Maria Galiotou-Panayotou

Influence of Glucose and Saturated Free-Fatty Acid Mixtures on Citric Acid and Lipid Production by Yarrowia lipolytica

In the present report, the effect of glucose and stearin (substrate composed by saturated free-fatty acids) on the production of biomass, reserve lipid, and citric acid by Yarrowia lipolytica ACA-DC 50109 was investigated in nitrogen-limited cultures. Numerical models that were used in order to quantify the kinetic behavior of the above Yarrowia lipolytica strain showed successful simulation, while the optimized parameter values were similar to those experimentally measured and the predictive ability of the models was satisfactory. In nitrogen-limited cultures in which glucose was used as the sole substrate, satisfactory growth and no glucose inhibition occurred, although in some cases the initial concentration of glucose was significantly high (150 g/l). Citric acid production was observed in all trials, which was in some cases notable (final concentration 42.9 g/l, yield 0.56 g per g of sugar consumed). The concentration of unsaturated cellular fatty acids was slightly lower when the quantity of sugar in the medium was elevated.In the cases in which stearin and glucose were used as co-substrates, in spite of the fact that the quantity of cellular lipid inside the yeast cells varied remarkably (from 0.3 to 2.0 g/l – 4 to 20% wt/wt), de novo fatty acid biosynthesis was observed. This activity increased when the yeast cells assimilated higher sugar quantities. The citric acid produced was mainly derived from the catabolism of sugar. Nevertheless, citric acid yield on sugar consumed and citrate specific production rate, as evaluated by the numerical model, presented substantially higher values in the fermentation in which no fat was used as glucose co-substrate compared with the cultures with stearin used as co-substrate.

Biotechnological conversions of bio-diesel-derived crude glycerol by Yarrowia lipolytica strains

In the present report, crude glycerol, waste discharged from bio‐diesel production, was used as carbon substrate for three natural Yarrowia lipolytica strains (LFMB 19, LFMB 20 and ACA‐YC 5033) during growth in nitrogen‐limited submerged shake‐flask experiments. In media with initial glycerol concentration of 30 g/L, all strains presented satisfactory microbial growth and complete glycerol uptake. Although culture conditions favored the secretion of citric acid (and potentially the accumulation of storage lipid), for the strains LFMB 19 and LFMB 20, polyol mannitol was the principal metabolic product synthesized (maximum quantity 6.0 g/L, yield 0.20–0.26 g per g of glycerol consumed). The above strains produced small quantities of lipids and citric acid. In contrast, Y. lipolytica ACA‐YC 5033 produced simultaneously higher quantities of lipid and citric acid and was further grown on crude glycerol in nitrogen‐limited experiments, with constant nitrogen and increasing glycerol concentrations (70–120 g/L). Citric acid and lipid concentrations increased with increment of glycerol; maximum total citric acid 50.1 g/L was produced (yield 0.44 g per g of glycerol) while simultaneously 2.0 g/L of fat were accumulated inside the cells (0.31 g of lipid per g of dry weight). Cellular lipids were mainly composed of neutral fraction, the concentration of which substantially increased with time. Moreover, in any case, the phospholipid fraction was more unsaturated compared with total and neutral lipids, while at the early growth step, microbial lipid was more rich in saturated fatty acids (e.g. C16:0 and C18:0) compared with the stationary phase.

Organic nitrogen of tomato waste hydrolysate enhances glucose uptake and lipid accumulation in Cunninghamella echinulata

Aims:  To investigate the effect of organic nitrogen on lipogenesis during growth of Cunninghamella echinulata on tomato waste hydrolysate (TWH) media.

Lipids of Cunninghamella echinulata with emphasis to γ-linolenic acid distribution among lipid classes

Changes in lipid composition of the oleaginous fungus Cunninghamella echinulata were monitored during growth. Lipid fractions and individual lipid classes varied in amount, relative proportions, and fatty acid profile depending on the developmental stage. Neutral lipids (N), comprised mainly of triacylglycerol, were accumulated in the fungal mycelium during both the late exponential and the stationary growth phases with a concomitant decrease in the amount of polar lipids. While fatty acid composition of N fraction remained almost constant, individual N classes showed a noticeable alteration in γ-linolenic acid (GLA) concentration. The glycolipid plus sphingolipid (G+S) fraction consisted mainly of monoglycosylglycerol and diglycosylglycerol. The sugar composition of G+S fraction was analyzed and showed a partial replacement of galactose for glucose as growth proceeded. Phospholipid (P) major classes were phosphatidylcholine (PC) and phosphatidylethanolamine, followed by phosphatidylinositol, phosphatidylserine, and diphosphatidylglycerol. P fatty acid composition showed significant changes with time, resulting in a considerable drop in the unsaturation index of this fraction. While in mid exponential growth phase, all P classes contained more than 20% w/w GLA of total fatty acids, and their concentration decreased to 12–17% w/w, except for the PC class where GLA concentration remained at high levels (e.g., more than 20% w/w). The constant level of GLA in PC at all growth phases suggests that PC was the major source of GLA. Sterol analysis showed that their concentration increased during growth, whereas ergosterol was the major component.

