T. L. Wheeler

Seasonal Prevalence of Shiga Toxin–Producing Escherichia coli, Including O157:H7 and Non-O157 Serotypes, and Salmonella in Commercial Beef Processing Plants†

The seasonal prevalence of Escherichia coli O157:H7, Salmonella, non-O157 E. coli (STEC), and stx-harboring cells was monitored at three Midwestern fed-beef processing plants. Overall, E. coli O157:H7 was recovered from 5.9% of fecal samples, 60.6% of hide samples, and 26.7% of carcasses sampled before the preevisceration wash. This pathogen also was recovered from 1.2% (15 of 1,232) of carcasses sampled at chilling (postintervention) at approximate levels of <3.0 cells per 100 cm2. In one case, the E. coli O157:H7 concentration dropped from ca. 1,100 cells per 320 cm2 at the preevisceration stage to a level that was undetectable on ca. 2,500 cm2 at the postintervention stage. The prevalence of E. coli O157:H7 in feces peaked in the summer, whereas its prevalence on hide was high from the spring through the fall. Overall, Salmonella was recovered from 4.4, 71.0, and 12.7% of fecal, hide, and preevisceration carcass samples, respectively. Salmonella was recovered from one postintervention carcass (of 1,016 sampled). Salmonella prevalence peaked in feces in the summer and was highest on hide and preevisceration carcasses in the summer and the fall. Non-O157 STEC prevalence also appeared to vary by season, but the efficiency in the recovery of isolates from stx-positive samples ranged from 37.5 to 83.8% and could have influenced these results. Cells harboring stx genes were detected by PCR in 34.3, 92.0, 96.6, and 16.2% of fecal, hide, preevisceration carcass, and postintervention carcass samples, respectively. The approximate level of non-O157 STEC and stx-harboring cells on postintervention carcasses was > or = 3.0 cells per 100 cm2 for only 8 of 199 carcasses (4.0%). Overall, the prevalence of E. coli O157:H7, Salmonella, and non-O157 STEC varied by season, was higher on hides than in feces, and decreased dramatically, along with pathogen levels, during processing and during the application of antimicrobial interventions. These results demonstrate the effectiveness of the current interventions used by the industry and highlight the significance of hides as a major source of pathogens on beef carcasses.

Meat tenderness and muscle growth: is there any relationship?

Our objectives for this manuscript are to review the mechanisms of muscle growth, the biological basis of meat tenderness, and the relationship between these two processes. Muscle growth is determined by hyperplasia and hypertrophy. Muscle cell size is determined by the balance between the amount of muscle protein synthesized and the amount of muscle protein degraded. Current evidence suggests that the calpain proteolytic system is a major regulator of muscle protein degradation. Sarcomere length, connective tissue content, and proteolysis of myofibrils and associated proteins account for most, if not all, of the explainable variation in tenderness of meat after postmortem storage. The relative contribution of each of the above components is muscle dependent. The calpain proteolytic system is a key regulator of postmortem proteolysis. While changes in muscle protein degradation affect meat tenderization/tenderness, changes in muscle protein synthesis are not expected to affect meat tenderization/tenderness.

Post-harvest interventions to reduce/eliminate pathogens in beef.

In 1999 the foodborne pathogens Salmonella, Listeria, Campylobacter, and Escherichia coli (both O157 and non-O157) were estimated to cause more than 6 million illnesses and approximately 9000 deaths each year. However, the most recent Centers for Disease Control and Prevention report on the sources and incidence of foodborne disease, released in 2004, has shown a dramatic decrease in E. coli O157:H7 infections. Since raw beef products are the most frequently foodborne sources of these pathogens, the results of this report demonstrate that the microbiological quality of raw beef has improved greatly. During the intervening years, post-harvest interventions have continually improved, with new attention to hide decontamination and innovative treatments of carcasses. In addition, a system to hold and test beef trim or ground beef for E. coli O157:H7 before its release into commerce has provided an even greater level of safety. In this paper, we review the latest information on the prevalence of E. coli O157:H7 and other pathogens on beef, the evidence identifying the hide as the primary source of pathogens on beef carcasses, the efficacy of various hide and carcass interventions, and other developments that have led or have the potential to lead to even greater improvements in the microbial quality of beef.

Characterization of biological types of cattle (Cycle VIII): carcass, yield, and longissimus palatability traits.

