M.J. van der Werf

Environmental and physiological factors affecting the succinate product ratio during carbohydrate fermentation by Actinobacillus sp. 130Z

Actinobacillus sp. 130Z fermented glucose to the major products succinate, acetate, and formate. Ethanol was formed as a minor fermentation product. Under CO2-limiting conditions, less succinate and more ethanol were formed. The fermentation product ratio remained constant at pH values from 6.0 to 7.4. More succinate was produced when hydrogen was present in the gas phase. Actinobacillus sp. 130Z grew at the expense of fumarate and l-malate reduction, with hydrogen as an electron donor. Other substrates such as more-reduced carbohydrates (e.g., d-sorbitol) resulted in higher succinate and/or ethanol production. Actinobacillus sp. 130Z contained the key enzymes involved in the Embden-Meyerhof-Parnas and the pentose-phosphate pathways and contained high levels of phosphoenolpyruvate (PEP) carboxykinase, malate dehydrogenase, fumarase, fumarate reductase, pyruvate kinase, pyruvate formate-lyase, phosphotransacetylase, acetate kinase, malic enzyme, and oxaloacetate decarboxylase. The levels of PEP carboxykinase, malate dehydrogenase, and fumarase were significantly higher in Actinobacillus sp. 130Z than in Escherichia coli K-12 and accounted for the differences in succinate production. Key enzymes in end product formation in Actinobacillus sp. 130Z were regulated by the energy substrates.

Substrate specificity and stereospecificity of limonene-1,2-epoxide hydrolase from Rhodococcus erythropolis DCL14; an enzyme showing sequential and enantioconvergent substrate conversion

Abstract Limonene-1,2-epoxide hydrolase (LEH) from Rhodococcus erythropolis DCL14, an enzyme involved in the limonene degradation pathway of this microlorganism, has a narrow substrate specificity. Of the compounds tested, the natural substrate, limonene-1,2-epoxide, and several alicyclic and 2-methyl-1,2-epoxides (e.g. 1-methylcyclohexene oxide and indene oxide), were substrates for the enzyme. When LEH was incubated with a diastereomeric mixture of limonene-1,2-epoxide, the sequential hydrolysis of first the (1R,2S)- and then the (1S,2R)-isomer was observed. The hydrolysis of (4R)- and (4S)-limonene-1,2-epoxide resulted in, respectively, (1S,2S,4R)- and (1R,2R,4S)-limonene-1,2-diol as the sole product with a diastereomeric excess of over 98%. With all other substrates, LEH showed moderate to low enantioselectivities (E ratios between 34 and 3).

Bacterial metabolism of 3-chloroacrylic acid.

Two bacterial strains were isolated with 3-chloroacrylic acid (CAA) as sole source of carbon and energy. Strain CAA1, a Pseudomonas cepacia sp., was capable of growth with only the cis-isomer of CAA. Strain CAA2, a coryneform bacterium, utilized both isomers of CAA as sole source of carbon and energy. Strain CAA1 contained cis-CAA hydratase and strain CAA2 contained two hydratases, one with cis-CAA hydratase activity and one with trans-CAA hydratase activity. The product of the hydratase activities with CAA was malonate semialdehyde. In both strains malonate semialdehyde was subsequently decarboxylated by a cofactor-independent decarboxylase yielding acetaldehyde and CO2.

Efficient Transformation System for Propionibacterium freudenreichii Based on a Novel Vector

ABSTRACT A 3.6-kb endogenous plasmid was isolated from aPropionibacterium freudenreichii strain and sequenced completely. Based on homologies with plasmids from other bacteria, notably a plasmid from Mycobacterium, a region harboring putative replicative functions was defined. Outside this region two restriction enzyme recognition sites were used for insertion of anEscherichia coli-specific replicon and an erythromycin resistance gene for selection in Propionibacterium. Hybrid vectors obtained in this way replicated in both E. coli andP. freudenreichii. Whereas electroporation of P. freudenreichii with vector DNA isolated from an E. coli transformant yielded 10 to 30 colonies per μg of DNA, use of vector DNA reisolated from a Propionibacteriumtransformant dramatically increased the efficiency of transformation (≥108 colonies per μg of DNA). It could be shown that restriction-modification was responsible for this effect. The high efficiency of the system described here permitted successful transformation of Propionibacterium with DNA ligation mixtures.

