enhancers could be a promising dermal delivery carrier for tadalafil.

Modification of paclitaxel-loaded solid lipid nanoparticles with 2-hydroxypropyl-β-cyclodextrin enhances absorption and reduces nephrotoxicity associated with intravenous injection

Background Paclitaxel (PTX) solid lipid nanoparticles (SLNs) modified with 2-hydroxypropyl-β-cyclodextrin (HPCD) were evaluated for their ability to enhance PTX absorption and reduce the nephrotoxicity accompanying intravenous administration. Methods PTX-loaded SLNs (PS) and PTX-loaded SLNs modified using HPCD (PSC) were prepared by hot-melted sonication. The anticancer activity of PSC was evaluated in MCF-7 cells, and confocal microscopy was used to quantify the cellular uptake. The pharmacokinetic profiles of PTX released from PSC after intravenous administration were studied in rats. Furthermore, kidney toxicity was determined by measuring the kidney size and plasma creatinine level. Results PSC were successfully prepared by hot-melted sonication and had smaller diameters than PS. PSC exhibited improved anticancer activity and cellular uptake in MCF-7 cells. Furthermore, PSC showed higher bioavailability in rats after intravenous administration than PTX solution; however, no significant differences in kidney toxicity were observed. Conclusion Based on these results, PSC could be considered as a potential therapeutic PTX delivery system for breast cancer with low renal toxicity.

Alendronate-loaded microparticles for improvement of intestinal cellular absorption.

This study examined a novel alendronate formulation that was developed to overcome the shortcomings of alendronate, such as its low bioavailability and gastric adverse effects. Alendronate microparticles were prepared using mucoadhesive polymers such as chitosan for improving the intestinal cellular absorption of alendronate and also using a gastric-resistant polymer such as Eudragit L100-55 for reducing the gastric inflammation of alendronate. Alendronate microparticles including chitosan showed a threefold increase in alendronate uptake (6.92 ± 0.27%) in Caco-2 cells when compared with the uptake of alendronate solution (2.38 ± 0.27%) into Caco-2 cells. Most interestingly, alendronate microparticles including chitosan showed 2.80 × 10−6 cm/s of an apparent permeability coefficient across Caco-2 cells and caused a significant 42.4% enhancement compared with that of alendronate solution across Caco-2 cells. The morphology of the Caco-2 cells treated with alendronate microparticles including chitosan was similar to that of the untreated cells and alendronate microparticles exhibited a negative effect to propodium iodide with some annexin-V fluorescence isothiocyante positive effect. It was proposed that the novel alendronate microparticles could possess the potential of an increased intestinal absorption and fewer adverse effects of alendronate.