Sae-Eun Oh

Combined (alkaline+ultrasonic) pretreatment effect on sewage sludge disintegration.

The individual effects of alkaline (pH 8-13) and ultrasonic (3750-45,000kJ/kg TS) pretreatments on the disintegration of sewage sludge were separately tested, and then the effect of combining these two methods at different intensity levels was investigated using response surface methodology (RSM). In the combined pretreatment, ultrasonic treatment was applied to the alkali-pretreated sludge. While the solubilization (SCOD/TCOD) increase was limited to 50% in individual pretreatments, it reached 70% in combined pretreatment, and the results clearly showed that preconditioning of sludge at high pH levels played a crucial role in enhancing the disintegration efficiency of the subsequent ultrasonic pretreatment. By applying regression analysis, the disintegration degree (DD) was fitted based on the actual value to a second order polynomial equation: Y=-172.44+29.82X(1)+5.30x10(-3)X(2)-7.53x10(-5)X(1)X(2)-1.10X(1)(2)-1.043x10(-7)X(2)(2), where X(1), X(2), and Y are pH, specific energy input (kJ/kg TS), and DD, respectively. In a 2D contour plot describing the tendency of DD with respect to pH and specific energy input, it was clear that DD increased as pH increased, but it seemed that DD decreased when the specific energy input exceeded about 20,000kJ/kg TS. This phenomenon tells us that there exists a certain point where additional energy input is ineffective in achieving further disintegration. A synergetic disintegration effect was also found in the combined pretreatment, with lower specific energy input in ultrasonic pretreatment yielding higher synergetic effect. Finally, in order to see the combined pretreatment effect in continuous operation, the sludge pretreated with low intensity alkaline (pH 9)/ultrasonic (7500kJ/kg TS) treatment was fed to a 3 L of anaerobic sequencing batch reactor after 70 days of control operation. CH(4) production yield significantly increased from 81.9+/-4.5mL CH(4)/g COD(added) to 127.3+/-5.0mL CH(4)/g COD(added) by pretreatment, and this enhanced performance was closely related to the solubilization increase of the sludge by pretreatment. However, enhanced anaerobic digestion resulted in 20% higher soluble N concentration in the reactor, which would be an additional burden in the subsequent nitrogen removal system.

Continuous high-solids anaerobic co-digestion of organic solid wastes under mesophilic conditions

With increasing concerns over the limited capacity of landfills, conservation of resources, and reduction of CO(2) emissions, high-solids (dry) anaerobic digestion of organic solid waste (OSW) is attracting a great deal of attention these days. In the present work, two dry anaerobic co-digestion systems fed with different mixtures of OSW were continuously operated under mesophilic conditions. Dewatered sludge cake was used as a main seeding source. In reactor (I), which was fed with food waste (FW) and paper waste (PW), hydraulic retention time (HRT) and solid content were controlled to find the maximum treatability. At a fixed solid content of 30% total solids (TS), stable performance was maintained up to an HRT decrease to 40 d. However, the stable performance was not sustained at 30 d HRT, and hence, HRT was increased to 40 d again. In further operation, instead of decreasing HRT, solid content was increased to 40% TS, which was found to be a better option to increase the treatability. The biogas production rate (BPR), CH(4) production yield (MPY) and VS reduction achieved in this condition were 5.0m(3)/m(3)/d, 0.25 m(3) CH(4)/g COD(added), and 80%, respectively. Reactor (II) was fed with FW and livestock waste (LW), and LW content was increased during the operation. Until a 40% LW content increase, reactor (II) exhibited a stable performance. A BPR of 1.7 m(3)/m(3)/d, MPY of 0.26 m(3) CH(4)/g COD(added), and VS reduction of 72% was achieved at 40% LW content. However, when the LW content was increased to 60%, there was a significant performance drop, which was attributed to free ammonia inhibition. The performances in these two reactors were comparable to the ones achieved in the conventional wet digestion and thermophilic dry digestion processes.

Dry anaerobic digestion of food waste under mesophilic conditions: performance and methanogenic community analysis.

The performance of dry anaerobic digestion (AD) of food waste was investigated under mesophilic conditions and the methanogenic community was investigated using 454 pyrosequencing. Stable dry AD was achieved by hydraulic retention time (HRT) control without the addition of alkali agents. The average CH4 production rate, CH4 content, and volatile solid reduction rate were 2.51±0.17m(3)/m(3)/d, 66±2.1%, and 65.8±1.22%, respectively, at an HRT of 40d. The methanogenic community of the seed sludge experienced a significant reduction in genus diversity from 18 to 4 and a dominant methanogenic shift from hydrogenotrophic to acetoclastic groups after the acclimation under dry condition. Almost all sequences of the dry anaerobic digester were closely related with those of Methanosarcina thermophila with similarity of 96.4-99.1%. The experimental results would serve as useful information to understand the dry AD system.

Response Surface Optimization of Substrates for Thermophilic Anaerobic Codigestion of Sewage Sludge and Food Waste

Abstract This study investigated the effects of food waste constituents on thermophilic (55 °C) anaerobic codigestion of sewage sludge and food waste by using statistical techniques based on biochemical methane potential tests. Various combinations of grain, vegetable, and meat as cosubstrate were tested, and then the data of methane potential (MP), methane production rate (MPR), and first-order kinetic constant of hydrolysis (kH) were collected for further analyses. Response surface methodology by the Box-Behnken design can verify the effects and their interactions of three variables on responses efficiently. MP was mainly affected by grain, whereas MPR and kH were affected by both vegetable and meat. Estimated polynomial regression models can properly explain the variability of experimental data with a high-adjusted R2 of 0.727, 0.836, and 0.915, respectively. By applying a series of optimization techniques, it was possible to find the proper criteria of cosubstrate. The optimal cosubstrate region was suggested based on overlay contours of overall mean responses. With the desirability contour plots, it was found that optimal conditions of cosubstrate for the maximum MPR (56.6 mL of CH4/g of chemical oxygen demand [COD]/day) were 0.71 g of COD/L of grain, 0.18 g of COD/L of vegetable, and 0.38 g of COD/L of meat by the simultaneous consideration of MP, MPR, and kH. Within the range of each factor examined, the corresponding optimal ratio of sewage sludge to cosubstrate was 71:29 as the COD basis. Elaborate discussions could yield practical operational strategies for the enhanced thermophilic anaerobic codigestion of sewage sludge and food waste.