Metabolism of carveol and dihydrocarveol in Rhodococcus erythropolis DCL14

Rhodococcus erythropolis DCL14 assimilates all stereoisomers of carveol and dihydrocarveol as sole source of carbon and energy. Induction experiments with carveol- or dihydrocarveol-grown cells showed high oxygen consumption rates with these two compounds and with carvone and dihydrocarvone. (Dihydro)carveol-grown cells of R. erythropolis DCL14 contained the following enzymic activities involved in the carveol and dihydrocarveol degradation pathways of this micro-organism: (dihydro)carveol dehydrogenase (both NAD+- and dichlorophenolindophenol-dependent activities), an unknown cofactor-dependent carvone reductase, (iso-)dihydrocarvone isomerase activity, NADPH-dependent dihydrocarvone monooxygenase (Baeyer-Villiger monooxygenase), epsilon-lactone hydrolase and an NAD+-dependent 6-hydroxy-3-isopropenylheptanoate dehydrogenase. Product accumulation studies identified (4R)-carvone, (1R,4R)-dihydrocarvone, (4R,7R)-4-isopropenyl-7-methyl-2-oxo-oxepanone, (3R)-6-hydroxy-3-isopropenylheptanoate, (3R)-3-isopropenyl-6-oxoheptanoate, (3S,6R)-6-isopropenyl-3-methyl-2-oxooxepanone and (5R)-6-hydroxy-5-isopropenyl-2-methylhexanoate as intermediates in the (4R)-carveol degradation pathway. The opposite stereoisomers of these compounds were identified in the (4S)-carveol degradation pathway. With dihydrocarveol, the same intermediates are involved except that carvone was absent. These results show that R. erythropolis DCL14 metabolizes all four diastereomers of carveol via oxidation to carvone, which is subsequently stereospecifically reduced to (1R)-(iso-) dihydrocarvone. At this point also dihydrocarveol enters the pathway, and this compound is directly oxidized to (iso-)dihydrocarvone. Cell extracts contained both (1R)-(iso-)dihydrocarvone 1,2-monooxygenase and (1S)-(iso)-dihydrocarvone 2,3-monooxygenase activity, resulting in a branch point of the degradation pathway; (1R)-(iso-)dihydrocarvone was converted to 4-isopropenyl-7-methyl-2-oxo-oxepanone, while (1S)-(iso)-dihydrocarvone, which in vivo is isomerized to (1R)-(iso-)dihydrocarvone, was converted to 6-isopropenyl-3-methyl-2-oxo-oxepanone. 4-Isopropenyl-7-methyl-2-oxooxepanone is hydrolysed to 6-hydroxy-3-isopropenylheptanoate, which is subsequently oxidized to 3-isopropenyl-6-oxoheptanoate, thereby linking the (dihydro)carveol degradation pathways to the limonene degradation pathway of this micro-organism. 6-Isopropenyl-3-methyl-2-oxo-oxepanone is, in vitro, hydrolysed to 6-hydroxy-5-isopropenyl-2-methylhexanoate, which is thought to be a dead-end metabolite.

Permeabilization and lysis of Pseudomonas pseudoalcaligenes cells by Triton X-100 for efficient production of d-malate

Pseudomonas pseudoalcaligenes can only form d-malate from maleate after incubation of the cells with a solvent or a detergent. The effect of the detergent Triton X-100 on d-malate production was studied in more detail. The longer the cells were incubated with Triton X-100, the higher was the d-malate production activity, until the maximal malease activity was reached. Incubation of P. pseudoalcaligenes cells with Triton X-100 also resulted in an increase in the protein concentration of the supernatant, indicating that cell lysis had occurred. The rate at which the d-malate production activity increased was dependent on the Triton X-100 concentration and on the cell density. Also the rate at which lysis occurred depended on the Triton X-100 concentration.

