Kit Granby

The effect of asparaginase on acrylamide formation in French fries

Acrylamide formation in French fries was investigated in relation to blanching and asparaginase soaking treatments before final frying. Par-fried potatoes of Bintje variety were prepared by cutting strips (0.8×0.8×5cm) which were blanched at 75°C for 10min. Unblanched strips were used as the control. Control or blanched strips were then dried at 85°C for 10min and immediately partially fried at 175°C for 1min. Finally, frozen par-fried potatoes were fried at 175°C for 3min to obtain French fries. Pre-drying of raw or blanched potato strips did not generate acrylamide formation as expected. Partial frying of pre-dried control potato strips generated 370μg/kg of acrylamide and the final frying determined French fries with 2075μg/kg of acrylamide. When control potato strips were treated with a 10000 ASNU/l asparaginase solution at 40°C for 20min, the acrylamide formation in French fries was reduced by 30%. When blanched potato strips were treated in the same way, the produced French fries have 60% less acrylamide content than blanched strips without the enzyme treatment. Soaking of blanched potato strips (75°C, 10min) in an 10000 ASNU/l asparaginase solution at 40°C for 20min is an effective way to reduce acrylamide formation after frying by reducing the amount of one of its important precursors such as asparagine.

Current issues in dietary acrylamide: formation, mitigation and risk assessment

Acrylamide (AA) is known as a neurotoxin in humans and it is classified as a probable human carcinogen by the International Agency of Research on Cancer. AA is produced as by-product of the Maillard reaction in starchy foods processed at high temperatures (>120 °C). This review includes the investigation of AA precursors, mechanisms of AA formation and AA mitigation technologies in potato, cereal and coffee products. Additionally, most relevant issues of AA risk assessment are discussed. New technologies tested from laboratory to industrial scale face, as a major challenge, the reduction of AA content of browned food, while still maintaining its attractive organoleptic properties. Reducing sugars such as glucose and fructose are the major contributors to AA in potato-based products. On the other hand, the limiting substrate of AA formation in cereals and coffee is the free amino acid asparagine. For some products the addition of glycine or asparaginase reduces AA formation during baking. Since, for potatoes, the limiting substrate is reducing sugars, increases in sugar content in potatoes during storage then introduce some difficulties and potentially quite large variations in the AA content of the final product. Sugars in potatoes may be reduced by blanching. Levels of AA in different foods show large variations and no general upper limit is easily applicable, since some formation will always occur. Current policy is that practical measures should be taken voluntarily to reduce AA formation in vulnerable foods since AA is considered a health risk at the concentrations found in foods.

Cumulative risk assessment of the intake of organophosphorus and carbamate pesticides in the Danish diet

The aim of the study is to evaluate the potential cumulative effects of organophosphorus and carbamate pesticides that act through a common mechanism of toxicity, and to assess the long- and short-term risks for the Danish population. The intake estimates are based on dietary intake data collected in the Danish nation-wide food consumption survey in 1995. The pesticide data are based on the Danish pesticide residue-monitoring programme from 1996–2001. The amount of 35 organophosphorus pesticides and carbamates were included in the cumulative risk assessment. Processing factors, such as reduction of pesticide levels by rinsing and peeling, were applied in the exposure assessment. The “Toxicity Equivalence Factor” (TEF) approach was used to normalise the toxicity of the different organophosphorus and carbamate pesticides. Cumulative chronic exposure of organophosphorus and carbamates pesticides via fruit, vegetables and cereals is for adults 0.8–2% of the Acceptable Daily Intake (ADI) in chlorpyrifos equivalents, and 0.03–11% of the ADI in methamidophos equivalents; and for children 2–5% of the ADI in the chlorpyrifos equivalents, and 0.07–27% of the ADI in methamidophos equivalents. Neither Acute Reference Dose (ARfD) nor ADI was exceeded for any of the compounds studied. The results indicate that the Danish population is neither exposed to any cumulative chronic risk, nor at risk of acute exposure, from consumption of organophosphorus and carbamate pesticides from fruit, vegetables and cereals.

Analysis of glyphosate residues in cereals using liquid chromatography-mass spectrometry (LC-MS/MS)

A fast and specific method for the determination of glyphosate in cereals is described. The method is based on extraction with water by ultrasonication. The samples are cleaned up and separated by high-performance liquid chromatography on a polystyrene-based reverse-phase column (clean-up) in series with an ion chromatography column (separation) using NaHCO3 as eluent. A micro-membrane suppressor was inserted after the separator column to remove the Na+ ions before detection by electrospray ionization mass spectrometry in the negative-ion mode. In MS/MS, mode the following transitions were monitoredm/z168 → 150 (glyphosate) and 170 → 152 (internal standard 2-13 C15N-glyphosate) for quantification. The mean recovery was 85% (n=32) at spiking levels from 0.03 to 0.33 mg kg−1. From 1998 to 2001, from the analysis of about 50 samples per annum, a reduction in the glyphosate residues was observed owing to a Danish trade decision not to use grain with glyphosate residues for milling or bread production.