The objective of this experiment was to evaluate alternative sources of tropically adapted cattle germplasm and compare them with Angus- (AN) and Hereford- (HE) sired steers. Carcass, yield, and longissimus thoracis palatability traits from F(1) steers (n = 621) obtained from mating AN and MARC III cows to HE, AN, Brangus (BR), Beefmaster (BM), Bonsmara (BO), or Romosinuano (RO) sires were compared. Data were adjusted to constant age (426 d), carcass weight (340 kg), fat thickness (1.0 cm), fat trim percentage (25%), and marbling (Small(00)) endpoints. For Warner-Bratzler and slice shear force and trained and untrained sensory panel traits, data were obtained on LM from ribeye steaks stored at 2 degrees C for 14 or 15 d postmortem. The following comparisons were from the age-constant endpoint. Carcasses from BM-, AN-, and BR-sired steers (358, 355, and 351 kg, respectively) were heavier (P < 0.05) than carcasses from steers from HE (343 kg) and BO (331 kg) sires; RO-sired steers (318 kg) had the lightest (P < 0.05) carcasses. Adjusted fat thicknesses for AN- and BM-sired steers (1.3 and 1.2 cm, respectively) were greater (P < 0.05) than for steers from BR (1.0 cm) and BO (0.9 cm) sires; RO-sired steers (0.8 cm) had the least fat thickness. Longissimus areas were larger (P < 0.05) for BO- and BR-sired steers (84.4 and 84.1 cm(2), respectively) than for BM- and HE-sired steers (80.8 and 80.2 cm(2), respectively). A greater (P < 0.05) percentage of carcasses from AN-sired steers graded USDA Choice (69%) than other sire breeds (17 to 47%) except HE (52%). Carcass yield of boneless, totally trimmed retail product was least (P < 0.05) for AN-sired steers (60.1%) and greatest (P < 0.05) for RO- and BO-sired steers (64.4 to 63.5%). Considering all measurements, AN LM tended to be more tender and BM LM tended to be least tender. American composite breeds BM and BR were heavier, fatter, lesser yielding, with similar marbling scores but less tender LM than BO and RO. Angus carcasses were similar in size, fatter, lesser yielding, with more marbling and more tender LM compared with BM and BR. Bonsmara and RO provide tropically adapted germplasm and produce carcasses that are lighter, leaner, greater yielding, with similar marbling and LM that tend to be more tender than carcasses from BM and BR.

Transportation and lairage environment effects on prevalence, numbers, and diversity of Escherichia coli O157:H7 on hides and carcasses of beef cattle at processing.

Hide has been established as the main source of carcass contamination during cattle processing; therefore, it is crucial to minimize the amount of Escherichia coli O157:H7 on cattle hides before slaughter. Several potential sources of E. coli O157: H7 are encountered during transportation and in the lairage environment at beef-processing facilities that could increase the prevalence and numbers of E. coli O157:H7 on the hides of cattle. On three separate occasions, samples were obtained from cattle at the feedlot and again after cattle were stunned and exsanguinated at the processing plant (286 total animals). The prevalence of E. coli O157:H7 on hides increased from 50.3 to 94.4% between the time cattle were loaded onto tractor-trailers at the feedlot and the time hides were removed in the processing plant. Before transport, nine animals had E. coli O157:H7 in high numbers (> 0.4 CFU/cm2) on their hides. When sampled at the slaughter facility, the number of animals with high hide numbers had increased to 70. Overall, only 29% of the E. coli O157:H7 isolates collected postharvest (221 of 764) matched pulsed-field gel electrophoresis types collected before transport. The results of this study indicate that transport to and lairage at processing plants can lead to increases in the prevalence and degree of E. coli O157:H7 contamination on hides and the number of E. coli O157:H7 pulsed-field gel electrophoresis types associated with the animals. More study is needed to confirm the mechanism by which additional E. coli O157:H7 strains contaminate cattle hides during transport and lairage and to design interventions to prevent this contamination.

Effect of chemical dehairing on the prevalence of Escherichia coli O157:H7 and the levels of aerobic bacteria and enterobacteriaceae on carcasses in a commercial beef processing plant.