The effect of environmental conditions on extracellular protease activity in controlled fermentations of Aspergillus niger

Proteolytic degradation by host proteases is one of the key issues in the application of filamentous fungi for non-fungal protein production. In this study the influence of several environmental factors on the production of extracellular proteases of Aspergillus niger was investigated systematically in controlled batch cultures. Of all factors investigated in a series of initial screening experiments, culture pH and nitrogen concentration in particular strongly affected extracellular protease activities. For instance, at a culture pH of 4, protease activity was higher than at pH 5, and protease activity increased with increasing concentrations of ammonium as nitrogen source. Interestingly, an interdependence was observed for several of the factors studied. These possible interaction effects were investigated further using a full factorial experimental design. Amongst others, the results showed a clear interaction effect between nitrogen source and nitrogen concentration. Based on the observed interactions, the selection of environmental factors to reduce protease activity is not straightforward, as unexpected antagonistic or synergistic effects occur. Furthermore, not only were the effects of the process parameters on maximum protease activity investigated, but five other protease-related phenotypes were studied as well, such as maximum specific protease activity and maximum protease productivity. There were significant differences in the effect of the environmental parameters on the various protease-related phenotypes. For instance, pH significantly affected final levels of protease activity, but not protease productivity. The results obtained in this study are important for the optimization of A. niger for protein production.

Purification and characterization of a Baeyer-Villiger mono-oxygenase from Rhodococcus erythropolis DCL14 involved in three different monocyclic monoterpene degradation pathways.

A Baeyer-Villiger mono-oxygenase (BVMO), catalysing the NADPH- and oxygen-dependent oxidation of the monocyclic monoterpene ketones 1-hydroxy-2-oxolimonene, dihydrocarvone and menthone, was purified to homogeneity from Rhodococcus erythropolis DCL14. Monocyclic monoterpene ketone mono-oxygenase (MMKMO) is a monomeric enzyme of molecular mass 60 kDa. It contains 1 mol of FAD/monomer as the prosthetic group. The N-terminal amino acid sequence showed homology with many other NADPH-dependent and FAD-containing (Type 1) BVMOs. Maximal enzyme activity was measured at pH 9 and 35 degrees C. MMKMO has a broad substrate specificity, catalysing the lactonization of a large number of monocyclic monoterpene ketones and substituted cyclohexanones. The natural substrates 1-hydroxy-2-oxolimonene, dihydrocarvone and menthone were converted stoichiometrically into 3-isopropenyl-6-oxoheptanoate (the spontaneous rearrangement product of the lactone formed by MMKMO), 4-isopropenyl-7-methyl-2-oxo-oxepanone and 7-isopropyl-4-methyl-2-oxo-oxepanone respectively. The MMKMO-catalysed conversion of iso-dihydrocarvone showed an opposite regioselectivity to that of dihydrocarvone; in this case, 6-isopropenyl-3-methyl-2-oxo-oxepanone was formed as the product. MMKMO converted all enantiomers of the natural substrates with almost equal efficiency. MMKMO is involved in the conversion of the monocyclic monoterpene ketone intermediates formed in the degradation pathways of all stereoisomers of three different monocyclic monoterpenes, i.e. limonene, (dihydro)carveol and menthol.

Genetic algorithm based two-mode clustering of metabolomics data

Metabolomics and other omics tools are generally characterized by large data sets with many variables obtained under different environmental conditions. Clustering methods and more specifically two-mode clustering methods are excellent tools for analyzing this type of data. Two-mode clustering methods allow for analysis of the behavior of subsets of metabolites under different experimental conditions. In addition, the results are easily visualized. In this paper we introduce a two-mode clustering method based on a genetic algorithm that uses a criterion that searches for homogeneous clusters. Furthermore we introduce a cluster stability criterion to validate the clusters and we provide an extended knee plot to select the optimal number of clusters in both experimental and metabolite modes. The genetic algorithm-based two-mode clustering gave biological relevant results when it was applied to two real life metabolomics data sets. It was, for instance, able to identify a catabolic pathway for growth on several of the carbon sources.

Geraniol biotransformation-pathway in spores of Penicillium digitatum

Abstract. Spores of Penicillium digitatum ATCC 201167 transform geraniol, nerol, citral, and geranic acid into methylheptenone. Spore extracts of P. digitatum convert geraniol and nerol NAD+-dependently into citral. Spore extract also converts citral NAD+-dependently into geranic acid. Furthermore, a novel enzymatic activity, citral lyase, which cofactor-independently converts citral into methylheptenone and acetaldehyde, was detected. These result show that spores of P. digitatum convert geraniol via a novel biotransformation pathway. This is the first time a biotransformation pathway in fungal spores has been substantiated by biochemical studies. Geraniol and nerol are converted into citral by citrol dehydrogenase activity. The citral formed is subsequently deacetylated by citral lyase activity, forming methylheptenone. Moreover, citral is converted reversibly into geranic acid by citral dehydrogenase activity.