Method validation for strobilurin fungicides in cereals and fruit.

Strobilurins are a new class of fungicides that are active against a broad spectrum of fungi. In the present work a GC method for analysis of strobilurin fungicides was validated. The method was based on extraction with ethyl acetate/cyclohexane, clean-up by gel permeation chromatography (GPC) and determination of the content by gas chromatography (GC) with electron capture (EC-), nitrogen/phosphorous (NP-), and mass spectrometric (MS-) detection. Three strobilurins, azoxystrobin, kresoxim-methyl and trifloxystrobin were validated on three matrices, wheat, apple and grapes. The validation was based on recovery tests at three or four spiking levels, determined as double determinations and repeated three times (n = 6). The mean recoveries for the three detectors were in the range of 70-114%, and the LODs were between 0.004mg/kg and 0.014mg/kg, for all three strobilurins. The values for repeatability and reproducibility were within the limits for repeatability and reproducibility given by the Horwitz equation. Validation was not accepted for azoxystrobin in grapes on all three detectors and for azoxystrobin in apple for the MS-detector. A comparison of matrix-matched standards versus standards in solvent showed varying differences

Influence of smoking parameters on the concentration of polycyclic aromatic hydrocarbons (PAHs) in Danish smoked fish

A new method for the analysis of 25 polycyclic aromatic hydrocarbon (PAH) compounds in fish was developed, validated, and used for the quantification of PAHs in 180 industrially smoked fish products. The method included pressurized liquid extraction, gel-permeation chromatography (Bio-beads S-X3), solid-phase extraction (silica gel), and gas chromatography-mass spectrometry analysis. The sum concentration of 25 PAHs (∑PAH25) was highest in smoked herring (n = 3) and mackerel fillets (n = 13), with an average concentration of 320 and 235 µg kg−1, respectively. Lowest average ∑PAH25 concentrations were obtained for indirectly smoked trout (26 µg kg−1). Principal component analysis was used to correlate processing parameters to PAH concentrations and to identify the effects of these parameters. The analysis showed that for salmon hot-smoking conditions lead to higher ΣPAH25 than cold smoking, and for other fish species direct smoking leads to higher ΣPAH25 than indirect smoking. Also, the usage of common alder increases the PAH contamination compared with beech. The effects of smoking time, combustion temperatures, and two types of smoke-generating material on the ∑PAH25 were also tested in a pilot plant study with smoked trout as a model fish. In addition to confirming that increased combustion temperatures and usage of common alder in comparison with beech increased ∑PAH25, it was also revealed that the PAH concentration decreased in the order fish skin ≫ outer layer of the fish muscle > inner part of the fish muscle.

Formation and mitigation of N-nitrosamines in nitrite preserved cooked sausages

Literature on formation and mitigation of N-nitrosamine (NA) and especially non-volatile NA (NVNA) in meat products is scarce and the present study is therefore a relevant contribution to the field. We found positive correlation between the levels of N-nitrosopiperidine (NPIP), N-nitrosohydroxyproline (NHPRO), N-nitrosoproline (NPRO), N-nitrosothiazolidine-4-carboxylic acid (NTCA) and N-nitroso-2-methyl-thiazolidine-4-carboxylic acid (NMTCA) and the amount of nitrite added to cooked pork sausages. The levels studied were 0, 60, 100, 150, 250 and 350 mg kg(-)(1). The levels of N-nitrosodimethylamine (NDMA) and N-nitrosopyrrolidine (NPYR) remained at or below limit of quantification. Erythorbic acid inhibited the formation of NHPRO, NPRO, NPIP and NTCA. This inhibition was for NTCA and NMTCA counteracted by addition of free iron. Ascorbyl palmitate had less inhibitory effect than erythorbic acid and a combination of the two provided no further protection. Increasing the black pepper content increased the levels of NPIP and NMTCA. Only slight effects of increased fat content and addition of tripolyphosphate were observed.

