Panyue Zhang

Energy-efficient sludge sonication: power and sludge characteristics.

This paper improves the energy efficiency for sludge treatment using ultrasound. The sludge organic content, solid concentration, ultrasonic intensity, and time were optimized. A new index, kWh / kgSCOD-increase, was used to evaluate the energy efficiency that covers both sludge characteristics and lysis effectiveness. The results showed that the energy efficiency of sludge sonication was in the range of 102-347kWh /kgSCOD-increase. Higher VS/TS ratio gave higher energy efficiency. Optimal solid concentration (TS) was found to be 20g /L; low TS (5.0g/L) consumed 137% more energy; while higher TS might assimilate the sound energy and decrease the efficiency. The cavitation threshold for sludge was 20-30W /cm(2), below which no sludge lysis was observed. The lowest effective sound intensity (31.4W /cm(2)) was best and saved 20-35% energy compared to higher intensities. The initial first minutes of sonication were most effective; hence intensive-short treatment was preferred.

Enhancement of anaerobic sludge digestion by high-pressure homogenization.

To improve anaerobic sludge digestion efficiency, the effects of high-pressure homogenization (HPH) conditions on the anaerobic sludge digestion were investigated. The VS and TCOD were significantly removed with the anaerobic digestion, and the VS removal and TCOD removal increased with increasing the homogenization pressure and homogenization cycle number; correspondingly, the accumulative biogas production also increased with increasing the homogenization pressure and homogenization cycle number. The optimal homogenization pressure was 50 MPa for one homogenization cycle and 40 MPa for two homogenization cycles. The SCOD of the sludge supernatant significantly increased with increasing the homogenization pressure and homogenization cycle number due to the sludge disintegration. The relationship between the biogas production and the sludge disintegration showed that the accumulative biogas and methane production were mainly enhanced by the sludge disintegration, which accelerated the anaerobic digestion process and improved the methane content in the biogas.

Effect of alkaline addition on anaerobic sludge digestion with combined pretreatment of alkaline and high pressure homogenization

To improve anaerobic digestion efficiency, combination pretreatment of alkaline and high pressure homogenization was applied to pretreat sewage sludge. Effect of alkaline dosage on anaerobic sludge digestion was investigated in detail. SCOD of sludge supernatant significantly increased with the alkaline dosage increase after the combined pretreatment because of sludge disintegration. Organics were significantly degraded after the anaerobic digestion, and the maximal SCOD, TCOD and VS removal was 73.5%, 61.3% and 43.5%, respectively. Cumulative biogas production, methane content in biogas and biogas production rate obviously increased with the alkaline dosage increase. Considering both the biogas production and alkaline dosage, the optimal alkaline dosage was selected as 0.04 mol/L. Relationships between biogas production and sludge disintegration showed that the accumulative biogas was mainly enhanced by the sludge disintegration. The methane yield linearly increased with the DDCOD increase as Methane yield (ml/gVS)=4.66 DDCOD-9.69.

Biomass and carotenoid production in photosynthetic bacteria wastewater treatment: effects of light intensity.

This study investigated the feasibility of using photosynthetic bacteria (PSB) to produce biomass and carotenoid while treating wastewater. The effects of light intensity on the biomass, carotenoid and bacteriochlorophyll accumulation in together with pollutant removal were studied. Results showed that it was feasible to use PSB to treat wastewater as well as to produce biomass or carotenoid. 2000 lux was an optimal intensity for biomass production and COD removal, and the corresponding values were 2645 mg/L and 94.7%. 8000 lux was an optimal light intensity for carotenoid production (1.455 mg/L). Mechanism analysis displayed that the greater the bacteriochlorophyll and carotenoid were secreted, the lower the light conversion efficiency turned out to be. The highest light conversion efficiency was achieved at 500 lux; the ATP production, biomass production, and COD removal were the highest at 2000 lux, but the bacteriochlorophyll and carotenoid content were the lowest at 2000 lux.

Degradation properties of protein and carbohydrate during sludge anaerobic digestion

Degradation of protein and carbohydrate is vital for sludge anaerobic digestion performance. However, few studies focused on degradation properties of protein and carbohydrate. This study investigated detailed degradation properties of sludge protein and carbohydrate in order to gain insight into organics removal during anaerobic digestion. Results showed that carbohydrate was more efficiently degraded than protein and was degraded prior to protein. The final removal efficiencies of carbohydrate and protein were 49.7% and 32.2%, respectively. The first 3 days were a lag phase for protein degradation since rapid carbohydrate degradation in this phase led to repression of protease formation. Kinetics results showed that, after initial lag phase, protein degradation followed the first-order kinetic with rate constants of 0.0197 and 0.0018 d(-1) during later rapid degradation phase and slow degradation phase, respectively. Carbohydrate degradation also followed the first-order kinetics with a rate constant of 0.007 d(-1) after initial quick degradation phase.

Biomass and pigments production in photosynthetic bacteria wastewater treatment: effects of light sources.