The objective of this experiment was to test the hypothesis that cleaning cattle hides by removing hair and extraneous matter before hide removal would result in improved microbiological quality of carcasses in commercial beef processing plants. To test this hypothesis, we examined the effect of chemical dehairing of cattle hides on the prevalence of Escherichia coli O157:H7 and the levels of aerobic bacteria and Enterobacteriaceae on carcasses. Samples from 240 control (conventionally processed) and 240 treated (chemically dehaired before hide removal) hides (immediately after stunning but before treatment) and preevisceration carcasses (immediately after hide removal) were obtained from four visits to a commercial beef processing plant. Total aerobic plate counts (APC) and Enterobacteriaceae counts (EBC) were not (P > 0.05) different between cattle designated for chemical dehairing (8.1 and 5.9 log CFU/100 cm2 for APC and EBC, respectively) and cattle designated for conventional processing (8.0 and 5.7 log CFU/100 cm2 for APC and EBC, respectively). However, E. coli O157:H7 hide prevalence was higher (P < 0.05) for the control group than for the treated group (67% versus 88%). In contrast to hides, the bacterial levels were lower (P < 0.05) on the treated (3.5 and 1.4 log CFU/100 cm2 for APC and EBC) than the control (5.5 and 3.2 log CFU/100 cm2 for APC and EBC) preevisceration carcasses. Prevalence of E. coli O157:H7 was lower (P > 0.05) on treated than on control preevisceration carcasses (1% versus 50%). These data indicate that chemical dehairing of cattle hides is an effective intervention to reduce the incidence of hide-to-carcass contamination with pathogens. The data also imply that any effective hide intervention process incorporated into beef processing procedures would significantly reduce carcass contamination by E. coli O157:H7.

Longitudinal Study of Escherichia coli O157:H7 in a Beef Cattle Feedlot and Role of High-Level Shedders in Hide Contamination

ABSTRACT The objectives of the study described here were (i) to investigate the dynamics of Escherichia coli O157:H7 fecal and hide prevalence over a 9-month period in a feedlot setting and (ii) to determine how animals shedding E. coli O157:H7 at high levels affect the prevalence and levels of E. coli O157:H7 on the hides of other animals in the same pen. Cattle (n = 319) were distributed in 10 adjacent pens, and fecal and hide levels of E. coli O157:H7 were monitored. When the fecal pen prevalence exceeded 20%, the hide pen prevalence was usually (25 of 27 pens) greater than 80%. Sixteen of 19 (84.2%) supershedder (>104 CFU/g) pens had a fecal prevalence greater than 20%. Significant associations with hide and high-level hide (≥40 CFU/100 cm2) contamination were identified for (i) a fecal prevalence greater than 20%, (ii) the presence of one or more high-density shedders (≥200 CFU/g) in a pen, and (iii) the presence of one or more supershedders in a pen. The results presented here suggest that the E. coli O157:H7 fecal prevalence should be reduced below 20% and the levels of shedding should be kept below 200 CFU/g to minimize the contamination of cattle hides. Also, large and unpredictable fluctuations within and between pens in both fecal and hide prevalence of E. coli O157:H7 were detected and should be used as a guide when preharvest studies, particularly preharvest intervention studies, are designed.

Salmonella and Escherichia coli O157:H7 Contamination on Hides and Carcasses of Cull Cattle Presented for Slaughter in the United States: an Evaluation of Prevalence and Bacterial Loads by Immunomagnetic Separation and Direct Plating Methods

ABSTRACT The hide and carcass hygiene of cull cattle at slaughter in four geographically distant regions of the United States was examined from July 2005 to April 2006 by measuring the aerobic plate counts (APC) and the prevalences and loads of Salmonella and Escherichia coli O157:H7. The geometric mean log10 APC CFU/100 cm2 levels on hides and preevisceration and postintervention carcasses ranged from 6.17 to 8.19, 4.24 to 6.47, and 1.46 to 1.96, respectively, and were highest in the summer (P < 0.0001). The average prevalences of Salmonella on hides and preevisceration and postintervention carcasses were 89.6% (95% confidence interval [CI], 85.1 to 94.0), 50.2% (95% CI, 40.9 to 59.5), and 0.8% (95% CI, 0.18 to 1.42), respectively. The prevalences of E. coli O157:H7 were 46.9% (95% CI, 37.3 to 56.6) and 16.7% (95% CI, 9.8 to 23.6) on hides and preevisceration carcasses, respectively. Examination of the concomitant incidence of Salmonella and E. coli O157:H7 showed that, on average, 33.3% (95% CI, 15.9 to 69.8) of cattle hide and 4.1% (95% CI, 0.98 to 17.3) of preevisceration carcass samples were contaminated with both pathogens. The pathogen prevalence on hides and carcasses was not significantly affected by the season; however, significant differences were observed between plants with respect to the incoming pathogen load and the ability to mitigate hide-to-carcass transfer. In spite of these differences, postintervention carcass contamination was significantly reduced (P < 0.001), likely as a result of the use of one or more of the processing interventions employed at each of the four processing plants examined.