Screening of bacterial strains capable of converting biodiesel-derived raw glycerol into 1,3-propanediol, 2,3-butanediol and ethanol

The ability of bacterial strains to assimilate glycerol derived from biodiesel facilities to produce metabolic compounds of importance for the food, textile and chemical industry, such as 1,3‐propanediol (PD), 2,3‐butanediol (BD) and ethanol (EtOH), was assessed. The screening of 84 bacterial strains was performed using glycerol as carbon source. After initial trials, 12 strains were identified capable of consuming raw glycerol under anaerobic conditions, whereas 5 strains consumed glycerol under aerobiosis. A plethora of metabolic compounds was synthesized; in anaerobic batch‐bioreactor cultures PD in quantities up to 11.3 g/L was produced by Clostridium butyricum NRRL B‐23495, while the respective value was 10.1 g/L for a newly isolated Citrobacter freundii. Adaptation of Cl. butyricum at higher initial glycerol concentration resulted in a PDmax concentration of ∼32 g/L. BD was produced by a new Enterobacter aerogenes isolate in shake‐flask experiments, under fully aerobic conditions, with a maximum concentration of ∼22 g/L which was achieved at an initial glycerol quantity of 55 g/L. A new Klebsiella oxytoca isolate converted waste glycerol into mixtures of PD, BD and EtOH at various ratios. Finally, another new C. freundii isolate converted waste glycerol into EtOH in anaerobic batch‐bioreactor cultures with constant pH, achieving a final EtOH concentration of 14.5 g/L, a conversion yield of 0.45 g/g and a volumetric productivity of ∼0.7 g/L/h. As a conclusion, the current study confirmed the utilization of biodiesel‐derived raw glycerol as an appropriate substrate for the production of PD, BD and EtOH by several newly isolated bacterial strains under different experimental conditions.

Biotechnological conversion of waste cooking olive oil into lipid-rich biomass using Aspergillus and Penicillium strains

Aims:  In this study, we have investigated the biochemical behaviour of Aspergillus sp. (five strains) and Penicillium expansum (one strain) fungi cultivated on waste cooking olive oil. The production of lipid‐rich biomass was the main target of the work. In parallel, the biosynthesis of other extracellular metabolites (organic acids) and enzyme (lipase) and the substrate fatty acid specificity of the strains were studied.

Growth conditions of Aspergillus sp. ATHUM-3482 for polygalacturonase production

Abstract A wild type of Aspergillus sp. ATHUM-3482 produced extracellular polygalacturonase when grown in liquid medium containing citrus pectin as sole carbon source. A number of factors affecting enzyme activity were investigated. Polygalacturonase activities as high as␣4.3 U␣ml−1(reducing-group-releasing activity) and 17␣U␣ml−1 (viscosity-diminishing activity) were obtained under optimum growth conditions. With sugar-beet as sole carbon source the respective activities were 6.5 U␣ml−1 and 40 U ml−1, the highest achieved in this work. Under these conditions no pectin lyase or pectinesterase activity was detected. The above yields of polygalacturonase activity compare favourably with those reported for fungi grown under similar growth conditions.

Enhanced ethanol production, volatile compound biosynthesis and fungicide removal during growth of a newly isolated Saccharomyces cerevisiae strain on enriched pasteurized grape musts

The kinetic behavior of a newly isolated Saccharomyces cerevisiae strain, grown on pasteurized grape musts enriched with industrial sugars, was studied after the addition of various concentrations [0.0 (reference), 0.4 and 2.4 mg/L] of the fungicide quinoxyfen to the medium. Batch‐flask cultures were carried out. Significant quantities of biomass (10.0±0.8 g/L) were produced regardless of quinoxyfen addition to the medium; therefore, the addition of the fungicide did not seriously inhibit biomass production. Ethanol was synthesized in very high quantities in all trials (highest concentrations 106.4–119.2 g/L). A slight decrease of ethanol production in terms of both absolute value and conversion yield of ethanol produced per sugar consumed was, however, observed when the quinoxyfen concentration was increased. The addition of quinoxyfen led to significantly lower ethylic ester levels, which also pertains to the acetates analyzed in this study. Fusel alcohol synthesis seemed to be activated when 0.4 mg/L quinoxyfen was added, but at 2.4 mg/L of added fungicide, no statistically significant differences were observed compared with the control trial. Volatile acid levels did not present a uniform trend in relation with the added fungicide. Finally, the fermentation was accompanied by a significant reduction of the fungicide concentration (79–82 wt% fungicide removal).

Modelling of simultaneous production of polygalacturonase and exopolysaccharide by Aureobasidium pullulans ATHUM 2915

The polymorphic fungus Aureobasidium pullulans ATHUM 2915, produced significant quantities of extracellular polygalacturonase and polysaccharide when grown, under controlled conditions, in liquid medium with pectin and glucose as carbon sources and nitrogen source as limited factor. Growth, substrate consumption and products formation were simulated by a structured mathematical model, which was compared with the experimental data from batch culture in a chemostat. This model was applied successfully in the study of some essential parameters influenced the process at various pH values.

Increase in Phytase Activity and Decrease in Phytate During Germination of Four Common Legumes

Maximum phytase activity in four legume species, lentils, chick peas, broad beans and runner beans, was reached after 6 days of germination for chick peas and 8 days for the rest of them. In all legumes, the increase in phytase activity was accompanied by a concomitant decrease in phytate content. After 10 days of germination the decrease in phytate varied from 83% in broad beans up to 64% in runner beans.