C. Paredes

Maturity and stability parameters of composts prepared with a wide range of organic wastes

Seven different composts were prepared ,(n a pilot plant by the Rutgers static-pile system using a wide range of wastes: sewage sludge, poultry manure, pig slurry, olivemill wastewater city refuse and the lignocellulosic wastes cotton waste, maize straw and sweet sorghum bagasse. Their chemical and biological properties were studied at four stages of the composting process: in the initial mixture, at the thermophilic phase, at the end of the active phase and after two months of maturation. The following maturity indices were established: CIN<12, C&1.7%, Cw/N0,<0.55 NHJNOs< 0.16, and NH4-N <0.04%, with a germination index greater than 50%. In addition, some carbon mineralization parameters could also be used as maturity indices: mineralized-c in 70 days (C,,,) ~3070, rapidly mineralizable-C (C,) < 7.270 and a slow mineralization rate (C, x KS) ~0.357~ day-‘. Maturation indices based on humification of the organic matter and the cation exchange capacity of different composts could not be found, since the values for mature compost depended on the wastes from which the composts were made. 0 1998 Elsevier Science Ltd.

Nitrogen transformation during organic waste composting by the Rutgers system and its effects on pH, EC and maturity of the composting mixtures.

The evolution of the different forms of nitrogen during the composting of several wastes was studied, as well as its relation to the pH, electrical conductivity and parameters of maturity of the composts obtained. Four mixtures were prepared from different organic materials: sewage sludge, municipal solid waste, brewery sludge, sorghum bagasse, cotton waste and pine bark. The evolution of the different forms of nitrogen during composting depended on the material which supplied the nitrogen to the mixtures and the organic matter (OM) degradation rate during composting. The greatest concentration of ammonium was observed during the first weeks of composting, coinciding with the most intense period of OM degradation, and ammonium then decreased gradually to reach final values of below 0.04%. The use of urea as a nitrogen source in the mixtures led to high ammonium levels during the first weeks as a result of its rapid hydrolysis. The nitrification process began only when the temperature of the mixtures had dropped below 40 degrees C and its intensity depended on the quantity of ammonium present when the process began. The highest concentrations of NO3-N were always produced at the end of maturation, reaching values of 0.52%, 0.53%, 0.12% and 0.20% in the four mixtures studied. Nitrogen losses during composting depended on the materials used and on the pH values of the mixtures. Mixtures with the highest lignocellulose content showed the lowest losses (below 25%), while those containing municipal solid waste lost more than 40% of the initial content. Statistically significant correlations at a high probability level were found between the NO3-N concentration and pH and electrical conductivity. confirming that nitrification was responsible for the falling pH values and increasing electrical conductivity. The ratio of NH4-N and NO3-N concentrations was shown to be a clear indicator of the maturity of the mixtures during composting, the final values of 0.08, 0.04, 0,16 and 0.11 for the four mixtures being equal to, or below the maximum value established as a maturity index in other materials.

Evolution of organic matter and nitrogen during co-composting of olive mill wastewater with solid organic wastes

Abstract Four olive mill wastewater (OMW) composts, prepared with three N-rich organic wastes and two different bulking agents, were studied in a pilot plant using the Rutgers system. Organic matter (OM) losses during composting followed a first-order kinetic equation in all the piles, the slowest being the OM mineralisation rate in the pile using maize straw (MS). The highest N losses through NH3 volatilisation occurred in the mixtures which had a low initial C/N ratio and high pH values during the process. Such losses were reduced considerably when MS was used as the bulking agent instead of cotton waste (CW). N fixation activity increased during the bio-oxidative phase before falling during maturation. This N fixation capacity was higher in piles with a lower NH4+-N concentration. Only the composts prepared with OMW, CW and poultry manure or sewage sludge reached water-soluble organic C (CW) and NH4+-N concentrations and CW/Norg and NH4+/NO3– ratios within the established limits which indicate a good degree of compost maturity. Increases in the cation-exchange capacity, the percentage of humic acid-like C and the polymerisation ratio revealed that the OM had been humified during composting. The germination index indicated the reduction of phytotoxicity during composting.