Application of low-strength ultrasonication to the continuous anaerobic digestion processes: UASBr and dry digester.

In this study, the positive effects of low-strength ultrasonication (LS-ultrasonication) on the anaerobic digestion (AD) performance were investigated by continuously operating an upflow anaerobic sludge blanket reactor (UASBr) and a dry digester. In the ultrasonicated UASBr system (1 s per min, 0.05 W/mL), ultrasonication enhanced the CH₄ production by 38% and 19% in an ambient and a mesophilic condition, respectively. In addition, a different sludge yield and a changed electron flow were observed after ultrasonication. In the ultrasonicated dry digestion system (2 s per 30 s, 0.0025 W/mL), a 40% increase in the production of CH₄ was observed after lowering the total solid content of the reactor from 12% to 10%, implying that a high solid content diminished the ultrasonic stimulation effect. Moreover, the ultrasonication strength itself appeared to be a more crucial factor than the ultrasonication density during the application of LS-ultrasonication in the AD system.

Low strength ultrasonication positively affects the methanogenic granules toward higher AD performance. Part I: physico-chemical characteristics.

To elucidate the correlation between enhanced biogas production and changed physico-chemical properties of methanogenic granules after low strength ultrasonication, in this study, the effects of low strength ultrasonication on the settling velocity, permeability, porosity, and fluid collection efficiency of the methanogenic granules were investigated. In addition, their morphological changes were visualized using a scanning electron microscopic technique. The experimental results indicate that low strength ultrasonication increased both the permeability (37%) and specific surface area (230%) of the granules through the generation of greater craters and cracks on the granular surface compared to the control granules. The penetration of nutrients and substrate into the granules was thereby enhanced, and more favorable conditions for achieving higher anaerobic performance were provided to the ultrasonicated granules. The microbial community shift caused by the changed physico-chemical properties of the methanogenic granules will be further analyzed in part II of this study.

Effect of hydraulic retention time on lactic acid production and granulation in an up-flow anaerobic sludge blanket reactor

In the present work, lactic acid (LA) production performance with granulation was investigated at various hydraulic retention times (HRTs), 8-0.5h. Glucose was used as a feedstock, and anaerobic mixed cultures were inoculated in an up-flow anaerobic sludge blanket reactor. As HRT decreased, the average diameter and hydrophobicity of the granules increased from 0.31 to 3.4mm and from 17.5% to 38.3%, respectively, suggesting the successful formation of granules. With decreasing HRT, LA productivity increased up to 16.7gLA/L-fermenter/h at HRT 0.5h. The existence of rod-shaped organisms with pores and internal channels at granule surface was observed by scanning electron microscope. Next generation sequencing revealed that Lactobacillus was the dominant microorganism, accounting for 96.7% of total sequences, comprising LA-producing granules.

Preservation characteristics of anaerobic granular sludge

SummaryThe preservation characteristics of granular sludges were investigated in terms of storing age and environmental condition. As a preservative index, physicochemical, microbiological, and morphological parameters were measured in order to quantify the change in granular sludge. Results from this research indicated that, as the anaerobic granular sludge had an outstanding preservation characteristic, UASB system could be effectively applied to the industries operating seasonally or intermittently.

Enhanced activity of methanogenic granules by low-strength ultrasonication

In this study, low-strength ultrasonication was applied at various ultrasonication densities (UDs) (0-0.1 W/mL) and ultrasonication time (UT) (0-30 min) to methanogenic granules on the purpose of increasing their activity, and eventually, enhancing the performance of upflow anaerobic sludge blanket reactor (UASBr). Batch test results showed that 5 min of ultrasonication at 0.05 W/mL was found to be the optimal conditions, resulting in the increase of dehydrogenase activity and adenosine triphosphate content by 257%, and 374%, respectively, compared to the control. These increments were confirmed by specific methanogenic activity test. When ultrasonication (UD 0.05 W/mL, UT 5 min) was irradiated every 8h during the continuous operation of UASBr, it caused a gradual drop of methanogenic activity, complete loss after 20 days. At further operation, UT was decreased to 1s but irradiated every 1 min, which resulted in a 43% higher specific CH(4) production rate.

Enhanced anaerobic digestion of livestock waste by ultrasonication: A tool for ammonia removal and solubilization

Ultrasonication was applied to lower the ammonia level in livestock waste to enhance the anaerobic digestion performance. In simulated waste tests, in spite of an identical temperature increase, a higher ammonia removal rate was observed at lower frequency. This could be explained by the existence of athermal effects, accounting for 64% of the total ammonia removal rate. These effects originated from various convections (micro-streaming, micro-convection, shock-waves, and micro-jets), possibly caused by stable bubbles, and this indigenous mixing ability led to a negligible effect of aeration in the ultrasound assisted ammonia stripping process. In actual waste tests, an ammonia removal rate of up to 55% was achieved with a 0.77 h−1 mass transfer rate coefficient. After ultrasonication (28 kHz, pH 11, 15 min) of livestock waste, 58% higher CH4 yield was achieved due to the decrease of ammonia concentration (28%) and enhanced solubilization (51%).