This study is aimed at enhancing biomass and pigments production together with pollution removal in photosynthetic bacteria (PSB) wastewater treatment via different light sources. Red, yellow, blue, white LED and incandescent lamp were used. Results showed different light sources had great effects on the PSB. PSB had the highest biomass production, COD removal and biomass yield with red LED. The corresponding biomass, COD removal and biomass yield reached 2580 mg/L, 88.6% and 0.49 mg-biomass/mg-COD-removal, respectively. The hydraulic retention time of wastewater treatment could be shortened to 72 h with red LED. Mechanism analysis showed higher ATP was produced with red LED than others. Light sources could significantly affect the pigments production. The pigments productions were greatly higher with LED than incandescent lamp. Yellow LED had the highest pigments production while red LED produced the highest carotenoid/bacteriochlorophyll ratio. Considering both efficiency and energy cost, red LED was the optimal light source.

Spectroscopic analysis and biodegradation potential study of dissolved organic matters in sewage sludge treated with high-pressure homogenization.

The effect of high-pressure homogenization (HPH) treatment on characteristics of dissolved organic matters (DOM) in sewage sludge was investigated. Soluble chemical oxygen demand (SCOD), dissolved organic carbon (DOC), protein and polysaccharide concentration in sludge supernatant significantly increased after HPH treatment. Fourier-transform infrared (FTIR) spectra showed that the main components in the DOM for raw sludge were protein and polysaccharide, while for the treated sludge were protein, polysaccharide and lipid. The spectra of fluorescence excitation-emission matrix (EEM) for DOM showed two protein-like peaks at the excitation/emission wavelengths (Ex/Em) of 225/330-340 nm and 275/310-335 nm. A single broad shoulder representing substances with aromatic structure in range 245-270 nm was found in ultraviolet (UV) spectra of the DOM for the treated sludge. Homogenization pressure and homogenization cycle number affected the content of aromatic carbon per unit DOC. The maximum BOD5/SCOD ratio of 0.48 was achieved at 60 MPa with a single homogenization cycle.

Sewage sludge disintegration by combined treatment of alkaline+high pressure homogenization.

Alkaline pretreatment combined with high pressure homogenization (HPH) was applied to promote sewage sludge disintegration. For sewage sludge with a total solid content of 1.82%, sludge disintegration degree (DD(COD)) with combined treatment was higher than the sum of DD(COD) with single alkaline and single HPH treatment. NaOH dosage ⩽0.04mol/L, homogenization pressure ⩽60MPa and a single homogenization cycle were the suitable conditions for combined sludge treatment. The combined sludge treatment showed a maximum DD(COD) of 59.26%. By regression analysis, the combined sludge disintegration model was established as 11-DD(COD)=0.713C(0.334)P(0.234)N(0.119), showing that the effect of operating parameters on sludge disintegration followed the order: NaOH dosage>homogenization pressure>number of homogenization cycle. The energy efficiency with combined sludge treatment significantly increased compared with that with single HPH treatment, and the high energy efficiency was achieved at low homogenization pressure with a single homogenization cycle.

Microwave assisted alkaline pretreatment to enhance enzymatic saccharification of catalpa sawdust.

Catalpa sawdust, a promising biofuel production biomass, was pretreated by microwave-water, -NaOH, and -Ca(OH)2 to enhance enzymatic digestibility. After 48h enzymatic hydrolysis, microwave-Ca(OH)2 pretreated sample showed the highest reducing sugar yield. The content of hemicellulose and lignin in catalpa sawdust decreased after microwave-alkali pretreatment. SEM observation showed that the catalpa sawdust surface with microwave-Ca(OH)2 pretreatment suffered the most serious erosion. Crystallinity index of catalpa sawdust increased after all three kinds of pretreatment. The optimum conditions of microwave-Ca(OH)2 pretreatment were particle size of 40mesh, Ca(OH)2 dosage of 2.25% (w/v), microwave power of 400W, pretreatment time of 6min, enzyme loading of 175FPU/g, and hydrolysis time of 96h, and the reducing sugar yield of microwave-Ca(OH)2 pretreated catalpa sawdust reached 402.73mg/g, which increased by 682.15% compared with that of raw catalpa sawdust. The catalpa sawdust with microwave-Ca(OH)2 pretreatment is promising for biofuel production with great potential.

Biomass and pigments production in photosynthetic bacteria wastewater treatment: effects of photoperiod.

This study aimed at enhancing the bacterial biomass and pigments production in together with pollution removal in photosynthetic bacteria (PSB) wastewater treatment via using different photoperiods. Different light/dark cycles and light/dark cycle frequencies were examined. Results showed that PSB had the highest biomass production, COD removal and biomass yield, and light energy efficiency with light/dark cycle of 2h/1h. The corresponding biomass, COD removal and biomass yield reached 2068mg/L, 90.3%, and 0.38mg-biomass/mg-COD-removal, respectively. PSB showed higher biomass production and biomass yield with higher light/dark cycle frequency. Mechanism analysis showed within a light/dark cycle from 1h/2h to 2h/1h, the carotenoid and bacteriochlorophyll production increased with an increase in light/dark cycle. Moreover, the pigment contents were much higher with lower frequency of 2-4 times/d.