Characterization of olive mill wastewater (alpechin) and its sludge for agricultural purposes

Abstract Ten samples of olive mill wastewater (OMW) taken from different mills in southern Spain and other ten of OMW sludges from evaporation ponds were analysed. The aim was to study the composition of these wastes and to find relationships which would make it possible to use easily determinable parameters to ascertain their composition. Compared with other organic wastes, these materials had a high potassium concentration, a similar organic matter content and notable levels of nitrogen, phosphorus, calcium, magnesium and iron. The highest potassium concentrations were observed in the OMWs, while the sludges showed higher levels of the other nutrients, especially iron. The dry matter of the OMWs was significantly correlated with most of the parameters studied but, in the sludges, the only correlation was between the ash content and the total organic carbon and total nitrogen concentrations. The regression equations obtained permitted a rapid characterization of the OMWs from their dry matter content.

Bio-degradation of olive mill wastewater sludge by its co-composting with agricultural wastes

The use of maize straw (MS) or cotton waste (CW) as bulking agents in the composting of olive mill wastewater (OMW) sludge was compared by studying the organic matter (OM) mineralisation and humification processes during composting and the characteristics of the end products. Both composts were prepared in a pilot-plant using the Rutgers static-pile system. The use of CW instead of MS to compost OMW sludge extended both the thermophilic and bio-oxidative phases of the process, with higher degradation of polymers (mainly lignin and cellulose), a greater formation of nitrates, higher total nitrogen losses and a lower biological nitrogen fixation. The CW produced a compost with a more stabilised OM and more highly polymerised humic-like substances. In the pile with CW and OMW sludge, OM losses followed a first-order kinetic equation, due to OM degradation being greater at the beginning of the composting and remaining almost constant until the end of the process. However, in the pile with MS and OMW sludge this parameter followed a zero-order kinetic equation, since OM degraded throughout the process. The germination index indicated the reduction of phytotoxicity during composting.

Co-composting of distillery wastes with animal manures: carbon and nitrogen transformations in the evaluation of compost stability.

The aim of this work was to study the viability of recycling the solid wastes generated by the winery and distillery industry by means of co-composting with animal manures, as well as to evaluate the quality of the composts obtained. Two piles, using exhausted grape marc and cattle manure or poultry manure, respectively (at ratios, on a fresh weight basis, of 70:30), were composted by the Rutgers static pile composting system. Throughout the composting process, a number of parameters were monitored, such as pH, electrical conductivity, organic matter, water-soluble carbon, water-soluble polyphenols, different forms of nitrogen (organic nitrogen, ammonium and nitrate) and humification indices (humification ratio, humification index, percentage of humic acid-like C, polymerisation ratio and cation exchange capacity), as well as the germination index. Organic matter losses followed first-order kinetics equation in both piles, the highest organic matter mineralisation rate being observed with exhausted grape marc and cow manure. On the other hand, the mixture with the lowest C/N ratio, using exhausted grape marc and poultry manure, showed the highest initial ammonium contents, probably due to the higher and more labile N content of poultry manure. The increase in the cation exchange capacity revealed the organic matter humification during composting. In contrast, other humification parameters, such as the humification ratio and the humification index, did not show the expected evolution and, thus, could not be used to assess compost maturity. Composting produced a degradation of the phytotoxic compounds, such as polyphenols, to give composts without a phytotoxic character. Therefore, composting can be considered as an efficient treatment to recycle this type of wastes, due to composts presented a stable and humified organic matter and without phytotoxic effects, which makes them suitable for their agronomic use.

Spent mushroom substrates as component of growing media for germination and growth of horticultural plants.