Prevalence of Escherichia coli O157 and Levels of Aerobic Bacteria and Enterobacteriaceae Are Reduced When Hides Are Washed and Treated with Cetylpyridinium Chloride at a Commercial Beef Processing Plant

The objective of this experiment was to test the potential of a combined water wash and cetylpyridinium chloride (CPC) treatment as a hide intervention applied to cattle in the holding pens of a processing plant immediately before stunning. Over 2 processing days, 149 control and 139 treated cattle were tested. Control cattle were processed in the normal manner. The treatment group was prewashed with water the day before harvest. Immediately before stunning, these cattle were sprayed twice with 1% CPC, first for 3 min, then for 1 min. Hides and preevisceration carcasses were sampled to determine aerobic plate counts, Enterobacteriaceae counts (EBC), and Escherichia coli O157 prevalence. The treatment reduced the prevalence of E. coli O157 on hides from 56% to 34% and the prevalence on preevisceration carcasses from 23% to 3%. The treatment decreased aerobic plate counts from 4.9 log CFU/100 cm2 to 3.4 log CFU/100 cm2 and EBC from 3.1 log CFU/100 cm2 to 2.0 log CFU/100 cm2 on preevisceration carcasses. The treatment of hides did not result in any detectable CPC contamination of the chilled carcasses. These data indicated that a 1% CPC treatment preceded by a water wash was capable of reducing hide prevalence of E. coli O157 from as high as 80% to less than 50%, resulting in preevisceration carcass prevalence of 5% or less. We conclude that water washing followed by an antimicrobial treatment, such as CPC, has great potential as an effective hide intervention step and should be further evaluated for implementation as a processing step after stunning and before hide removal.

The relationship between ultrasound measurements and carcass fat thickness and longissimus muscle area in beef cattle.

Five hundred thirty-four steers were evaluated over a 2-yr period to determine the accuracy of ultrasonic estimates of carcass 12th-rib fat thickness (CFAT) and longissimus muscle area (CLMA). Within 5 d before slaughter, steers were ultrasonically measured for 12th-rib fat thickness (UFAT) and longissimus muscle area (ULMA) using an Aloka 500V real-time ultrasound machine equipped with a 17.2-cm, 3.5-MHz linear transducer. Overall, correlation coefficients between ultrasound and carcass fat and longissimus muscle area were 0.89 and 0.86, respectively. Correlations for UFAT with CFAT were similar between years (0.86 and 0.90), whereas the relationship between ULMA and CLMA was stronger in yr 1 (r = 0.91; n = 282) than in yr 2 (r = 0.79; n = 252). Differences between ultrasonic and carcass measurements were expressed on both an actual (FDIFF and RDIFF) and absolute (FDEV and RDEV) basis. Mean FDIFF and RDIFF indicated that ultrasound underestimated CFAT by 0.06 cm and overestimated CLMA by 0.71 cm2 across both years. Overall mean FDEV and RDEV, which are indications of the average error rate, were 0.16 cm and 3.39 cm2, respectively. Analysis of year effects revealed that FDIFF, FDEV, and RDEV were greater (P < 0.01) in magnitude in yr 1. Further analysis of FDEV indicated that leaner (CFAT < 0.51 cm) cattle were overestimated and that fatter (CFAT > 1.02 cm) cattle were underestimated with ultrasound. Similarly, steers with small CLMA (< 71.0 cm2) were overestimated, and steers with large CLMA (> 90.3 cm2) were underestimated. The thickness of CFAT had an effect (P < 0.05) on the error of UFAT and ULMA measurements, with leaner animals being more accurately evaluated for both traits. Standard errors of prediction (SEP) adjusted for bias of ultrasound measurements were 0.20 cm and 4.49 cm2 for UFAT and ULMA, respectively. Differences in SEP were observed for ULMA, but not UFAT, by year. These results indicate that ultrasound can be an accurate estimator of carcass traits in live cattle when measurements are taken by an experienced, well-trained technician, with only small differences in accuracy between years.