Processing factors and variability of pyrimethanil, fenhexamid and tolylfluanid in strawberries

An HPLC-MS/MS method for the analysis of three pesticides in strawberries was developed and validated. Recoveries were measured at three spiking levels and ranged from 85 to 99% (mean recoveries). The effects of processing of strawberries ranging from rinsing to jam production were investigated for the three fungicides tolylfluanid, fenhexamid and pyrimethanil, which were applied under field conditions. Kresoxim-methyl was also applied in the field, but was not found in any of the samples investigated. The effect of parameters such as preharvest interval, dose, harvest time and observed pesticide concentration after harvest (initial concentration, mg kg−1), were examined with respect to possible reduction of the pesticides. The results from rinsing showed that all three pesticides were reduced on average by 37% for tolylfluanid, by 34% for fenhexamid and by 19% for pyrimethanil. For tolylfluanid and fenhexamid, the initial concentration significantly affected the reduction. For fenhexamid, dose could also have a minor influence on reduction. For pyrimethanil, none of the parameters significantly influenced the reduction. For jam production, cooking significantly reduced tolylfluanid by an average of 91%. For fenhexamid and pyrimethanil, a smaller reduction was seen, 25% and 33%, respectively. The reduction of tolylfluanid and pyrimethanil was affected by the preharvest interval, while fenhexamid was affected by the initial concentration. The unit-to-unit variability of fungicide contents was also investigated and the variability factors for the three fungicides were from 1.9 to 2.8.

Investigation of the herbicide glyphosate and the plant growth regulators chlormequat and mepiquat in cereals produced in Denmark.

An LC-MS/MS method for analysing glyphosate and aminomethylphosphonic acid (AMPA) in cereals was developed. The method is based on extraction with water and detection of the ions from the fragmentation m/z 170-->88 (glyphosate) and m/z 112-->30 (AMPA), using electrospray interface in the positive mode. Investigation from the harvests of 1998 and 1999 showed residues of glyphosate and/or its degradation product AMPA in more than half of the cereal samples produced in Denmark. The average concentration of glyphosate in 46 samples from the 1999 harvest was 0.11 mg/kg compared with 0.08 mg/kg for the 1998 harvest (n = 49). Thus, the figures were well below the maximum residue limit (MRL) and no violations were observed. The plant growth regulators chlormequat and/or mepiquat were investigated in cereals from the Danish harvest of 1999 where 83% of the samples contained chlormequat (n = 46) compared with 87% of the samples from the 1997 harvest (n = 52). The average concentration of chlormequat in 1999 was 0.32 mg/kg compared with 0.23 mg/kg in 1997. At 2.9 mg/kg, one sample of wheat bran was exceeding the MRL of 2 mg/kg for wheat. The intakes of the pesticides through the diet of cereals were estimated to comprise 0.04% of the acceptable daily intake (ADI) for glyphosate and 1% of the ADI for chlormequat for an adult Dane.

Simultaneous determination of volatile and non-volatile nitrosamines in processed meat products by liquid chromatography tandem mass spectrometry using atmospheric pressure chemical ionisation and electrospray ionisation

A sensitive, selective and generic method has been developed for the simultaneous determination of the contents (μgkg(-1) range) of both volatile nitrosamines (VNA) and non-volatile nitrosamines (NVNA) in processed meat products. The extraction procedure only requires basic laboratory equipment and a small volume of organic solvent. Separation and quantification were performed by the developed LC-(APCI/ESI)MS/MS method. The method was validated using spiked samples of three different processed meat products. Satisfactory recoveries (50-130%) and precisions (2-23%) were obtained for eight VNA and six NVNAs with LODs generally between 0.2 and 1μgkg(-1), though for a few analyte/matrix combinations higher LODs were obtained (3 to 18μgkg(-1)). The validation results show that results obtained for one meat product is not always valid for other meat products. We were not able to obtain satisfactory results for N-nitrosohydroxyproline (NHPRO), N-nitrosodibenzylamine (NDBzA) and N-nitrosodiphenylamine (NDPhA). Application of the APCI interface improved the sensitivity of the method, because of less matrix interference, and gave the method a wider scope, as some NAs were ionisable only by APCI. However, it was only possible to ionize N-nitroso-thiazolidine-4-carboxylic acid (NTCA) and N-nitroso-2-methyl-thiazolidine-4-carboxylic acid (NMTCA) by ESI. The validated method was applied for the analysis of processed meat products and contents of N-nitrosodimethylamine (NDMA), N-nitrosopyrrolidine (NPYR), N-nitrosomethylaniline (NMA), N-nitrosoproline (NPRO), NTCA, and NMTCA were found in one or several nitrite cured meat products, whereas none were detected in non-nitrite cured bacon.