This research work was conducted in order to investigate the possibility of using spent mushroom substrate (SMS) in the production of horticultural seedlings replacing part of the peat in the growing media. Three vegetable species with different salt sensitivities, the less sensitive being tomato (Lycopersicon esculentum var. Muchamiel), the moderately salt-sensitive being courgette (Cucurbita pepo L. var. Afrodite F1) and the most salt-sensitive being pepper (Capsicum annum L. var. Lamuyo F1) were grown in 12 media containing SMS of two types of mushroom (Agaricus bisporus (SMS-AB) and Pleurotus ostreatus (SMS-PO)) or a mixture of both 50% (v/v) (SMS-50), as well as peat in various ratios. The proportions of each residue in the mixtures elaborated with peat were 25%, 50%, 75% and 100% v/v residue. A substrate of 100% peat was used as control. The experiment was arranged in a completely-randomised design with two replicates per treatment under greenhouse conditions. Prior to sowing, some physical, physico-chemical and chemical properties of the growing media were determined and seed germination and fresh weight of seedling were also measured. In most of the cases, the addition of SMS to the growing media produced an increase in the pH values, salt contents, macro and micronutrient concentrations and a decrease in the water holding capacity contents in comparison to peat, whereas great differences were found in the air capacity values between SMS-based substrates and peat. Up to 75% SMS can be used in mixtures with peat for seed germination of the plant species studied. Regarding the most suitable SMS-based substrates for plant growth, any substrate could be used for tomato seedling production. However, all SMS-AB-based substrates and the media containing low dose of SMS-PO and SMS-50 were adequate for growth of courgette and pepper.

Utilisation of manure composts by high-value crops: safety and environmental challenges.

The intensification in livestock production has increased the need of efficient treatments of waste streams especially to preserve as much as possible, the nutrients into the soil-plant system. Composting is a cheap, efficient and sustainable treatment for solid wastes that is always included in any manure treatment scenario. In this paper, an overview about the environmental and safety challenges of composting of manures is made considering the compost quality requirements established by the main demanding sectors. Co-composting and additive strategies are presented as feasible options for the improvement of compost quality. For quality evaluation of manure compost, the use of both classical and innovative instrumental techniques could increase our knowledge about added properties in compost, especially those related to organic matter stability.

Effects of olive mill wastewater addition in composting of agroindustrial and urban wastes.

In order to study the suitability of olive mill wastewater (OMW) for composting, thisliquid waste was added to two different mixtures of agroindustrial and urban wastesand the composting process was compared with two other piles of similar composition,but without OMW. These four piles were studied in a pilot plant using the Rutgers staticpile system. The addition of OMW produced a greater proportion of degradable organic matter or a higher degradation rate, higher electrical conductivity values, greater losses of total N and lower nitrification than in piles without OMW. Its addition also restricted the increase of the cation exchange capacity and provoked the appearance of phytotoxicity or a longer persistence of phytotoxicity. However, in general, all the composts showed increases in the cation exchange capacity, the percentage of humic acid-like carbon, the polymerisation ratio of these humic substances (which revealed that the organic matter had been humified during composting) and the germination index, the latter indicating the reduction of phytotoxicity during the process.

Use of Olive Mill Wastewater Compost for Crop Production

Abstract Vast amounts of olive mill wastewaters (OMW) are produced in Mediterranean countries, where their treatment and disposal are becoming a serious environmental problem. Increasing attention has been paid to discovering a use for OMW and a wide range of technological treatments are available nowadays for reducing their pollutant effects and for their transformation into valuable products, the most suitable procedures being found to involve recycling rather than the detoxication of these wastes. Direct application of OMW to soil has been considered as an inexpensive method of disposal and recovery of their mineral and organic components but, because of their organic acid and phenol contents, OMW are also a source of pollution. By using composting technologies, it is possible to transform either fresh OMW or sludge from pond-stored OMW mixed with appropriate plant waste waterials (carriers) into organic fertilizers (composts) with no phytotoxicity to improve soil fertility and plant production, the process involving the microbial degradation of the polluting load of the wastes. Results of field and pot experiments using OMW-composts to cultivate horticultural and other crops have shown that yields obtained with organic fertilization are similar, and sometimes higher, to those obtained with a balanced mineral fertilizer. A comparison between the macro and micronutrient contents of plants cultivated with organic or mineral fertilizers did not generally reveal important differences. However, the cases of iron and manganese are worth mentioning as their bio-availability may be linked to the soil humic complexes originated by the OMW organic fertilizers.